Ford Power Train Clutch Assembly Pedal/linkage
Car-and-Safety.com | FORD>FORD Power Train Clutch Assembly Pedal/linkage
Ford Power Train Clutch Assembly Pedal/linkage Reports
16 Mar
| FORD MUSTANG 1994 | The Clutch Cable Popped Purchase car new . tt |
| FORD F350 1993 | The Clutch Linkage Split.please describe. tt |
| FORD F150 1989 | Clutch And Brake Pedal Became stiff. tt |
| FORD RANGER 1993 | Replace Clutch Plate Cylinder, due to an acceleration problem. tt |
| FORD F350 1999 | Clutch Pedal Will Not Return when applied. vehicle taken to dealer, and was informed of a yoke failure. repairs were |
| FORD RANGER 2001 | Vehicle Experiencing Loss Of Power whenever air conditioner is being used. vehicle been in dealer shop on three occasions, and problem still reoccurring. |
| FORD EXPLORER 1992 | When Clutch Pedal Was depressed clutch didn't engage. dealership will be made aware of problem. *ak |
| FORD F350 1999 | Manual Transmission Clutch Rod Cylinder broke while shifting to make a turn. was going only 25mph on a back road. was able to |
| FORD F 450 SD 2000 | While Traveling And Depressing Clutch, pedal would not depress. consumer stopped vehicle by depressing brake pedal. *ak clutch plate |
| FORD RANGER 1994 | Clutch Leaks From Slave cylinder when applying clutch in cold weather. dealer notified, and informed consumer that vehicle was not covered |
| FORD F150 1993 | Due To Design Of clutch pedal assembly which is located under dash, clip on rod is held by brackets which are |
| FORD ESCORT 1989 | Vehicle Stalls Alot, Especially when it rains. owner has to blow dry distributor cap before vehicle will start again. also, |
| FORD F 150 1995 | Vehicle Failed To Start. voltage on instrument panel not showing vehicle receiving any voltage. might be related to interlock switch on clutch. |
| FORD AEROSTAR 1990 | Plastic Snap Retainer Bushing Holding the clutch push rod no longer holds push rod.*ak push rod fell off of the stud making |
| FORD F450 1991 | Consumer Has Had Several Problems with vehicle. rear axle/flywheel and clutch pressure plates have all been replaced 3 times each. |
| FORD FOCUS 2000 | When Accelerating From A Stop clutch spring broke, causing the pedal to remain on the floorboard. vehicle has been in the shop |
| FORD FOCUS 2000 | Consumer Was Driving And The spring in the clutch pedal broke/popped up & hit the consumer in the leg. it made the vehicle |
| FORD F 450 SD 1999 | The Clutch Assembly Got Stuck due to a defective clutch plate, causing vehicle to stall which could cause a crash. |
| FORD F350 1993 | While Driving And stepping on the clutch to reduce speed, clutch broke down, and the pedal went to the floor |
| FORD F 150 2000 | While At A Dead Stop foot slipped off the clutch, and consumer bounced into the back of another car. upon impact, |
| FORD F150 1993 | While Shifting The Clutch The eyelet exploded, causing the gear to go into neutral, not allowing the driver to shift. |
| FORD F350 2000 | Clutch Assembly Springs Separated From the clutch on three occasions. dealer repaired vehicle three times in three weeks. manufacturer |
| FORD RANGER 1996 | When Traveling The Pivot Bracket which is attached to the firewall has broken, causing unwanted acceleration, resulting in a near crash. consumer |
| FORD F 150 1999 | Clutch Does Not Engage Properly with the application of the clutch pedal. the clutch can be pressed, but will not engage which causes |
| FORD RANGER 1997 | Cruise Control Is Engaged,climbing a small rise. also, needs to shift manually from 5th to 4th gear. when |
| FORD F 450 SD 1999 | Vehicle Experienced Problem With clutch pedal located to close to the floor which caused vehicle to move, even when clutch pedal was fully |
| FORD WINDSTAR 1995 | Forward Clutch Piston Cracked , causing vehicle to behave like it was in neutral. also, when transmission would finally kick |
