Car-and-Safety.com
Volvo Xc90 2005 Safety Reports and Reviews
Volvo Xc90 2005 Reviews
Volvo Xc90 2005 Wheels Lugs/nuts/boltsVolvo Xc90 2005 Wheels Lugs/nuts/bolts Review #10135911 VOLVO XC90 2005 car safety problem was reported on Aug 16, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with WHEELS:LUGS/NUTS/BOLTS . on february 16 of this year, i hit some black ice that caused me to hit a curb sideways. the impact knocked the front driver's side wheel off. the car was towed to the ken garff service department at the southtowne location in sandy, ut where it was "repaired". a free loaner car was given to me, and the charges were covered by my insurance. at that time the car had approx 3700 miles on it. since that repair i have driven the car approx 5000 miles. i had the 7500 mile service completed at the ken garff downtown slc location around july 15th. at that time, it is my understanding that they check the car over for any and all safety issues. on august 15th, i drove from elko, nv to lakewood, co, with my 14 month old baby. the 750 mile drive took us via i-70 and the mountains of colorado. on aug 16th, i drove 1 block from my parent's house to a store, when i was pulling out of the parking place the car wouldn't move. i got out to see what the trouble was and the left front wheel was lying completely sideways. a bolt had come out of the a frame and therefore the wheel fell off. the car was towed to rickenbaugh volvo in downtown denver to be repaired. *nm .0 person(s) were injured. 0 person(s) died.Mileage was 8700 miles. Vehicle Identification Number (VIN):YV1CZ592X51. Volvo Xc90 2005 problem was reported in ELKO, NV. Original Owner. Vehicle was purchased on Dec 16, 2004. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 1 mph. DEALER'S NAME: KEN GARFF . DEALER'S TELEPHONE NUMBER: 801-257-3530 . DEALER'S CITY: SALT LAKE CITY . DEALER'S STATE CODE: UT. DEALER'S ZIPCODE: 84110 . Volvo Xc90 2005 Interior LightingVolvo Xc90 2005 Interior Lighting Review #10136106 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with INTERIOR LIGHTING . the lighting of dash instruments, i.e. radio and hvac controls is too dim to read during normal sunny daylight conditions. this condition creates a safety hazard in that the driver cannot see important information.*jb.Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in KNOXVILLE, TN. Original Owner. Vehicle was purchased on Feb 18, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. Volvo Xc90 2005 SteeringVolvo Xc90 2005 Steering Review #10139754 VOLVO XC90 2005 car safety problem was reported on Oct 14, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STEERING . at time of purchase, a vibration from the front of vehicle occurs upon turning, manufacturer replaced entire steering assembly after 5k miles. other volvo xc90 owners have had similar problems and repairs of steering assembly at this time i would like to bring the issue to nstb as it may reflect potential safety issues if not repaired..Mileage was 100 miles. Vehicle Identification Number (VIN):YV1CZ852051. Volvo Xc90 2005 problem was reported in LAGUNA NIGUEL, CA. Original Owner. Vehicle was purchased on Apr 18, 2005. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: POWER VOLVO . DEALER'S TELEPHONE NUMBER: 949-454-2999 . DEALER'S CITY: IRVINE . DEALER'S STATE CODE: CA. DEALER'S ZIPCODE: 92618 . Volvo Xc90 2005 Fuel System, Other Delivery Fuel PumpVolvo Xc90 2005 Fuel System, Other Delivery Fuel Pump Review #10148501 VOLVO XC90 2005 car safety problem was reported on Dec 15, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP . volvo xc90 awd: this vehicle has failed three times with me and once with the dealer. december 2005 the vehicles failed to start. i had it towed to the local dealership. the problem was a fuel pump malfunction. fuel pump was replaced, and i drove the truck maybe a good two weeks and early one morning on the interstate the vehicle just slowed speed to 20 mph. i merged right and the vehicle cut of after waiting a short time i stated the vehicle again and it continued with the same malfunctions. after about 1 hour and a half i arrive to my 20-minute destination and called roadside service again and had the vehicle towed in to the same dealer. after approximately three days the service department calls me in and tells me the vehicle was ready to be pick-up. the problem was their technician forgot to reset the computer system, which cased the vehicle to quit while driving. i accepted my vehicle and representative informed me that the problem was taken care of it was their fault and he apologized..... okay, three days later the vehicle did the same thing with my children and i on the interstate again i called roadside, vehicle was towed in and i was told that the fuel sensors were faulty and they needed to be replaced. itã¿â¢ã¿â¿ã¿â¿s been about 8 days later my vehicle is still at volvo. i called today and the service manager with all honesty informed me that they didn't know what the problem was however; there's definitely a problem, because the vehicle cut off again when they test drove the vehicle.