HARLEY DAVIDSON FLST 1990 |
Consumer Was Driving The Base gasket was leak oil. please describe . *ak
|
HARLEY DAVIDSON FXDG SERIES 1995 |
Consumer Was Driving And The oil filter nipple came off . tt
|
HARLEY DAVIDSON FXDWG 1999 |
Cam Bolt Breaking Which Resulted in sudden engine failure(abnormal wear)
|
HARLEY DAVIDSON 1200 2000 |
Leaking Oil Is Burning On exhaust. consumer took motorcycle to the dealer, and dealer noted that seals were broken off off
|
HARLEY DAVIDSON FLHT 2001 |
While Riding Motorcycle At 70 mph it started to blow out oil through carburetor onto consumer's legs. while oil was burning,
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Harley Davidson Model Fatboy Motorcycle; while driving 40 mph heard a loud noise. dealer replaced a broken rear cam bearing under warranty.
|
HARLEY DAVIDSON FXDX 1999 |
While Traveling Engine Was making a loud noise and running rough, and without any indicatiion vehicle would stall. dealer has replaced camshaft.
|
HARLEY DAVIDSON ULTRA CLASSIC 1999 |
Engine Would Make A Lot of noise while driving. had motorcycle checked at motorcycle shop. cam bearings was going out in engine,
|
HARLEY DAVIDSON SOFTAIL 1996 |
Was Driving Motorcycle When cam bearings blew out and scattered metal pieces throughout engine, causing it to stall out. *ak
|
HARLEY DAVIDSON ULTRA CLASSIC 1999 |
Engine Camshaft Had To be replaced on two occasions, once per year. dealer was notified ,and made repairs at no
|
HARLEY DAVIDSON ROAD KING 1997 |
Consumer's 2000 Motorcycle has a ticking noise, and won't start. on highway engine locked up.
|
HARLEY DAVIDSON FLHTCUI 1999 |
While Traveling At Approximately 65 mph in rush hour engine stalled. consumer had previously recall work done for 'bank angle sensor'
|
HARLEY DAVIDSON FLHTC 2001 |
Consumer Was Traveling About 40mph on highway and motorcycle shutdown without prior warning, and lost power.
|
HARLEY DAVIDSON FLHTCUI 2000 |
Camshaft Bearing Was Prematurely Failing, causing loss of power and disabling motorcycles. manufacturer was aware of defect, and redesigned part.
|
HARLEY DAVIDSON FLSTC 2000 |
Cam Bearings Are Defective. please provide further details. *ak
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Consumer Was Traveling About Sixty miles and when he came to a complete stop, noticed that the motor mounts were on the ground.
|
HARLEY DAVIDSON FLHT 1999 |
Consumer Contacted Dealer In Reference to recall0101/angle sensor. dealer contacted, problem was taken care of. *ak *ml
|
HARLEY DAVIDSON FLHTCUI 1999 |
Consumer Received A Recall notice 99v003000 concerning engine cam bolt failure. dealer did not have parts available. *ak
|
HARLEY DAVIDSON FLHT 1999 |
Motorcycle Will Sputter / Cut completely off. dealer says it is the crank case. *ak *yc
|
HARLEY DAVIDSON 1340 1995 |
When Driving At 35 Mph their was a loud noise within the engine due to the engine's four valve lifters being worn out. *ak
|
HARLEY DAVIDSON FLST 1988 |
Engine Lifter Failed, Causing engine valve not to work , resulting in motorcycle stalling unexpectedly, which may cause a crash.
|
HARLEY DAVIDSON FLHR 1999 |
While Driving About 20 Mph engine cam bolt sheared off, causing sudden engine siege. the bolt has been replaced by the dealership.
|
HARLEY DAVIDSON FXD 1999 |
Consumer Received Recall Letter Concerning engine cam bolts. contacted dealer, no parts available to correct recall problem. recall number 99v003000.
