Jeep Engine And Engine Cooling Exhaust System
Car-and-Safety.com | JEEP>JEEP Engine And Engine Cooling Exhaust System
Jeep Engine And Engine Cooling Exhaust System Reports
16 Mar
| JEEP CHEROKEE 1995 | While Driving The Vehicle Owner gets a headache because of exhaust fumes coming into vehicle. tt |
| JEEP CHEROKEE 1993 | Odor Inside Of Vehicle Causing ill effects. wife and daughter both sick , both has asthma. tt |
| JEEP CHEROKEE 1989 | Noisy Exhaust System. *ak |
| JEEP CHEROKEE 1990 | Cracked Exhaust. Tt |
| JEEP WRANGLER 1997 | Had Heard A Noise When vehicle was started, sounded like a hole in muffler. exhaust was coming off engine. problem got worse. |
| JEEP WRANGLER 1998 | Exhaust System Broke twice. this could allow exhaust fumes to enter passenger's compartment. please provide any additional |
| JEEP CHEROKEE 2001 | Structure Underneath Is Rusting Out. also, brake line is corroded/ exhaust is pitted, and steering spindle rusted and corroded. |
| JEEP WRANGLER 1989 | Carburator Was Running Too Much fuel to exhaust system which caused exhaust system to become cherry red & catch on fire in |
| JEEP WAGONEER 1998 | While Traveling Engine Became Loud. technician stated exhaust header had a crack. please provide further information. *ak |
| JEEP WRANGLER 1997 | Cracks Developed In The Exhaust system. patched/welded by an independent repairs shop. less then 20,000 miles, other cracks appeared in |
| JEEP CHEROKEE 1994 | The Exhaust System Runs Underneath floorboard on passenger's side. when vehicle was in motion, the floorboard overheated & rusted. was informed by |
| JEEP GRAND CHEROKEE 1991 | After Replacement Of Catalytic Converter ( new item 3omph) and exhaust system turned a bright orange suddenly fire seeped from the undercarriage: flames 3--4 |
| JEEP GRAND CHEROKEE 1994 | While Driving, Exhaust Fumes are "leaking" into the vehicle's interior compartment. consumer stated that fumes are very strong and difficult to withstand. |
| JEEP GRAND CHEROKEE 1998 | Intermittently The Vehicle Would Vibrate while applying the brakes. the brake pedal would go to the floor and cause an extended stopping distance. |
| JEEP GRAND CHEROKEE 1994 | Consumer States That While Driving and no warning the exhaust manifold had crack causing a fire under the hood and the consumer was force to |
| JEEP WRANGLER 1997 | Vehicle Was Making Noise From muffler. took vehicle to dealership, and mechanic stated that exhaust manifold was cracked, causing exhaust leakage and |
| JEEP GRAND CHEROKEE 1998 | While Driving, Heard Constant noise. took vehicle to dealer for service who stated that exhaust manifold needed to be replaced.*ak the |
| JEEP GRAND CHEROKEE 1999 | While Driving At 40 Mph, and upon pressing down on brake, vehicle shaks very hard, rotors appear to be very |
| JEEP CHEROKEE 1994 | Exhaust Manifold Failure. |
| JEEP WRANGLER 1997 | Daimler Chrysler Has Been Unresponsive to my requests for replacement of this part under "implied warranty" or anything else, even though the car problem |
| JEEP WRANGLER 1999 | I Would Like To Know if their is a secret warrenty on the exhaust manifolds cracking on the seams of the joint, for the |
| JEEP WRANGLER 1997 | Exhaust Header Cracked At 4 locations and had to be replaced. jeep dealer said that this is a known defect and still would |
| JEEP WRANGLER 1998 | Cracked Exhaust Manifold. the crack could have resulted in carbon monoxide entering the passenger compartment. repair facility reported that this is |
| JEEP WRANGLER 1994 | Catalytic Converter Rattles Loudly. noise is intermittent, independent of speed, engine temp or if transmission engaged. dt |
| JEEP GRAND CHEROKEE 1996 | Manifold Crack Over $400.00 to repair also ball jionts over $500.00 to repair. auto used only on road and highway speed. |
| JEEP WRANGLER 1995 | This Is The Third Cat i have had to place on this automobile. the dealership replaced the first two, all failing at |