| FORD F 150 1995 | Push Rod Broke, Not allowing vehicle to shift gears. the dealer has been notified. *ak |
| FORD F800 1998 | Clutch Release Linkage Fell Apart, causing extended stopping distance, and could have resulted in an accident. please provide further information. |
| FORD F150 1993 | Clutch Assembly Fails Too Soon, is not designed to last, replacement occurred at 63,000 miles ,and needs replacing again. dealer |
| FORD F 350 1995 | Clutch Linkage Failed Twice While driving, leaving consumer sitting. dealer was contacted. after the first failure the linkage was replaced. |
| FORD TAURUS 1995 | Piston In The Foward Clutch plate has gone bad, causing the vehicle not to go into the drive gear. dealer has been contacted. |
| FORD F SERIES 1994 | The Plastic Bushing Used On the clutch plate broke while the consumer was driving, inableing the consumer to shift the vehicle into gear. |
| FORD ASPIRE 1995 | Clutch Cable Broke, Causes vehicle accelerate forward whenever consumer left off clutch pedal. found cracked bracket which held cable as the |
| FORD WINDSTAR 1995 | Van Does Not Accelerate or take off after coming to a complete stop. dealer diagnosed a defective forward clutch piston as |
| FORD F250 1993 | The Clutch Master Cylinder assembly bushing that holds the clutch arm that goes through the fire arm plastic piece, breaks/snaps and clutch goes |
| FORD WINDSTAR 1995 | The Forward Clutch Piston Is cracked because its made of aluminum, ford is aware of the problem, dealer cannot duplicate the problem. |
| FORD F 250 1995 | Master And Slave Cylinders Keep going out and the two work together to make the clutch. dealer cannot duplicate the problem. *ak |
| FORD F250 1993 | The Clutch Linkage Comes off the clutch arm , causing the vehicle not be able to shift gears or brake, which may |
| FORD F250 1993 | Going 15mph, Pressed The clutch pedal. went to floor. stopped vehicle. checked problem. noticed piece on ground had broken. |
| FORD AEROSTAR 1994 | Was Driving Vehicle About 40mph. noticed vehicle started going in neutral. took to dealer & nothing was done by mechanics. decided |
| FORD F350 1993 | The Clutch Rod Made out of plastic, caused the clutch to break and disabled the clutch, causing the truck not to be |
| FORD WINDSTAR 1995 | Foward Clutch Piston Was Built in aluminum instead of steel, piston then split, causing the foward and reverse to be inopertive , |
| FORD F350 1993 | Owner States That While Driving the clutch slave cylinder goes out. this is 5th time problem has occurred. cause is undetermined. |
| FORD TAURUS 1993 | Clutch Piston Gives Out While pulling from a stand still, vehicle feels like it's in neutral even when its in gear. *ak |
| FORD MUSTANG 1994 | The Vehicle's Four Brackets That are welded to hold the clutch broke off, causing a snap noise when switching gears and can result |
| FORD RANGER 1996 | Owner States That His Vehicle was able to start without the clutch being depressed, owner's vehicle went into reverse and out of driveway. |
| FORD F350 1990 | Fluid Leaked From Clutch Slave cylinder lined and vibrated along exhaust manifold which resulted in a fire. *ak |
| FORD F 350 1994 | Clutch Assembly Slave Cylander Actuator has been replaced 5 times, part is located too close to exhaust which causes it to melt. |
| FORD TAURUS 2001 | The Brake And Gas Pedal are to close together when apply please provide additional information dealer is aware of the problem. ts |
| FORD RANGER 2001 | Consumer States While Driving Clutch pedal fell to the floor, and would not come back up. took to dealer and they |
| FORD EXPLORER 2000 | Consumer States Of Having Problems with the transmission. dealer was contacted. ts |
| FORD F350 1993 | While Driving Consumer Tried To push clutch in the bushing broke, and the linkage fell apart, making clutch inoperative. *akconsumer had |
| FORD F350 1999 | While Driving On A Flat surface at 15mph, the vehicle lost its clutch. making it hard to stop the vehicle. |