|
HARLEY DAVIDSON HARLEY DAVIDSON 1996 |
Motor Bike Has A Bad fuel valve. owner said that dealership has had part on back order for about a month. *ak
|
HARLEY DAVIDSON ROAD KING 2001 |
While Driving At Any Speed on flat surface and with no warning oil is leaking onto brakes, causing the brakes to slip,
|
HARLEY DAVIDSON FLHTCUI 2000 |
Engine Stopped Running After A camshaft bearing broke while motorcycle was being driven at 55 mph. owner had to coast to side on
|
HARLEY DAVIDSON SPORTSTER 2000 |
Engine Rocker Box Gasket Was leaking oil while driving, dealer notified. feel free to provide any further information.*ak
|
HARLEY DAVIDSON ULTRA CLASSIC 1999 |
Consumer States Heard A Strange noise coming from the engine. took vehicle to the dealership, they told her that there was a
|
HARLEY DAVIDSON FLSTF 2000 |
It Is My Understanding That the manufacturer knows that certain vehicles produced early in the model year possibly have a cam bearing in the engine
|
HARLEY DAVIDSON HARLEY DAVIDSON 1999 |
All 1999 Harlley Davidson "twin cam" engines were equipped with faulty cam bearings which were changed during the 2000 model year. based on
|
HARLEY DAVIDSON FLSTC 2000 |
This Engine Type (tc-88) In earlier models (produced before roughly end of 1999) has harley-davidson (h-d) acknowdged known poor cam bearing design which can result
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Twin Cam Bearing Has Not failed yet. if bearing does fail a serious potential for accident exists because failure could cause engine to lock
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
I Have Been Notified In writing by harley-davidson about possible failure of the rear cam bearing in my motorcyle. they say that
|
HARLEY DAVIDSON FLHPI 1999 |
This Cam Bearing Issue Is well-known among hd twin-cam owners. my bearing begin to cause the engine to vibrate excessively so that i
|
HARLEY DAVIDSON FXDX 1999 |
Harley Davidson Has Not Yet issued a recall for the impending failure of the cam bearing that is occuring in the 1999 twin cam engines.
|
HARLEY DAVIDSON FLHRCI 1999 |
Rear Camshaft Bearing Assembly Disintegrated, sending metal particles through the lubrication system into the oil pump, necessitating replacement of many engine componenents.
|
HARLEY DAVIDSON FXDWG 2000 |
On January 22,2001 Harley-davidson sent a letter to customers alerting them of a engine cam bearing failure problem. when this bearing goes bad
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Cam Bearing Failure. not at speed
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Harley Knows There Is A problem with the rear camshafts on the 2000 tc88.....why the hell don't they fix the
|
HARLEY DAVIDSON FLHR 1999 |
1999 Harley Davidson 88 Cubic inch twin cam engines have a known problem with cam bearings. many of the bearings are failing causing
|
HARLEY DAVIDSON FLHR 1999 |
Original Equipment Ie. (factory cams and cam bearings) replaced with stage 1 performance cams and new bearing sets at approx. 10,000
|
HARLEY DAVIDSON SOFTAIL 2000 |
The Cam Bearing Problem Was known at the time i purchased my motorcycle for close to $20,000, but i was not notified this
|
HARLEY DAVIDSON HARLEY DAVIDSON 1999 |
Camshaft Failure Also Damaged Flywheels which will require bottom end rebuild
|
HARLEY DAVIDSON FXDX 2000 |
I Am Concerned About Reports of cam and cam bearing failures. the manufacturer claims incidents of less than 1%. however the
|
HARLEY DAVIDSON FLSTS 2000 |
Due To The Reported Failures in the twin cam 88 engine i am concerned the rear cam bearing might fail when i am at highway
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
The Cam Bearing Has Not yet failed. there is a high number of failures in this bearing, on new engine design mamnufactured
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
There Have Been An Alarming number of cam bearing failures on hd's tc88 engines. the factory has not issued a recall. if the
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Cam Bearings Are Failing On 1999 and 2000 harley-davidson tc-88 engines. there is potential for serious safety consquences due to this failure should
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
This Is The Second Motorcycle mentioned in the earlier report on cam bearing failure in our 2000 road king. again, failure resulted in
|
HARLEY DAVIDSON HARLEY DAVIDSON 2000 |
Bearing Failure Results In Total and immediate engine failure at the point of failure. happened on this motorcycle and on my wife's (2000
|
HARLEY DAVIDSON FLHRCI 1999 |
Cams Always Is Very Noisy and believe they will go completely out any day now possibly in a curve, causing severe injury or death.