| JEEP GRAND CHEROKEE 1995 | Exhaust Manifold Developed 1-inch Crack at main stem. very loud noise when engine was running. i was told by dealer that |
| JEEP WRANGLER 1998 | The Mannifold Has Cracked Twice. the first time, jeep fixed it, stating there was a "design flaw". now, |
| JEEP WRANGLER 1998 | A Known Problem With Exhaust leaks on wranglers. nlm |
| JEEP WRANGLER 1998 | Exhaust Header Split Open at heat effected zone of weld.*ak |
| JEEP CHEROKEE 1999 | I Have Talked To Various jeep cherokee owners and researched on the internet. this seems to be a very common problem with the |
| JEEP GRAND CHEROKEE 1996 | Exhaust Manifold Is Cracked On my 1996 jeep grand cherokee. the problem seems to be common among grand cherokee owners. this |
| JEEP WRANGLER 1999 | Exhaust Manifold Cracked In Several places with only 56k on jeep. dealer says there was no special warranty for this part, but was |
| JEEP GRAND CHEROKEE 1995 | I Understand This Problem Has been going on for years..please see what you can do..this is a safety concern... |
| JEEP WRANGLER 1998 | I Took The Jeep Last year to get the rattle fixed. they fixed it, but on the 1/12/02 i took it back for |
| JEEP WRANGLER 1997 | Noticed What Sounded Like An exhaust leak coming from the engine compartment. i brought it to the dealer with 27k miles on it. |
| JEEP WRANGLER 1998 | As I Have Read Mentioned by others at this website, about a year after i bought the jeep, my dash gauges would go |
| JEEP WRANGLER 1997 | Exhaust Manifold Cracked/studs Failed/parts,labor not covered/3rd party repaired. *ak |
| JEEP WRANGLER 1997 | There Seems To Be A lot of complaints about this same problem. hopw many does it take to get some action. no safety |
| JEEP WRANGLER 1997 | About A Week Ago I called the dealership to report a cracked exhaust manifold.i asked if there has been any recalls of this and |
| JEEP GRAND CHEROKEE 1995 | This Crack Is Pervasive With 91-97 jeeps. all dealership and private-label mechanics are aware of the issue. jeep is aware of it because |
| JEEP GRAND CHEROKEE 1998 | All Of The Problems Identified in my complaints are covered by chrysler extended warranty. but i strongly feel jeep is building an inferior |
| JEEP WRANGLER 1997 | Exhaust Manifold Cracked 1/8" Horizontally, vehicle not showing signs of overheating, dealership and two muffler shops contacted--all indicated this is a common problem |
| JEEP WRANGLER 1997 | Exhaust Manifold Is Cracked In 4 places. dealership indicated it is a common problem. contacted chrysler corp, but did not seem concerned. |
| JEEP CHEROKEE 1995 | I Believe Exhaust Manifold Is of substandard design/materials. this part should last longer than 5 years. it seems that this is a common |
| JEEP GRAND CHEROKEE 1995 | Dating Back To 2 Years ago, i had a jeep dealer check the exhaust system for a "fluttery" noise, which i thought sounded |
| JEEP GRAND CHEROKEE 1995 | No Summary Listed For Above vehicle. *ak |
| JEEP GRAND CHEROKEE 1995 | Case And All Internal Parts; seals and gaskets are covered have a added care service contract 7/100 . under transmission it is |
| JEEP CHEROKEE 1994 | No Summary( Dot Number: tire size: p235/75r15 ) |
| JEEP WRANGLER 1997 | Rough Idle; Engine check light on; stalling, bucking at speed; noisey/cracked exhaust |
| JEEP WRANGLER 1997 | Exhaust Manifold Had To Be replaced. there were several large cracks, luckily the problem was caught before it broke off. |
| JEEP GRAND CHEROKEE 1994 | No Summary Listed For Above vehicle. *ak |
| JEEP GRAND WAGONEER 1986 | The Whole Crankcase Emission Control device failed, causing a complete meltdown of all engine parts. at the time the vehicle was being |
| JEEP WRANGLER 1998 | The Exhaust Manifold/header Cracks At the bottom on the inside pipe i have talked to a few other people and it is apperantly a very |
| JEEP WRANGLER 1997 | Dealer Said No Warrenty Coverage for manifold due to mileage and age. called chrysler help line and told maybe cold water or rain |