| FORD F650 2001 | Hydraulic Cylinder Clutch Pedal Malfunctioned, causing vehicle to accelerate when applying brakes. dealer has replaced cylinder three times. please |
| FORD RANGER 2001 | While Trying To Shift From second to third gear clutch pedal moved freely, consumer unable to use clutch to shift. gear lever had |
| FORD F250 1999 | While Driving 10 Mph Consumer was not able to shift gears. vehicle was towed to dealer. dealer determined that clutch fork had broken. |
| FORD ESCORT 1995 | While Exiting Freeway Applied Clutch, went to floor without stopping action, gears locked up, no warning, speed 45 mph, caused |
| FORD F 450 SD 1999 | Vehicle Would Not Go Into gear and sometimes would pop out of gear. clutch disc broke where springs fell out. took vehicle to |
| FORD FOCUS 2000 | While Driving 20 Mph Consumer applied clutch pedal, it went to the floor. dealer replaced a broken spring on clutch assembly. |
| FORD MUSTANG 2000 | At Certain Rpms And Without warning clutch and pedal rattle continuously. mechanic has been notified; however, mechanic stated there was nothing |
| FORD F250 1987 | Consumer Was Driving And The clutch came apart, purchased truck used from someone. please describe .*ak |
| FORD F250 2000 | Hydraulic Clutch Has failed two times while traveling less than 5 mph. dealership has replaced clutch disc assembly in |
| FORD THUNDERBIRD 1992 | Gas Pedal Sticking To The floor. *et |
| FORD TAURUS 1994 | Clutch Piston/clutch Pack/drive Chain, and epc solenoid failed. |
| FORD TAURUS 1994 | Clutch Piston Failure. |
| FORD F 150 1997 | 2/01 Vehicle Was Brought To lithia ford in concord to diagnose over heating. cooling system was checked and stated c.s. was holding |
| FORD WINDSTAR 1995 | Forward Cluth Piston - Transmission problems in first geat and reverse. *ak |
| FORD MUSTANG 2001 | Special Gas/brake/clutch Pedals In Mustang gt bullitt edition (only) can slip out from under foot when foot pressure is applied in wet and especially soapy |
| FORD F250 2001 | Without Warning The Hydraulic Line from the master clutch cylinder ?term came off and rendering the clutch completely useless (pedal went to the floor and |
| FORD MUSTANG 1997 | Clutch Pedal Will Rattle At specific low speeds. *ak |
| FORD CONTOUR 1998 | Clutch Hydraulic Cable Has Burst three times within 23000 miles. *ak |
| FORD RANGER 2001 | Problem 1- Vehicle Regularly stalls or idles so low power steering and power brakes are lost. problem occurs when slowing for and |
| FORD F250 2001 | Hose Blew Out Of The bottom of clutch master cyclinder due to the keeper pin missing. this caused the clutch pedal to go |
| FORD TAURUS 1997 | Ford Referred To Their Service bulletin number 98-3-7 when this problem occurred. after researching the forward clutch piston failure i found that this is |
| FORD EXPLORER 1991 | Periodically, When Beginning To contact the clutch pedal and if the explorer operator's left foot is too high, the top of the foot |
| FORD ESCAPE 2001 | Cable Came Off Clutch Pedal under the dash. pedal went completely to floor and was unable to shift care. cable was |
| FORD FOCUS 2000 | The Clutch Pedal Spring Split in half while at a stop light on a road with a posted speed limit of 45 miles an hour. |
| FORD MUSTANG 1989 | The Gear Shift Would Not change gears unless car was off. also clutch cable broke, and the gears grind going in reverse. |
| FORD RANGER 1998 | Clutch Pedal About 1 1/2" free play. warranty work performed @ airport marina ford on 05/16/00, 05/22/00,08/16/00, 08/24/00.clutch pedal |
| FORD MUSTANG 1999 | This Is The Third Pressure plate replacement that has been put into this car. i now have a one of a kind hand |
| FORD F150 1992 | Clutch Master Cylinder Rod Connects to clutch pedal with plastic bushing,the bushing wears out and clutch linkage falls off.if this happens while driving |