|
HARLEY DAVIDSON HERITAGE 1996 |
Hd Put In Inferior Cam bearings to save .72 cents per unit and they are failing in big numbers but hd is trying to
|
HARLEY DAVIDSON FLHT 1999 |
I Have Heard The Rear camshaft on the twin cam engine is weak. and that too much power will cause it to break,
|
HARLEY DAVIDSON HARLEY DAVIDSON 1993 |
I Lost The Rear Cylinder lifter at very low speed in deadwood ,sd during sturgis bike week. the loss of the lifter caused
|
HARLEY DAVIDSON FLHTC 1999 |
Recall Notice Was Sent On january 25,1999. as of feb 08,1999, regarding engine cam bolt failure. no parts have
|
HARLEY DAVIDSON FLHT 1996 |
H-d Redesigned The Tappets In the evo big twin motor. my motor had 3 of the new style tappets and one of the old
|
HARLEY DAVIDSON FXSTS 1998 |
Cylinder Piston Head Failed. yh
|
HARLEY DAVIDSON SPORTSTER 1998 |
Front / Rear Head Gasket failed. *yc
|
HARLEY DAVIDSON SPORTSTER 1996 |
Engine Timing Plug Milling failed.
|
HARLEY DAVIDSON HARLEY DAVIDSON 1996 |
Lower Rocker Cover Gasket Failed.
|
HARLEY DAVIDSON ROAD KING 2001 |
The Top Bolt From The primary chain tension adjuster fell out, lodging between the double sprocket of the clutch assembly, the lower bolt
|
HARLEY DAVIDSON HARLEY DAVIDSON 9999 |
The Consumer States That The cam bearing could fail and cause crash and serious injury because it is defective. *yh
|
HARLEY DAVIDSON FLSTC 2000 |
The Rear Cam Bearings, cam support plates, and oil pump failed causing engine failure, the manufacturer knows of the malfunction but feels
|
HARLEY DAVIDSON XLH SERIES 1999 |
The #3 Camshaft And Camshaft bushing failed causing the motor to lock up and the rear wheel to slide out of control. nlm
|
HARLEY DAVIDSON FXDL 2000 |
Consumer Received A Letter From manufacturer stating the possibility of a rear cam bearing failure, the failure could cause engine to glide to a
|
HARLEY DAVIDSON FXRT 1992 |
Main Drive Gear Sprocket Failed (4 times). front engine mount and stabilizer replaced.
|
HARLEY DAVIDSON FLHTC 1989 |
Left Motor Mount Bracket Rusted.
|
HARLEY DAVIDSON FLHTC 1989 |
Engine Motor Mount Failure. *ak
|
HARLEY DAVIDSON FLSTC 1990 |
Crankshaft Failed.
|
HARLEY DAVIDSON FXRT 1991 |
Faulty Original Retaining Clip, causing massive/abrupt engine failure. *ak
|
HARLEY DAVIDSON FL SERIES 1990 |
Gaskets Replaced Twice Due To leaks. *skd
|
HARLEY DAVIDSON FXDL 2003 |
Tl*the Contact Owns 2003 Harley davidson dyna glide fxdl. the contact stated that the motorcycle had an unusual noise coming from the engine.
|
HARLEY DAVIDSON FLHTCU 2008 |
2008 Harley Davidson. Consumer states design flaw and serious safety issue with motorcycle *tgw the consumer stated the motorcycle had been at the
|
HARLEY DAVIDSON FLHRC 2008 |
2008 Harley-davidson Roadking Taken To the shop for excessive vibration. at 10,000 miles, the compensator sprocket on this motorcycle disintegrated and replaced
|
HARLEY DAVIDSON FL 9999 |
Tl* The Contact Owns A 2009 harley davidson street glide fl series(na). the contact stated that the vehicle would exhibit an unusual increase in
|
HARLEY DAVIDSON VRSCR 2006 |
After Work I Started The engine and allowed it to warm up while i put on my protective riding gear (jacket, helmet, and
|
HARLEY DAVIDSON FXDC 2009 |
Tl* The Contact Owns A 2010 harley davidson ultra screaming eagle fl ht cuse5 motorcycle. the contact stated that when driving at various speeds,
|
HARLEY DAVIDSON FLSTF 2001 |
Harley Davidson Twin Cam Crankshaft defect. i own a 2001 harley davidson and the crankshaft has shifted, the flywheels have slipped on the
|
HARLEY DAVIDSON FLHT 2002 |
I Own A 2002 Harley davidson flht. last year (2009) i noticed that my fairing started to vibrate excessively when the engine was at
|
HARLEY DAVIDSON FLHX 2007 |
Tl*the Contact Owns A 2007 harley davidson flhx motorcycle. since november of 2007, the vehicle shuts off when the contact pulls in
|
HARLEY DAVIDSON FLHTCU 2007 |