| JEEP WRANGLER 1997 | The Rear Differential Was Cracked, as was the exhaust manifold. also the crank sensor harness and the tps were melted against the manifold. |
| JEEP WRANGLER 1997 | The Exhaust Manifolds Bolds Are made out of alluminum, which at high temp. will break. that is what has happened in |
| JEEP GRAND CHEROKEE 1995 | My Exhaust Manifold Has Defective welds causing a very noticeable exhaust leak in engine compartment. took to independent muffler shop they inforrmed me tthis |
| JEEP GRAND CHEROKEE 1999 | Gas Tank Was Replaced Mid july of 1999. after that date, the "check engine" light appeared. service department claimed that |
| JEEP WRANGLER 1995 | No Summary |
| JEEP CHEROKEE 1991 | No Summary Listed For This vehicle. *ak |
| JEEP WRANGLER 1997 | The Problem With The Exhaust is that it is making a clicking sound at startup everytime until the engine is good and warm. |
| JEEP WRANGLER 1997 | Engine Manifold Cracked During Start up on a cold morning. *ak |
| JEEP CHEROKEE 1997 | No Summary Listed For This vehicle. *k |
| JEEP CHEROKEE 1998 | At 11,029 Front Pads and rotors were replaced, sway-bar bushings were replaced, exhaust hanger was replaced, drivers seat squeeked (fixed under |
| JEEP WRANGLER 1994 | No Summary Listed For This vehicle. *ak |
| JEEP WRANGLER 1995 | No Summary Listed For This vehicle. *ak |
| JEEP CHEROKEE 1999 | No Summary |
| JEEP WRANGLER 1994 | Exhaust Manifold Leaks After Bolts break off, cat. converter failure seems to occur at start up of vehicle |
| JEEP WRANGLER 1997 | Took Jeep To Dealer Several times had headers replaced soon after maifold exhaust faolure. radio replaced once, still doesn't stay on. |
| JEEP WRANGLER 1994 | No Summary From Consumer. |
| JEEP CHEROKEE 1990 | The Exhaust Has A Continual rattle at idle and i don't know if this is a safety concern ,it just started one day and |
| JEEP CHEROKEE 1998 | Exhaust System Failed. |
| JEEP CHEROKEE 1998 | Exhaust System Problem Due To bad mufler seal. yh |
| JEEP WRANGLER 1995 | Consumer Stated The Exhaust Manifold studs are fatiguing and breaking.*scc |
| JEEP GRAND CHEROKEE 1995 | Exhaust System Leaking, Dealer replaced muffler and exhaust manifold. nlm |
| JEEP CHEROKEE 1989 | The Tp Sensor And Ecm failed causing the vehicle the experience high idle whenever the jeep was started. nlm |
| JEEP GRAND CHEROKEE 1998 | Exhaust System Problems, Causing fumes to enter into vehicle, dealership has inspected vehicle on four occasions and can not determine failure. |
| JEEP WRANGLER 1995 | Exhaust Manifold Studs Broke Causing engine noise and loss of power. yh |
| JEEP WRANGLER 1997 | Exhaust System Had To Be replaced because there was a hole in it. |
| JEEP GRAND CHEROKEE 1997 | Exhaust System Failed, Emitting smoke. |
| JEEP CHEROKEE 1991 | Exhaust System Failed. |
| JEEP CHEROKEE 1998 | Exhaust Gas Leakage From Weep holes. |
| JEEP WRANGLER YJ 1997 | Exhaust System Was Making Rattling noise. |
| JEEP WAGONEER 1988 | Vehicle Stalled Due To Exhaust system leaks. *ak |
| JEEP CHEROKEE 1994 | Exhaust System Leaking. *sd |
| JEEP WRANGLER 1987 | Exhaust Replaced. |
| JEEP WRANGLER 1998 | Tl* The Contact Owns A 1998 jeep wrangler. while driving approximately 15 mph, the contact heard a loud rattling noise underneath the vehicle. |
| JEEP LIBERTY 2002 | I Have A 2002 Jeep liberty. i had a new transmission put in january 2011. the jeep has about 202000 miles. now |
| JEEP GRAND CHEROKEE 2007 | Tl*the Contact Owns A 2007 jeep grand cherokee. the contact stated that while driving 50 mph the vehicle stalled. the contact was able |
| JEEP WRANGLER 2005 | Rapid And Significant Loss Of power in jeep wranglers caused by rapid failure (clogging) of catalytic converter. jeep unable to replace catalytic due |
| JEEP LIBERTY 2002 | I Am Experiencing A Rattling sound when driving uphill or downhill through driveway, traveling 5-20 miles an hour. i took my jeep |