*ak .0 person(s) were injured. 0 person(s) died.Mileage was 11900 miles. Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in COLUMBUS, GA. Original Owner. Vehicle was purchased on Nov 24, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 70 mph. DEALER'S NAME: COLUMBUS MOTOR CO/VOLVO MILITARY SALES E. Volvo Xc90 2005 Equipment Other Owners/service/other ManualVolvo Xc90 2005 Equipment Other Owners/service/other Manual Review #10149708 VOLVO XC90 2005 car safety problem was reported on Aug 17, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL . dt*: the contact stated the towing capacity listed in the owner's manual conflicts with a brochure provided by the dealer. the brochure made no mention of third row seating having an impact on towing capacity while the owner's manual indicated the third row seating reduced towing capacity. while towing a snowmobile traveling 30mph the vehicle experienced a loss of power, the rear of the vehicle dropped down and the front wheels lost traction. the vehicle was inspected by a regional representative from the manufacturer who was unable to determine there was a problem. *ak.Mileage was 3000 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in STROUDSBURG, PA. Original Owner. Vehicle was purchased on Apr 03, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 30 mph. DEALER'S NAME: ERTLE VOLVO . DEALER'S TELEPHONE NUMBER: 570-421-4141 . DEALER'S CITY: STROUDSBURG . DEALER'S STATE CODE: PA. DEALER'S ZIPCODE: 18360 . Volvo Xc90 2005 Service Brakes, Hydraulic Foundation Components Disc CaliperVolvo Xc90 2005 Service Brakes, Hydraulic Foundation Components Disc Caliper Review #10156932 VOLVO XC90 2005 car safety problem was reported on May 05, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER . brake problem at 13000 miles and again at 25000, costly repair, the truck weighs 6000 lbs and brake system is not adequate for vehicle. caliper had to be replaced on new vehicle! please investigate, i know this will happen again, brakes have excessive dust, wear fast. *nm.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in CHICAGO, IL. Original Owner. Vehicle was purchased on Nov 15, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. Volvo Xc90 2005 Steering Linkages Tie Rod AssemblyVolvo Xc90 2005 Steering Linkages Tie Rod Assembly Review #10163449 VOLVO XC90 2005 car safety problem was reported on July 19, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STEERING:LINKAGES:TIE ROD ASSEMBLY . i took my 2005 volvo xc-90 to the dealership to have the outer tie rods replaced in conjunction with a recall notice i received from volvo. when i arrived at the dealership, i was told by the service adviser that i should have the rear wheels aligned because they were finding that when this recall service was being performed, the rear wheels needed alignment as well as the front wheels. i was also told that volvo would be paying for the front wheels to be aligned, but that i would have to pay for the rear wheel alignment at the special price of $59.95. i declined the rear wheel alignment because i felt it would be foolish to pay for something like this before knowing whether a problem really existed. several hours later, i received a call from the dealership saying that they were working on my car and that my rear wheels really did need to be aligned. not knowing what else to do, i consented to pay to have the work done. i returned from the dealership with the recall work completed and my wallet having been emptied of $66.37 ($59.95 + tax and miscellaneous charges). i decided to write to you since i believe this whole process is blatantly unfair to the consumer. volvo recalls defective parts but only pays for the front wheels to be aligned, yet the dealership is saying that they are finding that all of the wheels need to be realigned? my car is about 15 months old, and i had my 15,000 mile service done in early june. at that time, my wheels were rotated and balanced and nothing was said indicating i had an alignment problem either in the front or the rear of the car. it seems to me that volvo is taking advantage of its customers by having them come in to have parts replaced "free" of charge only to walk out with a bill for "necessary" services which are "not covered". i don't know if others have experienced this, but i wanted to go on record with what happened to me. thank you for your time and attention. *jb.0 person(s) were injured. 