| FORD F SUPER DUTY 1999 | Clutch/clutch Hydraulic Intermittent Failure. excessive free travel in clutch pedal and insufficient clutch pedal reserve(clutch begins to engage with pedal nearly bottomed and |
| FORD F 150 1995 | On My 1995 Ford F-150 p/u truck, there is a clutch linkage rod which goes through the neutral safety switch and impacts/interacts with the |
| FORD WINDSTAR 1998 | I Have Had My 1998 ford windstar for less than one year. it has been out of service for transmission problems 4 times. |
| FORD RANGER 1998 | Load 'squeal' Heard When Releasing clutch pedal between 1st-2nd, 2nd-3rd, 2wd & 4x4 high. will be serviced for the 3rd time |
| FORD WINDSTAR 1995 | I Was Stopped At A traffic light. the light changed for me to go and i pressed on the gas. the |
| FORD WINDSTAR 1995 | Transmission Slippage - Defect Was aluminum forward clutch piston cracked. |
| FORD ESCORT 1998 | Transmission Mounts Broke, Causing transmission problems. nlm |
| FORD RANGER 1995 | Throw Out Bearing Failure. *aw |
| FORD MUSTANG 1995 | Throw Out Bearing Failed. |
| FORD WINDSTAR 1995 | The Transmission Failed Because Of the failure of the forward clutch piston.consumer is asking for rembursement because the complain, clunking when shifting the |
| FORD TAURUS 1994 | The Transmission Forward Clutch Piston was cracked while stopped at a traffic light causing the vehicle not to move. nlm |
| FORD F 150 1999 | Clutch Failed To Disengage Occassionally. yh |
| FORD ESCORT 1995 | The Clutch Pedal Is Missing/fell off. yh |
| FORD F 150 1994 | With Clutch Pedal Depressed And transmission in gear, vehicle moves without warning. failure is dut to the clutch slave cylinder leaking fluid |
| FORD TAURUS 1994 | Forward Clutch Piston Cracked Causing transmission to slip as per tsb 94-24-7 sequence #080. nlm |
| FORD TAURUS 1994 | Transmission/clutch Failure. |
| FORD WINDSTAR 1995 | Forward Clutch Piston Cracked Resulting in clutch leakage and engagement problems. |
| FORD F 250 1995 | Clutch Has Failed Five Times, approximately every 20,000 miles. |
| FORD F 250 1995 | Retaining Clip Broke Allowing Plastic rod that connects the clutch pedal shaft to the clutch slave cylinder to disengage. |
| FORD F150 1992 | Clutch Pedal Is No Longer connected to the clutch. |
| FORD RANGER 1993 | Shifter Knob Breaks Off While shifting transmission. |
| FORD WINDSTAR 1995 | Fort Clutch Piston Motor Failed. |
| FORD RANGER 1998 | Clutch Pedal Is Spongy. travels half its normal distance when dwpressed before engaging transmission. |
| FORD MUSTANG 1996 | Vibration In The Clutch. |
| FORD PROBE 1993 | Problem With Noisy Throw-out Bearings, bearing replaced once. |
| FORD F 350 1995 | Clutch Failure. |
| FORD MUSTANG 1997 | Second Gear Grinds When Shifted. clutch pedal vibrates badly and makes pounding noise. |
| FORD TAURUS 1994 | Forward Clutch Piston Recall. |
| FORD PROBE 1996 | Clutch Pedal Went To The floor and did not come up. |
| FORD F250 1988 | Fire Wall In The Clutch linkage area broke, resulting in the clutch becoming very hard to disengage. |
| FORD TAURUS 1989 | Clutch Trow-out Bearing Failed. *ak |
| FORD RANGER 1992 | Clutch Throw-out Bearing/hydraulic Sleeve/pressure Plate failed. |
| FORD F350 1992 | Clutch Push Rod Becomes Disconnected allowing truck to stay in gear.*sd |
| FORD RANGER 1994 | Plastic Rod Under Clutch Pedal broke, causing clutch to fail. *dh |
| FORD MUSTANG 1994 | Clutch Cable Broke, Causing loss of control. |
| FORD MUSTANG 1994 | Clutch Pedal Becomes Stiff With heavy use, requiring replacement twice. |
| FORD F150 1988 | Clutch Pedal Broke Away From mounting on firewall, making it impossible to shift gears. *tw |
| FORD F150 1993 | Assembly Of Foot Pedal Positioned incorrectly. *sd |
| FORD EXPLORER 1992 | Leaking Seals Twice, Causing transmission failures. *skd |
| FORD RANGER 1991 | Factory Installed Wrong Clutch/pressure Plate, causing failure. *skd |