| JEEP COMMANDER 2006 | I Own A 2006 Jeep commander and i have had to take it in to have the bolts in the manifold replaced three times now. |
| JEEP WRANGLER 2 DR 4X4 2007 | The Chrysler Group Llc And midway jeep chrysler located at 777 camino del rio south in san diego, ca are colluding the deny consumer |
| JEEP LIBERTY 2010 | 2010 Jeep Liberty With Less than 9000 miles started leaking oil from some where under engine when running, hot oil leaks into the |
| JEEP WRANGLER 2 DR 4X4 2007 | In The November 2010 Issue of consumer reports, page 15, they is an article about a recall on '07-'08 jeep wranglers " - |
| JEEP GRAND CHEROKEE 2000 | I Own A 2000 Jeep grand cherokee. my wife was picking up my kids, when the car began to shake and then overheated. |
| JEEP WRANGLER 2005 | I Purchased My Jeep In may of 2005. since that time the engine light has come on and the o2 sensor replaced three times. |
| JEEP WRANGLER 2003 | Traveling At 60-65mph Vehicle Cut off without warning. no lights on dash came on. pulled out of way of other traffic and came |
| JEEP LIBERTY 2002 | We Own A 2002 Jeep liberty. a coup[le of weeks ago while traveling the little piece of tail pipe fell of the end |
| JEEP WRANGLER 2 DR 4X4 2009 | Tl*the Contact Owns A 2009 jeep wrangler 4x4. the contact stated that there was no heat shield underneath the exhaust system. |
| JEEP GRAND CHEROKEE 4X4 2007 | I Have A 2007 Jeep grand cherokee diesel. bought new, nov. 07. at about 28k miles, on may 24, |
| JEEP CHEROKEE 2001 | My Engine Light On My dash board is on all the time the mechanic stated it is cylinder 3 misfiring & need to go to |
| JEEP GRAND CHEROKEE 2001 | Over The Past Three Years my power windows slid down. one left rear a few years ago slid down as we were going |
| JEEP GRAND CHEROKEE 2004 | My Jeep Runs Hot Even if i drive it two blocks. i have call chrysler several time a day and no one is helping |
| JEEP GRAND CHEROKEE 1997 | 1. Came Out Of gear when in park and crashed sustaining 5000.00 dollars in damage. had received a letter from daimler-chrysler in |
| JEEP GRAND CHEROKEE 2000 | Very Little Heat Is Coming out the driver side and cold air is coming out the passenger vents. *tr |
| JEEP WRANGLER 1999 | Exhaust Manifold Failure. *tr |
| JEEP CHEROKEE 1996 | 1996 Cherokee 4.0 Ho 6 cylinder exhaust header cracked at coupler joint. *tr |
| JEEP WRANGLER 2000 | 1) Coolant Leak - Cracked head (4.0 l v6 - this is a common costly problem according to a tech friend at chrysler |
| JEEP CHEROKEE 1996 | 1996 Cherokee 4.0 Ho 6 cylinder exhaust header cracked at coupler joint. *tr |
| JEEP LIBERTY 4X4 2006 | I Have A 2006 Jeep liberty crd. the egr failed at 17k miles. it was replaced under warranty. it failed again at |
| JEEP WRANGLER 1997 | 1997 Jeep Wrangler Exhaust Manifold. consistent decrease in power, stumbling, and poor gas mileage. after a wreck i noticed |
| JEEP GRAND CHEROKEE 2003 | My 2003 Jeep Grand Cherokee ltd is having problems with the defroster, the heater, and air conditioner. it has driver and |
| JEEP LIBERTY 2006 | Tl*the Contact Owns A 2006 jeep liberty. the contact stated that the "epm" warning indicator light illuminated. the vehicle has not |
| JEEP WRANGLER 1999 | I Have Had The Exhaust manifold fail in my 99 tj twice now. the factory original cracked at about 39,000 miles and |
| JEEP WRANGLER 2006 | Dt: The Contact Stated While driving in tall grass the vehicle caught on fire. upon inspection the exhaust headers were observed hanging down too |
| JEEP WRANGLER 2005 | Odi 10137688 Follow Up kudos to jeep for standing by their product, they are currently replacing the entire exhaust system and |
| JEEP WRANGLER 2005 | Bought New 2005 Jeep Wrangler x 8/3/05 took on trip and soon was overwhelmed with butane/exhaust smell if windows or vent was open; eventually |
| JEEP CHEROKEE 2003 | My 2003 Jeep Grand Cherokee, with less than 33,000 miles, was repaired for the same problem twice this year, on 9 |