0 person(s) died.Mileage was 16115 miles. Vehicle Identification Number (VIN):YV1CN592751. Volvo Xc90 2005 problem was reported in ATLANTA, GA. Original Owner. Vehicle was purchased on Apr 21, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: DYER & DYER VOLVO . DEALER'S CITY: ATLANTA . DEALER'S STATE CODE: GA. Volvo Xc90 2005 Tires Tread/beltVolvo Xc90 2005 Tires Tread/belt Review #10168086 VOLVO XC90 2005 car safety problem was reported on Sept 12, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with TIRES:TREAD/BELT . dt*: the contact stated while routine maintenance at 15,000 miles was performed, it was determined all four tires were 60% worn, and should be replaced. these are pirelli scorpion tires.*ak updated 10/25/2006 - *nm.Mileage was 16000 miles. Vehicle Identification Number (VIN):YV1CZ592351. Volvo Xc90 2005 problem was reported in MEDFORD, MA. Original Owner. Vehicle was purchased on Feb 19, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SAME AS TIRES . Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10171029 VOLVO XC90 2005 car safety problem was reported on Oct 16, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . the vehicle was bought back in 10/31/04. within weeks of having the vehicle, we noticed lost of power and performances if the vehicle. we called the dealer about it and said that it might just be due to the gas cap. as it turned out they had to replace a solenoid which part of the starter or some type of firing mechanism for the engine. after that problem was fixed, we had to continually bring the vehicle back to the dealer for the check engine constantly coming on. this went on for numerous times until they found a relay problem. last friday my wife, who primarily drives the car, complained about the performance and lost of power issue. i test drove the vehicle and confirmed her worries about the vehicle. the vehicle does not accelerate properly and a sudden jerk or rise of rpm when it hits its mark. also around 60 mph and 70 mph you can hear obvious noise from the engine. at idle for about a minute you can smell something burning in the engine compartment. the vehicle will be taken to dealer on 10/17/06. *nm.0 person(s) were injured. 0 person(s) died.Mileage was 37300 miles. Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in AMERICAN CANYON, CA. Original Owner. Vehicle was purchased on Oct 31, 2004. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 60 mph. DEALER'S NAME: VOLVO MARIN . Volvo Xc90 2005 Visibility Windshield Wiper/washerVolvo Xc90 2005 Visibility Windshield Wiper/washer Review #10172906 VOLVO XC90 2005 car safety problem was reported on Nov 08, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with VISIBILITY:WINDSHIELD WIPER/WASHER . windshield wipers leave a streak across windshield, significantly impairing vision and making driving in rain hazardous. both wiper blades and windshield wiper arms were replaced by dealer - problem persists. this has been an ongoing issue since the car was purchased; dealer acknowledge the problem but has not adequately repaired the car. *jb.Volvo Xc90 2005 problem was reported in VIRGINIA BEACH, VA. Original Owner. Vehicle was purchased on Oct 22, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.DEALER'S NAME: PHILLIPS VOLVO . DEALER'S CITY: VIRGINIA BEACH . DEALER'S STATE CODE: VA. Volvo Xc90 2005 Air Bags FrontalVolvo Xc90 2005 Air Bags Frontal Review #10173453 VOLVO XC90 2005 car safety problem was reported on Mar 01, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with AIR BAGS:FRONTAL . dt*: the contact stated the passenger front airbag light illuminated intermittently. the vehicle was taken to a local dealer who could not duplicate the problem. the general manager suggested that the contact take the vehicle to another dealership for service because the dealer was not willing to service or further examine the vehicle..Vehicle Identification Number (VIN):YV1CZ592251. Volvo Xc90 2005 problem was reported in THOMASVILLE, NC. Vehicle was purchased on Mar 01, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: CROWN VOLVO . Volvo Xc90 2005 TiresVolvo Xc90 2005 Tires Review #10174269 VOLVO XC90 2005 car safety problem was reported on Nov 15, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with TIRES . i brought my 2005 xc90 in for routine maintenance at 25,500 miles. at that time, it was determined three of the four tires were worn on the outer edges and should be replaced. this is unacceptable for a vehicle to have three of its tires replaced within the first 25k miles of service. something is obviously wrong with either the tires or the vehicle dynamics. *jb.