EXPEDITION 2005 Technical Service Bulletins

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL . AXLE SEAL LEAKS. LEAKS FROM REAR HALFSHAFT AXLE SEAL. SERVICE TIPS. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Aug 23, 2004.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Sept 01, 2004.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM . REVERSE SENSING SYSTEM DEFAULTING OFF, SETTING DIAGNOSTIC TROUBLE CODES, OR LOSING COMMUNICATION WITH DIAGNOSTIC SCAN TOOL. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Feb 01, 2005.FORD EXPEDITION 2005 had a failed SEATS . CLIMATE CONTROLLED SEAT HEATING INOPERATIVE. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Feb 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY . AXLE WHINE HOWL SERVICE WITH INDIVIDUAL PARTS INSTEAD OF AN AXLE ASSEMBLY. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Feb 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN . TINY CRACK OR CRACKS AROUND THE TRANSFER CASE DRAIN PLUG. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed SERVICE BRAKES, HYDRAULIC . BRAKE SHUDDER (ROTOR THICKNESS VARIATION) DUE TO THE NEW LOW DUST FRONT BRAKE LINING USED IN PRODUCTION, OR NEW LININGS THAT WERE INSTALLED PER TSB 04-05-02. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed SEAT BELTS:FRONT:WARNING LIGHT/DEVICES . CAN NOT DISABLE BELTMINDER USING THE PROCEDURE LISTED IN SERVICE MANUAL OR OWNER GUIDE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER . CLIMATE CONTROLLED SEAT HEATING INOPERATIVE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM:STARTER ASSEMBLY . DELAYED CRANKING WHEN KEY IS TURNED TO START. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING . MALFUNCTION INDICATOR LAMP ON WITH MISFIRE DTC'S SPARK KNOCK PISTON SCUFFING. *EH VEHICLES BUILT THROUGH 4/25/2005 - 5.4L 3V ENGINE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Dec 13, 2004.FORD EXPEDITION 2005 had a failed VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:REAR WINDOW . REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Dec 13, 2004.FORD EXPEDITION 2005 had a failed POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) . GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY . LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed SEAT BELTS:FRONT:RETRACTOR . SAFETY BELT RETRACTION SPEED. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Dec 31, 2004.FORD EXPEDITION 2005 had a failed STRUCTURE . WELD BONDING PROCEDURE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Dec 01, 2004.FORD EXPEDITION 2005 had a failed VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR . POWERFOLD MIRRORS APPEAR LOOSE OR WILL NOT LOCK IN PLACE. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Dec 01, 2004.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING . REDUCTION IN POWER 4000-4500 RPM DURING WOT WHEN ENGINE IS COLD. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 01, 2005.FORD EXPEDITION 2005 had a failed TIRES . TIRE PRESSURE MONITOR SYSTEM. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 07, 2005.FORD EXPEDITION 2005 had a failed SEAT BELTS:FRONT:WARNING LIGHT/DEVICES . INABILITY TO DISABLE THE SUPPLEMENTAL SAFETY BELT WARNING CHIME (BELTMINDER). *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 07, 2005.FORD EXPEDITION 2005 had a failed EQUIPMENT:AIR CONDITIONER . NOISE FROM A/C (AIR CONDITIONING) OR INSUFFICIENT A/C COOLING. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY . AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 01, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING . CRANK NO START LONG CRANK OR ERRATIC CRANK. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 07, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . LACK OF POWER ON ACCELERATION - MAY ALSO BE DESCRIBED AS TRANSMISSION SLIPPING, LACK OF UPSHIFT OR A HESITATION - VEHICLES BUILT 1/20/2005 - 5.4L 3-VALVE ENGINE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued May 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY . AXLE SEAL LEAKS. *EH .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Mar 07, 2005.FORD EXPEDITION 2005 had a failed COMMUNICATIONS:BACK UP ALARM . FALSE PARKING AID WARNINGS. *TT UPDATE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Apr 01, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING . INTERMITTENT CONCERNS OF MIL ON WITH VARIOUS DTCS HARD START LONG CRANK RUNS ROUGH AND OR NO CRANK. *EH OASIS APRIL 2005. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed SUSPENSION:REAR . REAR AXLE NOISE REPAIR. *SC .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . HARD START/LONG CRANK, ROUGH IDLE, ENGINE IDLE MISFIRE-MIL-DTCS P0300 THROUGH P0308, P0171, P0172, P0174, P0175, P0316, P2195, P2196, P2197, P2198. *SC .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . DIAGNOSTIC TROUBLE CODE (DTC) P0340 AND OR P0344-5.4 3V ENGINE. *SC .