As I Was Riding Down the road at approx. 50 mph in 5th gear i noticed a drop in oil pressure and a noise
|
HARLEY DAVIDSON FLHT 2000 |
Tl*the Contact Owns A 2000 harley davidson flht. while riding the vehicle at an unknown speed, the contact heard a noise coming
|
HARLEY DAVIDSON FXDWG 1999 |
Total Engine Failure. terrible grinding noise inside the engine. *tr
|
HARLEY DAVIDSON FLSTC 2007 |
I Have A Harley Davidson 2007 heritage softtail classic. it has a dangerous heat problem. harley davidson designed the bike with the
|
HARLEY DAVIDSON FXDWG 2008 |
I Received First Degree Burns to my thighs. this engine is known to be a problem with being hot as i found out after
|
HARLEY DAVIDSON FLHTCUSE2 2007 |
Problems With 110 Ci Cvo engine map. engine sometimes dies when shifting, pops back through intake. had this happen on
|
HARLEY DAVIDSON FLHTCUSE2 2007 |
I Purchased A 2007 Harley davidson ultra classic screaming eagle and after 10k miles it stared leaking oil due to a manufacturers defect. there
|
HARLEY DAVIDSON FLHTCUSE2 2007 |
Noticed Vibration @ 75 Mph and use of oil. used 1.75 qts of oil in 1,700 miles. dealer said
|
HARLEY DAVIDSON FLSTC 2007 |
'07 Harley Davidson Heritage Softail -i was riding with a group and we accidentally ran into a parade during the 4th of july. we
|
HARLEY DAVIDSON FLSTN 2007 |
Hot Running Engine Under Normal operating conditions. hard, metal to metal hit on engagement of starter and transmission on start-ups.
|
HARLEY DAVIDSON ULTRA CLASSIC 1999 |
Tl*the Contact Owns A 1999 harley davidson ultra classic. the contact stated that his vehicle began to make an unfamiliar noise.
|
HARLEY DAVIDSON FLHTCU 2007 |
The Heat Generating From The engine and exhaust on to the rider's legs and seat and also to the passenger's legs is extremely high.
|
HARLEY DAVIDSON FLHTCUI 2000 |
2000 Harley-davidson Flhtcui (electra Glide ultra classic) cam chain tensioner failed at 37,400 miles. large chunk of material blocked oil flow.
|
HARLEY DAVIDSON XL883R 2006 |
Tl*the Contact Owns A 2006 harley davidson xl883r. while driving 70 mph, the contact noticed smoke coming from the engine.
|
HARLEY DAVIDSON FXST SERIES 2003 |
Vibration Over Time Can Cause compensatory or nut to back off, allowing metal particles to move freely around internal moving parts. concern
|
HARLEY DAVIDSON FXDS CONV 1999 |
Tl*the Contact Owns A 1999 harley davidson fxds conv. the contact received a recall notice a while back regarding the rear cam bearing
|
HARLEY DAVIDSON ELECTRA GLIDE 2003 |
Tl*the Contact Owns A 2003 harley davidson electra glide. while driving 70 mph, the engine shut off and all electrical power was
|
HARLEY DAVIDSON XL1200C 2006 |
2006 Harley Davidson 1200 Custom 1300 mi, constant engine cough and occasional stalling. the coughing and hesitation are quite often making this motorcycle
|
HARLEY DAVIDSON FXDWGI 2006 |
Tl*- The Contact Stated That the 2006 harley davidson wide glide with 4 failure mileage had a bad vibration in the engine,
|
HARLEY DAVIDSON FLHT 2002 |
Tl* - The Contact Called regarding the 2002 flht electric glide standard harley davidson motorcycle. the contact stated that while the
|
HARLEY DAVIDSON FXDCI 2006 |
Dt*: The Contact Stated That the engine made a noise after driving 30 minutes. the vehicle was taken to the service dealer,
|
HARLEY DAVIDSON FLHTC 2007 |
Engine Creates Excessive Heat Making the motorcycle almost unbearable to ride. if sitting in traffic long the heat almost burns the undersides of
|
HARLEY DAVIDSON ROAD KING 1999 |
Cam Bearings Failed In A 1999 roadking. the dealer stated that there was an extended warranty of 5yr/50,000miles but only if the engine
|
HARLEY DAVIDSON FLSTF 2006 |
1.engine Missing Failure Was on delivery of new motorcycle. 2. motorcycle would backfire and stall at almost every start & stop
|
HARLEY DAVIDSON FLSTC 2001 |
Internal Engine Noise Indicating Potential failure at 10,500 miles, requiring total engine remanufacturing. potential for injury, and or death.