| FORD F 350 2002 | Tl* The Contact Owns A 2002 ford f-350. the contact stated that the clutch pedal detached from the vehicle while driving 30 mph. |
| FORD RANGER 2009 | Tl* The Contact Owns A 2009 ford ranger. the contact stated that while driving 5 mph and attempting to shift gears, the clutch |
| FORD RANGER 1988 | I Bought A 1988 Ford ranger tan gold in color love the truck, but i went to indiana to pick my son up everything |
| FORD F 250 SD 2004 | While Driving On A 2 lane country road, i went to shift (change gears) my truck, and the clutch pedal fell off. |
| FORD E 250 1996 | I Was Stopped At An intersection with truck in gear and clutch pedal down, all of a sudden the clutch released with the |
| FORD F 350 SD 2001 | Tl*the Contact Owns A 2001 ford f350 super duty. the clutch pedal failed to engage when it was depressed. the contact |
| FORD F350 2004 | Tl*the Contact Owns A 2004 ford f-350. while driving 5 mph, the clutch pedal broke when depressed. the |
| FORD FOCUS 2002 | My Foot Pad On My clutch pedal became slippery due to leaking hydraulic fluid out of my clutch master cylinder on my 2002 ford focus |
| FORD F 350 SD 2004 | Tl*the Contact Owns A 2004 ford f350 superduty. while driving 20 mph, the clutch pedal failed. the contact stated that |
| FORD FOCUS 2005 | I Purchased A 2005 Ford focus in january 2005. approximately 14 months after the purchase the car started having major power train failure. |
| FORD EXPLORER 1998 | The 1998 Ford Explorer Accelerator pedal fell off. i was driving at 60 mph in a straight line and accelerating to 65 mph |
| FORD F250 2001 | Tl* - The Contact owns a ford f-250 super duty, and stated while vehicle was in a parking lot he stepped on the |
| FORD FOCUS 2004 | Car Stalls Without Notice. sent daughter to emergency room one time. stalls 2 different ways, while driving and sometimes when |
| FORD RANGER 1998 | While Backing My 98 Ford ranger 4.0 supercab with tow package (which has the beefier brakes) the aluminum bracket that holds the bar that |
| FORD F 150 1996 | Dt*: The Contact Stated While driving 7 mph, the clutch was depressed to slow the vehicle. upon depressing the clutch, there |
| FORD FOCUS 2002 | Clutch Pedal Disintegrated, Investigated it and found out that hydraulic fluid is leaking from clutch master cylinder. dealer said it is not |
| FORD F 250 SD 2001 | The Clutch Hydraulics Spontaneously Failed while driving in traffic. one day the clutch was perfectly normal. the next day, i was driving |
| FORD FOCUS 2002 | My Foot Pad On My clutch pedal became slippery due to leaking hydraulic fluid out of my clutch master cylinder on my 2002 ford focus |
| FORD FOCUS 2003 | I Have A 2003 Zts with a 5 speed. after driving roughly 40 miles nonstop when the temperature is 85 and above, the |
| FORD F350 2001 | Dt: The Clutch Pin broke completely off. the clutch pedal went all the way to floor, and the consumer lost |
| FORD FOCUS 2001 | Clutch Pedal Failed Due To failed/defective weld, leading to damage to clutch master cylinder. weld showed indication of insufficient heat penetration. defective |
| FORD F150 1993 | While Slowing From Highway Speeds, i attempted to downshift. when i pushed in the clutch pedal, it went to the |
| FORD MUSTANG 2004 | My Gas Pedal Has Gotten stuck during wirde open throttle on my 2004 mustang svt cobra. the dealer tried to adjust the gas |
| FORD ESCAPE 2001 | 2001 Ford Escape, 61, 000 miles, clutch failure, clutch pedal went to floor, would not disengage. was on entrance |
| FORD F SUPER DUTY 2001 | Clutch Disengagement Needing More Travel until nearly touching the floor, occured over a few weeks. the clutch stopped disengaging while towing a |
| FORD ESCAPE 2003 | Accelerator Pedal Got Stuck While driving down on 96 east in michigan. i was driving about 85 mph and realized my accelerator pedal got |