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in EAST NORTHPORT, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: HASSEL VOLVO . Volvo Xc90 2005 Tires Tread/beltVolvo Xc90 2005 Tires Tread/belt Review #10179457 VOLVO XC90 2005 car safety problem was reported on Jan 07, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with TIRES:TREAD/BELT . the type of tires volvo is putting on the xc90 is too soft leading to premature tire failure. volvo replaced the tires with the same type/brand and the tires have again worn. i have had two sets of tires with in 35,000 miles. researching the web has confirmed this is a problem vovlo xc90 wide. *nm.Volvo Xc90 2005 problem was reported in WAHOO, NE. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: GORGES VOLVO . Volvo Xc90 2005 Tires SidewallVolvo Xc90 2005 Tires Sidewall Review #10181317 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with TIRES:SIDEWALL . tl* - the contact owns a 2005 xc90 volvo. the contact stated that there was a safety recall on the vehicle which was issued may 3 2006. she was not notified of the safety recall until she took the vehicle to dealer for scheduled maintenance in january 2007. the contact believed that the problems she currently had with the tires having uneven wear and wearing down to the indicators, and cracked tread were caused by the defect stated in safety recall 06v155000.the recall stated that the outer tie rod ball joint could deform at high loads causing a loss of the clamping force ,and the nut may loosen, which may eventually lead to a fatigue fracture of the outer tie rod ball joint. the contact stated that the tires currently have 17,000 miles, the failure mileage was 12000. the contact would like to have the tires replaced by the manufacturer. *ak the tires wearing were due to the recall. updated 03/19/07. *jb.Mileage was 12000 miles. Vehicle Identification Number (VIN):YV1CY592851. Volvo Xc90 2005 problem was reported in RICHLANDS, NC. Original Owner. Vehicle was purchased on Jan 01, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:FWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: LARRY MENKE VOLVO . DEALER'S TELEPHONE NUMBER: 831-394-3374 . DEALER'S CITY: SEASIDE . DEALER'S STATE CODE: CA. DEALER'S ZIPCODE: 93955 . Volvo Xc90 2005 Steering Linkages Tie Rod AssemblyVolvo Xc90 2005 Steering Linkages Tie Rod Assembly Review #10181317 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STEERING:LINKAGES:TIE ROD ASSEMBLY . tl* - the contact owns a 2005 xc90 volvo. the contact stated that there was a safety recall on the vehicle which was issued may 3 2006. she was not notified of the safety recall until she took the vehicle to dealer for scheduled maintenance in january 2007. the contact believed that the problems she currently had with the tires having uneven wear and wearing down to the indicators, and cracked tread were caused by the defect stated in safety recall 06v155000.the recall stated that the outer tie rod ball joint could deform at high loads causing a loss of the clamping force ,and the nut may loosen, which may eventually lead to a fatigue fracture of the outer tie rod ball joint. the contact stated that the tires currently have 17,000 miles, the failure mileage was 12000. the contact would like to have the tires replaced by the manufacturer. *ak the tires wearing were due to the recall. updated 03/19/07. *jb.Mileage was 12000 miles. Vehicle Identification Number (VIN):YV1CY592851. Volvo Xc90 2005 problem was reported in RICHLANDS, NC. Original Owner. Vehicle was purchased on Jan 01, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:FWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: LARRY MENKE VOLVO . DEALER'S TELEPHONE NUMBER: 831-394-3374 . DEALER'S CITY: SEASIDE . DEALER'S STATE CODE: CA. DEALER'S ZIPCODE: 93955 . Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10184920 VOLVO XC90 2005 car safety problem was reported on Feb 28, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i was driving my 2005 volvo xc90 awd a from my home to work(about 20 miles) when i was parking the car on a parking lot, i noticed smoke coming from under the hood. the next moment i saw a little fire coming from under the hood. i stopped the car and got out. the fire was getting bigger and bigger. i immediately called 911. by the time the fire engine arrived the car was in flames, and the front windshield cracked and fell inside the car. the front seats and my personal property were burned. *jb.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 22950 miles. Vehicle Identification Number (VIN):YV1CZ592751. Volvo Xc90 2005 problem was reported in OLD GREENWICH, CT. Accident was reported to Police. Original Owner. Vehicle was purchased on Mar 15, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 5 mph. DEALER'S NAME: STAMFORD VOLVO . DEALER'S TELEPHONE NUMBER: 800-281-8658 . DEALER'S CITY: STAMFORD . DEALER'S STATE CODE: CT. DEALER'S ZIPCODE: 06902 . Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10186118 VOLVO XC90 2005 car safety problem was reported on Mar 21, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . this vehicle was purchased outright as a new vehicle in february 2005. this 2005 xc90, fwd with approximately 13,880 miles had a complete transmission failure on 03/21/2007. day prior to the event, an odd noise was heard on driver's side of vehicle. upon acceleration vehicle would hesitate then lunge forward. service department called upon arrival at home. the following morning, on way to dealership/service, 2 blocks from there vehicle lost power and would no longer accelerate. was notified that a new transmission was needed. currently am awaiting new transmission. as per service this was under warranty. service dept and volvo na, stated that the new transmission will only be covered for the remainder of the new car warranty period which would be approximately 2 years.*ak.Mileage was 13880 miles. Vehicle Identification Number (VIN):YV1CN592351. Volvo Xc90 2005 problem was reported in PLAINEDGE, NY. Original Owner. Vehicle was purchased on Feb 12, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:FWD. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10186341 VOLVO XC90 2005 car safety problem was reported on Feb 28, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . tl* - the contact owns a 2005 volvo x90. while driving 10 mph smoke came from under the hood. there were no warning indicators. the vehicle was pulled over, and the fire was extinguished by the fire department. the cause of the fire was undetermined. the failure mileage was 23,000. there were no injuries. the vehicle was destroyed. a fire report filed, and the contact has pictures. *ak.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 23000 miles. Vehicle Identification Number (VIN):YV1CZ592751. Volvo Xc90 2005 problem was reported in OLD GREENWICH, CT. Accident was reported to Police. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 10 mph. DEALER'S NAME: STANFORD VOLVO . DEALER'S CITY: STANFORD . DEALER'S STATE CODE: CT. Volvo Xc90 2005 Electrical System Battery CablesVolvo Xc90 2005 Electrical System Battery Cables Review #10207336 VOLVO XC90 2005 car safety problem was reported on Oct 27, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM:BATTERY:CABLES . tl*the contact owns a 2005 volvo xc90. the contact noticed a burning smell inside the passenger compartment. the vehicle would not start and was towed to the repair shop. the mechanic stated that the jack crank handle caused the failure. the contact was unsure if the vehicle was included in nhtsa campaign id number 07v221000 (electrical system:battery:cables). the current and failure mileages were 25,000. .0 person(s) were injured. 0 person(s) died.Mileage was 25000 miles. Vehicle Identification Number (VIN):YV1CY592151. Volvo Xc90 2005 problem was reported in WEST PALM BEACH, FL. Original Owner. Vehicle was purchased on Mar 12, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: WESTON VOLVO . Volvo Xc90 2005 Engine And Engine Cooling Cooling SystemVolvo Xc90 2005 Engine And Engine Cooling Cooling System Review #10212179 VOLVO XC90 2005 car safety problem was reported on Dec 11, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . the heater pipes that go through the firewall have corroded in less than 2 years and north point volvo wants a $1,000.00 to take of the dash and replace this part on the heater which in and of itself is only a $40.00 part. this pipe should not be defective on a car that's less than two years old. poor quality!!!!!!!!!! *tr.Mileage was 52000 miles. Vehicle Identification Number (VIN):YV1CY592151. Volvo Xc90 2005 problem was reported in WOODSTOCK, GA. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: NORTH POINT VOLVO . DEALER'S TELEPHONE NUMBER: 6783650600 . DEALER'S CITY: ALPHARETTA . DEALER'S STATE CODE: GA. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10214202 VOLVO XC90 2005 car safety problem was reported on Dec 02, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . transmission went out at 62k miles and had to be replaced. checking on edmunds website, this appears to be a very common problem with this vehicle. *tr.Mileage was 62000 miles. Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in SNELLVILLE, GA. Original Owner. Vehicle was purchased on Dec 09, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10215546 VOLVO XC90 2005 car safety problem was reported on Jan 11, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . while driving on the freeway, the instrument panel went dak, signals stopped working, stereo and other electrical devices quit working. the car still ran. the dealer has been unable to detect and fix the problems after one week and does not know when and states that the problem is in the central computer. on three other occasion this car has been to volve dealer for computer system upgrade; once for idling erratically, once for passenger side window not stopping when it reached maximum closure height and once for stereo system not ejecting cds. *tr.