|
HARLEY DAVIDSON FLHTCUI 2006 |
2006 Ultra Classic Has Smoked since day i bought it! had only 2 miles on it when i was given the pdi by salesman.
|
HARLEY DAVIDSON SPORTSTER 2002 |
Dt: The Contact Stated the rear upper valve cover leaked. the dealership replaced the front and rear upper valve covers.
|
HARLEY DAVIDSON FXDWG 1999 |
Harley-davidson Cam Bearing Failure On 1999 twin-cam88 & twin-cam88b engines. this was identified by harley-davidson and a design change was made to the
|
HARLEY DAVIDSON SOFTAIL 2005 |
From What I'm Learning The hard way, some 2005 harley davidson motorcycles burn oil at a rate of 1 quart per thousand miles -
|
HARLEY DAVIDSON FXDX 1999 |
99 Harley Davidson- Cam Bearing failure- the company extended the warrenty to 5yrs or 50,000 mi. the failure occured after 7 yrs.
|
HARLEY DAVIDSON ULTRA CLASSIC 1999 |
Dt: The Consumer Stated About a week ago, last saturday 7/16/05. the consumer was driving down the interstate when he noticed that there
|
HARLEY DAVIDSON TOURING 2005 |
Bought Vehicle Brand New On 04/08/05. vehicle engine pings at normal operating rpm, took vehicle to dealer, dealer was able to hear
|
HARLEY DAVIDSON ULTRA CLASSIC 2000 |
While Driving Alternator/enerator Burned up in the motor, causing the engine to malfunction at 30,000 miles. *ak
|
HARLEY DAVIDSON FLHRCI 2000 |
This Is A Complaint About the service life of the new twin cam engine's bottom end. there seems to be a large number of
|
HARLEY DAVIDSON FLHRCI 2003 |
Catastrophic Engine Failure Occurred Twice in a new 2003 harley-davidson motorcycle at 3284 miles and again at 7420 miles. the first was due to
|
HARLEY DAVIDSON HARLEY DAVIDSON 1997 |
Motorcycle Stalled And Leaked Oil due to a defective part. because of this, harley davidson promised to cover the cost of repairs then
|
HARLEY DAVIDSON HARLEY DAVIDSON 1997 |
Fax Fwd Ltr Fm Morgan b. lacey (fl) re defective engine (the pinion shaft inner race) for a 1997 harley-davidson motorcycle, reply attn.
|
HARLEY DAVIDSON FLSTF 2000 |
Vehicle Stalled While Driving At any speed without warning. dealership serviced the vehicle 4 times, but was unable to locate the cause
|
HARLEY DAVIDSON HARLEY DAVIDSON 2002 |
Motorcycle Stalls Intermittently While Driving. motorcycle will be taken to the dealer for determination of the problem. harley davidson v-rod 2002.
|
HARLEY DAVIDSON FLHTCI 2000 |
Consumer Stated He Is Not able to control the speed of the bike. the bike had to be shut off and restarted to
|
HARLEY DAVIDSON FXDL 2003 |
Problems With Dyna Low Rider. *mr while driving bike at 55 to 60 mph, the motorcycle vibrated so bad it put the consumer hands
|
HARLEY DAVIDSON FXR 1990 |
Harley Davidson Fxr Motorcycle. engine component. crankcase cracked ,causing oil leak.*ak
|
HARLEY DAVIDSON 1200 2000 |
Consumer States That While Driving and with no warning vehicle will stall, and it will be hard for the consumer to control the vehicle.
|
HARLEY DAVIDSON FXDWG 2000 |
The Cam Bearings Of My 2000 fxdwg [dyna wide glide] destroyed themselves in kansas city and the bike was repaired at harley davidsons expense
|
HARLEY DAVIDSON FXDX 1999 |
This Was One Of Eleven cam bearings elyria h-d has done, they only sell 300 bikes total a year. approx. 1/3
|
HARLEY DAVIDSON FLTRI 1999 |
There Have Been Numerous Failures of the engine cam bearings in 1999 twin cam motors which is a new design from harley davidson. harley
|
HARLEY DAVIDSON SOFTAIL 2002 |
The Motorcycle Overheated Excessively, which was caused by the oil tank being located directly under seat.ts also the clutch
|