| FORD F 350 SD 2000 | 2000 Ford F 350. clutch will not disengage driveline when depressed. 2 nd failure of such nature. vehicle will keep rolling in |
| FORD F 250 1995 | Recently When I Got In my 1995 f250 w/manual transmission i depressed the clutch pedal to start it up & the pedal went to the |
| FORD F 250 SD 2000 | Had A Throw Out Bearing fork break into two pieces on my 2000 f250 ford pick up. clutch became totally inoperative and the truck |
| FORD RANGER 2001 | While Slowing Down At A stop light i tried to engage my clutch pedal and gear became stif, and i could not shift out |
| FORD F 150 1994 | Problem Relates To The Bushing in the clutch pedal linkage. it fails without warning while shifting the transmission. it not only acts |
| FORD F 350 SD 2001 | My Ford F-350 Superduty Pickup truck (37,000 mi) was in gear and in motion when i stepped on the clutch pedal, prior to |
| FORD MUSTANG 2004 | When Consumer Applied The clutch pedal it caused the engine to rise up from 100 to 3000 rpms. vehicle was taken |
| FORD F 250 SD 2000 | While Driving At 50 Mph clutch did not disengage to change gears. vehicle was taken to a dealer. *ak |
| FORD F350 2002 | The Consumer Was Pulling Out of the driveway when he engaged the clutch, the clutch went to the floor, became stuck and continued |
| FORD FOCUS 2002 | Clutch Master Cylinder Leaks Clutch fluid. fluid runs down stem of clutch pedal, loosening the rubber pedal pad, which proceeds to |
| FORD F 350 SD 2001 | 2nd Failure Of Clutch Master/slave cylinder assemblies, within 40,ooo miles |
| FORD FOCUS 2000 | While Applying The Clutch Pedal at 35 mph, the driver was unable to engage the clutch to shift into the next gear. the |
| FORD F 250 SD 2001 | I Have A 2001 Ford f-250 diesel with a 6 speed manual transmission. the hydraulic clutch system has went out 3 times in less |
| FORD F 250 SD 1999 | I Have A 1999 Ford f250 superduty 6 speed manual. i have 61000 miles on it. today the clutch pedal stuck to |
| FORD F 350 SD 2002 | When Coming To A Stop or shifting the clutch will not disengage, and the pedal stays on the floor -- multiple incidents. |
| FORD F 350 SD 2002 | When Coming To A Stop or shifting the clutch will not disengage, and the pedal stays on the floor -- multiple incidents. |
| FORD F350 1993 | Clutch Master Cylinder, Push rod plastic extension fractured and broke while vehicle was in motion on the highway. the vehicle was unable |
| FORD FOCUS 2001 | I Just Bought Vehicle Used in november with 13k on it. the trunk latch was the first thing that wasn't working right. |
| FORD F 350 SD 2000 | Clutch Release Bearing (throw Out bearing) actuator arm failure resulting in movement of vehicle while clutch pedal is depressed |
| FORD TAURUS 1998 | Consumer Stated That They Would simultaneously press on the brake and gas pedal without notice causing a distraction to the consumer. dealer notified. |
On This Page
- Select and View Ford Power Train Clutch Assembly Pedal/linkage Problems
- Discuss Ford Power Train Clutch Assembly Pedal/linkage Problems
Hi my name is Dave, I have a 1997 f-150 with only a little over 63,000 mls on it. front left upper ball joint and rocker arm replaced then right side upper and lower ball joint replaced. turn signal assembly fixed the 2nd time,right side power doo my 2001 ford mustang keeps blowing the 40 amp fuse that controls the radio, power windows, cruise control. Does anybody know why this keeps happening? Already replaced the fuse 3 times and the power window switch. Help my daughter is drivin RPM light lost power 2006 Ford Freestar The first generation Mustang was my power locks doors windows and rear lights stop working until I disconnect the battery. Now that doesnt even work. Where do I start?
introduced to the public in 1964 at the World Exhibition in New York in 1964. The first generation Mustang entry
preceding two concept cars. The concept car had its power from an engine V4,
and