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Oct 03, 2005.FORD EXPEDITION 2005 had a failed VISIBILITY:REAR WINDOW WIPER/WASHER . REAR WINDOW WIPER INOPERATIVE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued July 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN . A CLUNK/THUMP NOISE FROM THE REAR WHEN THE TRANSMISSION IS ENGAGED OR SHIFTED, DURING A CHANGE IN VEHICLE DIRECTION OR ON ACCELERATION. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Apr 01, 2005.FORD EXPEDITION 2005 had a failed STEERING . STEERING WHEEL AT 65 MPH (105 KM/H) OR HIGHER. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Apr 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY . REAR AXLE NOISE REPAIR. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Apr 01, 2005.FORD EXPEDITION 2005 had a failed COMMUNICATIONS:BACK UP ALARM . FALSE PARKING AID WARNINGS. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER . CLIMATE CONTROL SEAT HEAT FUNCTION INOPERATIVE - VEHICLES BUILT PRIOR TO 3/24/2005. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 01, 2005.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM:WIRING . SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed STRUCTURE:FRAME AND MEMBERS . CLUNK/GRIND/THUMP NOISE - FRAME REPAIR PROCEDURE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued June 07, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN . CLUNK/GRIND/THUMP NOISE FROM REAR OF VEHICLE WHEN TRANSMISSION IS SHIFTED - VEHICLES BUILT BEFORE 6/13/2005. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Oct 07, 2005.FORD EXPEDITION 2005 had a failed SEATS:FRONT ASSEMBLY:POWER ADJUST . DRIVERS FRONT POWER SEAT WILL NOT MOVE FORWARD OR REARWARD. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Sept 01, 2005.FORD EXPEDITION 2005 had a failed POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . A TINY CRACK, OR CRACKS, AROUND THE TRANSFER CASE DRAIN PLUG HOLE. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Nov 14, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING . WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed TIRES . VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed WHEELS . VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM . VARIOUS ELECTRICAL CONCERNS - 3 BLOCK AUXILIARY RELAY BOX 1 CHAFING - SERVICE TIP. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM . DIAGNOSTIC TROUBLE CODES P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed TIRES . LOW TIRE INDICATOR ON - TPMS SYSTEM SENSOR WAKE UP. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2005.FORD EXPEDITION 2005 had a failed SERVICE BRAKES, HYDRAULIC:POWER ASSIST . UNINTENDED BRAKE ASSIST. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Jan 01, 2006.FORD EXPEDITION 2005 had a failed SERVICE BRAKES, HYDRAULIC . BRAKE SHUDDER. *TT .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued .FORD EXPEDITION 2005 had a failed POWER TRAIN:AUTOMATIC TRANSMISSION . UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. *KB .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued .FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . DIAGNOSTIC TROUBLE CODES (DTC) P0340, P0344, P0345, P0349. ARE FOUND. *KB .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued .FORD EXPEDITION 2005 had a failed ENGINE AND ENGINE COOLING:ENGINE . SPARK PLUG REMOVAL INSTRUCTIONS - 5.4 3V. *KB .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued .FORD EXPEDITION 2005 had a failed SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM . AIR SUSPENSION PERFORMANCE - HEIGHT SENSOR LINKAGE ARM DISENGAGING. *KB .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Aug 01, 2008.FORD EXPEDITION 2005 had a failed FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS . FORD\LINCOLN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CUSTOMER SATISFACTION PROGRAM 07M08: CERTAIN 2005 MODEL YEAR F-150, F-SUPER DUTY, EXPEDITION, AND NAVIGATOR VEHICLES WITH 5.4L 3V ENGINES-EXTENDED WARRANTY COVERA.
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued May 01, 2009.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT . FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued May 01, 2009.FORD EXPEDITION 2005 had a failed POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL . FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Apr 01, 2010.FORD EXPEDITION 2005 had a failed POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) . FORD: SOME HYBRID VEHICLES MAY EXHIBIT AN INTERMITTENT RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE DISPLAYED ON THE MESSAGE CENTER, ACCOMPANIED BY A SUDDEN RPM LOSS/NO START WITH A DIAGNOSTIC TROUBLE CODE (DTC) P1A0C. *PE .
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Aug 01, 2012.FORD EXPEDITION 2005 had a failed ELECTRICAL SYSTEM:BATTERY . FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD.
Post Your Comment Go Top

FORD EXPEDITION 2005 technical service bulletin was issued Aug 01, 2012.FORD EXPEDITION 2005 had a failed (PWS) . FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD.
Post Your Comment Go Top