| JEEP LIBERTY 2003 | I Have Had Numerous Problems with this jeep. always detected a rotten egg smell dealer claimed it was the gas. after |
| JEEP LIBERTY 2003 | While Driving On Two Different occasions, i experienced and burning smell from the drivers side rear wheel well and whitish smoke. on |
| JEEP GRAND CHEROKEE 1994 | Jeep Grand Cherokee, Early years 1992 - 2001 exhaust manifold cracks with regular occurance and allows carbon monoxide into passenger compartment. |
| JEEP LIBERTY 2005 | Consumor States: Check Engine light came on day after he bought it, and there is know reverse can push on gas pedal and |
| JEEP GRAND CHEROKEE 1994 | The Engine's Exhaust Manifold Had about 2-3 cracks on top. as a result the exhaust fumes seeps into the passenger compartment. consumer |
| JEEP CHEROKEE 1994 | Working 450 Miles From My home i was going through an intersection i heard an awful sound of metal clunking around in engine (loud). |
| JEEP WRANGLER 1997 | I Bought This 1997 Jeep wrangler from a used car dealer in june 2002 with a limited warranty and was told the vehicle pased inspection |
| JEEP WRANGLER 1998 | Exhaust Manifold Bolts Are Snapping off in the block of jeep 2.5 4 cyl engine. this problem is documented by chrysler as a |
| JEEP WRANGLER 1999 | On February 4, 2004 i took my 1999 jeep wrangler to bob mayberry chrysler dodge, jeep, inc. it was very noisy |
| JEEP CHEROKEE 1994 | Vehicle Was Consuming A Lot of oil. oil was leaking out and going through the exhaust system, per several mechanics.*ak |
| JEEP GRAND CHEROKEE 1996 | While Driving At 30 Mph, the vehicle stalled. when this occurred, the steering wheel locked up and the brakes failed to function. |
| JEEP WRANGLER 1999 | I Have A 1999 Jeep wrangler. the exhaust manifold cracked. at first i thought it was just mine but after some |
| JEEP GRAND CHEROKEE 1996 | Defective Exhaust Manifold. Cracks |
| JEEP WRANGLER 1995 | I Own A 1995 Jeep wrangler, sahara model, and the question i have is that the exhaust manifold is cracked. the |
| JEEP WRANGLER 1995 | While Parked The Vehicle Emergency brake failed which caused the vehicle to roll backwards and hit a van. the vehicles fuel sensor, |
| JEEP WRANGLER 1998 | A Cracked Exhaust Header Caused exhaust fumes to enter the passenger compartment of the vehicle. *nlm |
| JEEP WRANGLER 1997 | Exhaust Manifold Has Completely Failed due to severe cracking at 54,000 mi/ although this is apparently a defect in '97 jeep exhaust manifolds (based |
| JEEP CHEROKEE 1997 | 1997 Jeep Cherokee. ehaust manifold crack. i have friends who own 98 and 99 cherokee's with the same problem. |
On This Page
- Select and View Jeep Engine And Engine Cooling Exhaust System Problems
- Discuss Jeep Engine And Engine Cooling Exhaust System Problems
My 2006 Grand Cherokee Overland with Hemi engine is not reading Fuel Level correct, I fill tank to full and gauge shows 3/4 of a tank now I fill tank to full and it is showing 1/2 a tank, it appears to be dropping. I have been told it might be the The dash board lights on my 2007 Jeep Commander continue to flash on and off and at times the headlights will also quit. It does happen in cold weather and the last time the check engine light stayed on. I replaced the battery and all seemed wel 2004 Jeep Grand Cherokee was in park on driveway, with engine off. Vehicle rolled backwards and into the street. I welcome thoughts, ideas, issues, advice, etc. JHJ When I turn off the engine and put my 1993 Jeep Grand Cherokee Limited in park. I stayed in about a min. and I noticed that the Jeep was rocking or moved backwards a bit. I got out and heard a clicking noice on the driver side near the wheel then I turn the key off and remove it. About 10-15 seconds later the dash engine light comes on as well as the buzzer. These are real faint, but after a while it drains the battery. I have to disconnect the battery cables to keep this from happening.