FORD L SERIES 1997 Technical Service Bulletins

FORD L SERIES 1997 technical service bulletin was issued Oct 11, 1996.FORD L SERIES 1997 had a failed VEHICLE SPEED CONTROL. THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 15, 1996.FORD L SERIES 1997 had a failed SEATS. DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 13, 1996.FORD L SERIES 1997 had a failed SUSPENSION REAR SPRINGS AIR SUSPENSION SYSTEM SPRINGS/BAGS. REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 01, 1996.FORD L SERIES 1997 had a failed POWER TRAIN MANUAL TRANSMISSION. MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 01, 1996.FORD L SERIES 1997 had a failed FUEL SYSTEM, GASOLINE FUEL INJECTION SYSTEM FUEL RAIL. NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 01, 1996.FORD L SERIES 1997 had a failed SEATS. ON L SERIES EQUIPPED WITH CUSH-N-AIR SEATS, THE DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT DUE TO INADEQUATE WELDS. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 18, 1996.FORD L SERIES 1997 had a failed ELECTRICAL SYSTEM WIRING. WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Oct 21, 1996.FORD L SERIES 1997 had a failed VEHICLE SPEED CONTROL. ENGINE - WILL NOT ACCELERATE ABOVE IDLE SPEED - VEHICLES EQUIPPED WITH CUMMINS M11, N14 OR DETROIT DIESEL SERIES 60 ENGINE. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Oct 21, 1996.FORD L SERIES 1997 had a failed ELECTRICAL SYSTEM STARTER ASSEMBLY. STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 02, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE DIESEL. REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 02, 1997.FORD L SERIES 1997 had a failed UNKNOWN OR OTHER. SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 02, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM RADIATOR ASSEMBLY. HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 02, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 23, 1997.FORD L SERIES 1997 had a failed FUEL SYSTEM, GASOLINE DELIVERY FUEL PUMP. THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Jan 23, 1997.FORD L SERIES 1997 had a failed FUEL SYSTEM, GASOLINE DELIVERY FUEL PUMP. DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 03, 1997.FORD L SERIES 1997 had a failed ELECTRICAL SYSTEM STARTER ASSEMBLY. NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 17, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE BELTS AND ASSOCIATED PULLEYS. FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 17, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM FAN. COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 14, 1997.FORD L SERIES 1997 had a failed SUSPENSION FRONT SPRINGS AIR SUSPENSION SYSTEM. HENDRICKSON AIR RIDE SUSPENSION WITH TRANSVERSE MOUNTED TORQUE RODS- THE FLAT WASHERS USED ON THE ROD TO AXLE ATTATCHING BOLT MAY DEFORM. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 11, 1997.FORD L SERIES 1997 had a failed ELECTRICAL SYSTEM STARTER ASSEMBLY. FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Mar 31, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE DIESEL. FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Mar 03, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE DIESEL. ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Mar 17, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM EMISSION CONTROL CATALYTIC CONVERTOR. HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued May 01, 1997.FORD L SERIES 1997 had a failed VEHICLE SPEED CONTROL. NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Sept 02, 1997.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Feb 16, 1998.FORD L SERIES 1997 had a failed STRUCTURE BODY. SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Apr 13, 1998.FORD L SERIES 1997 had a failed TIRES. INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 01, 1998.FORD L SERIES 1997 had a failed STRUCTURE BODY HOOD. CONCERNS OF AIR CLEANER COVER MAY RUB A HOLE IN THE HOOD AT THE FRONT EDGE OF THE AIR CLEANER INLET " WAGON WHEEL " ON SOME VEHICLES. *YC .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued July 12, 1999.FORD L SERIES 1997 had a failed VEHICLE SPEED CONTROL ACCELERATOR PEDAL. VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Nov 01, 1998.FORD L SERIES 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION ON SERVICING THE AIR CLEANER ELEMENT ON ALL 1995- 1996-1997 L-SERIES EQUIPPED WITH CAT 3306 ENGINES. *MJS .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Aug 19, 2002.FORD L SERIES 1997 had a failed SUSPENSION. SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Oct 04, 1999.FORD L SERIES 1997 had a failed SUSPENSION. SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT .
Post Your Comment Go Top

FORD L SERIES 1997 technical service bulletin was issued Sept 20, 1999.FORD L SERIES 1997 had a failed EQUIPMENT AIR CONDITIONER. INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT .
Post Your Comment Go Top