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):YV1CZ592351. Volvo Xc90 2005 problem was reported in APEX, NC. Original Owner. Vehicle was purchased on Dec 08, 2004. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. DEALER'S NAME: VOLVO OF CARY . DEALER'S CITY: CARY . DEALER'S STATE CODE: NC. Volvo Xc90 2005 Latches/locks/linkages Doors LatchVolvo Xc90 2005 Latches/locks/linkages Doors Latch Review #10215616 VOLVO XC90 2005 car safety problem was reported on Nov 01, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with LATCHES/LOCKS/LINKAGES:DOORS:LATCH . driver's door will not latch properly. must recycle the lock (lock then unlock, sometimes more than once) in order to get the door to latch shut. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 61500 miles. Vehicle Identification Number (VIN):YV1CY592651. Volvo Xc90 2005 problem was reported in LOUISVILLE, KY. Original Owner. Vehicle was purchased on Nov 26, 2004. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:FWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive)Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive) Review #10216138 VOLVO XC90 2005 car safety problem was reported on Jan 06, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . angle iron failed in volvo xc90. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 76000 miles. Volvo Xc90 2005 problem was reported in PETERBOROUGH, NH. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Volvo Xc90 2005 drive type:4WD. VEHICLE SPEED: 65 mph. DEALER'S NAME: LEE VOLVO . DEALER'S CITY: WELLESLEY . DEALER'S STATE CODE: MA. Volvo Xc90 2005 Fuel System, Gasoline Delivery Fuel PumpVolvo Xc90 2005 Fuel System, Gasoline Delivery Fuel Pump Review #10218274 VOLVO XC90 2005 car safety problem was reported on Feb 12, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP . car stalled twice at 65mph while on freeway. first incident was 24nov06, 2nd incident was 12 feb 07. on first incident all car functions completely died and went into "limp mode" after swerving to stop, and was towed to bellingham wa (king volvo) dealer for "software upgrade on fuel pump". on 2nd incident car went into "reduced engine performance" after restart. i drove the car home 350miles although volvo suggested towing. i just traded the car in today on an acura as volvo wasn't interested in helping me beyond a $3k incentive towards a new volvo. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 30200 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in SAMMAMISH, WA. Original Owner. Vehicle was purchased on Feb 25, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:4WD. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 65 mph. DEALER'S NAME: BARRIER VOLVO . DEALER'S TELEPHONE NUMBER: 425-637-7294 . DEALER'S CITY: BELLEVUE . DEALER'S STATE CODE: WA. DEALER'S ZIPCODE: 98052 . Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive)Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive) Review #10220743 VOLVO XC90 2005 car safety problem was reported on Dec 10, 2007.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . the all wheel drive feature went out hence leaving the drive to two wheel drive ; the two wheel drive is very unbalance in snow / ice as oppose to a normal front wheel drive vehicle; ended up on the side of the road avoiding accident; contacted the manufacturer and they claim this is not a safety issue which i disagree; currently do not drive the vehicle in snow / ice due to unsafe driving condition. contacted different volvo dealers and claim a high failure rate of this feature. volvo requested $3,000 to fix issue; have not agreed to these costs yet. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 65000 miles. Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in BELMONT, MI. Original Owner. Vehicle was purchased on Feb 15, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 20 mph. DEALER'S NAME: BETTEN IMPORTS VOLVO . DEALER'S TELEPHONE NUMBER: +1 (616) 301-2100 . DEALER'S CITY: GRAND RAPIDS . DEALER'S STATE CODE: MI. DEALER'S ZIPCODE: 49546 . Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10231691 VOLVO XC90 2005 car safety problem was reported on June 17, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i currently own a volvo xc90 t-6 2005. the transmission began to slip in first gear, i had a volvo dealership take a look at it about 6,000 miles ago. now, the urgent service light came on and volvo states that the transmission needs to be replaced. many others have experienced these same issues, so what is volvo not fixing these issues. i will never, never purchase a volvo again. *tr.Mileage was 103000 miles. Volvo Xc90 2005 problem was reported in WOODSTOCK, MD. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Power Train Automatic Transmission Review #10234240 VOLVO XC90 2005 car safety problem was reported on July 02, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have a 2005 volvo xc90 t6. the transmission failed at 60,000 miles and will cost $4600+ to repair. the transmission should last longer than 60,000 miles unless there is a defect in design. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 60450 miles. Volvo Xc90 2005 problem was reported in BELLEVUE, NE. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10234817 VOLVO XC90 2005 car safety problem was reported on July 15, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . while driving my 2005 volvo xc90 noticed the transmission slipping. the slipping started in the just two after purchased and it was taken to the dealership at the factory schedule maintenance intervals. on july 15, 2008 while my wife was driving the vehicle with my two children that transmission slipped and got stuck is a gear that prevented my wife going more than twenty miles per hour on a very busy street. the vehicle has 72,000 miles on it. *tr.Mileage was 72350 miles. Volvo Xc90 2005 problem was reported in STEVENSON RANCH, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Service Brakes, Hydraulic Pedals And LinkagesVolvo Xc90 2005 Service Brakes, Hydraulic Pedals And Linkages Review #10243300 VOLVO XC90 2005 car safety problem was reported on Sept 20, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES . tl*the contact owns a 2005 volvo xc90. the contact noticed that the space between the accelerator and brake pedals was only 4 1/2 inches wide. the width of his foot is 5 inches wide. there is an insufficient amount of space to adequately apply pressure to the accelerator pedal without also depressing the brake pedal. the dealer stated that they were aware of the failure, but have not made any efforts to correct the design. the vin was unknown. the failure and current mileages were 54,000. .0 person(s) were injured. 0 person(s) died.Mileage was 54000 miles. Volvo Xc90 2005 problem was reported in GLENDALE, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Vehicle Speed ControlVolvo Xc90 2005 Vehicle Speed Control Review #10243300 VOLVO XC90 2005 car safety problem was reported on Sept 20, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with VEHICLE SPEED CONTROL . tl*the contact owns a 2005 volvo xc90. the contact noticed that the space between the accelerator and brake pedals was only 4 1/2 inches wide. the width of his foot is 5 inches wide. there is an insufficient amount of space to adequately apply pressure to the accelerator pedal without also depressing the brake pedal. the dealer stated that they were aware of the failure, but have not made any efforts to correct the design. the vin was unknown. the failure and current mileages were 54,000. .0 person(s) were injured. 0 person(s) died.Mileage was 54000 miles. Volvo Xc90 2005 problem was reported in GLENDALE, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10244460 VOLVO XC90 2005 car safety problem was reported on Oct 05, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have had my 2005 t6 xc90 for 5 months and until today have only dealt with small issues. today i was on the freeway and lost transmission power at 65 mph and the event could have been catastrophic, however i was lucky enough to regain transmission control and could get to an exit and park my vehicle in a safe place to await a tow. i had no idea that the t6 was known for this type of failure with the transmission or i would never have bought it. i have two little girls and their safety was the key element in my purchasing this vehicle. all things considered, today could have been much worse but according to many accounts this isn't the first t6 to have tranny problems and it won't be the last. until volvo is made to acknowledge that their design was faulty other families' lives are at stake. i know my xc90 will need a new transmission, and the cost is going to be upwards of $6,000. and for a "volvo for life" this is unacceptable!! *tr.Mileage was 122239 miles. Volvo Xc90 2005 problem was reported in FREEPORT, MN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10254441 VOLVO XC90 2005 car safety problem was reported on Dec 18, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . the transmission in my 2005 volvo xc 90, failed in traffic on dec. 18th. after doing some research this is a very common issue. the car only had 63,200 miles on it and had been regularly serviced. the links below, show that this is a common issue which volvo is aware of but failing to make public. http://townhall-talk.edmunds.com/direct/view/.f18a651/132 http://www.consumeraffairs.com/automotive/volvo.htm http://townhall-talk.edmunds.com/direct/view/.ef21566/1030 i believe there should be a recall, as people are having to pay $3000 - $5000, to replace a defective part. if you check the links, some users have had to replace the transmission multiple times. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 63200 miles. Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in ROCKFORD, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 5 mph. Volvo Xc90 2005 Tires Pressure Monitoring And Regulating SystemsVolvo Xc90 2005 Tires Pressure Monitoring And Regulating Systems Review #10257656 VOLVO XC90 2005 car safety problem was reported on Feb 04, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS . while driving my 2005 volvo xc90 (54,414 miles) on a busy california freeway (the 405), the engine stopped suddenly with no warning or warning light. fortunately, i was able to make it over to the side of the road to call for a tow without injury (although i was almost rear ended since the failure was so sudden and without warning) and had it towed to a volvo dealer in torrance, ca. it is a transmission problem. since then, we have found hundreds of other consumers who have had the same problem with their xc90 volvos too. volvo has not recalled or provided any notice to consumers of the problem. volvo has provided replacement trades and cash to some consumers who complained, but no overall notice to consumers. we didn't find out until it happened to us and started to research. additionally, the week before, the front left tire blew out when my wife was driving and i was out of town. uneven tire wear, uneven wear even with constant realignment, is another common issue with the 18" tires on volvo. they know of the issue, but not how to fix it. volvo did at least send a tow truck to put the spare on and my wife was not injured (fortunately). we didn't know of the safely flaws in the xc90 which was purchased because of volvo's marketing campaign of "safety" and "volvo for life" campaign. volvo is advertising falsely and the xc90 has safety issues. please help protect others! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 54414 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in PALOS VERDES ESTATES, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10257656 VOLVO XC90 2005 car safety problem was reported on Feb 04, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . while driving my 2005 volvo xc90 (54,414 miles) on a busy california freeway (the 405), the engine stopped suddenly with no warning or warning light. fortunately, i was able to make it over to the side of the road to call for a tow without injury (although i was almost rear ended since the failure was so sudden and without warning) and had it towed to a volvo dealer in torrance, ca. it is a transmission problem. since then, we have found hundreds of other consumers who have had the same problem with their xc90 volvos too. volvo has not recalled or provided any notice to consumers of the problem. volvo has provided replacement trades and cash to some consumers who complained, but no overall notice to consumers. we didn't find out until it happened to us and started to research. additionally, the week before, the front left tire blew out when my wife was driving and i was out of town. uneven tire wear, uneven wear even with constant realignment, is another common issue with the 18" tires on volvo. they know of the issue, but not how to fix it. volvo did at least send a tow truck to put the spare on and my wife was not injured (fortunately). we didn't know of the safely flaws in the xc90 which was purchased because of volvo's marketing campaign of "safety" and "volvo for life" campaign. volvo is advertising falsely and the xc90 has safety issues. please help protect others! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 54414 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in PALOS VERDES ESTATES, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Unknown Or OtherVolvo Xc90 2005 Unknown Or Other Review #10257656 VOLVO XC90 2005 car safety problem was reported on Feb 04, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with UNKNOWN OR OTHER . while driving my 2005 volvo xc90 (54,414 miles) on a busy california freeway (the 405), the engine stopped suddenly with no warning or warning light. fortunately, i was able to make it over to the side of the road to call for a tow without injury (although i was almost rear ended since the failure was so sudden and without warning) and had it towed to a volvo dealer in torrance, ca. it is a transmission problem. since then, we have found hundreds of other consumers who have had the same problem with their xc90 volvos too. volvo has not recalled or provided any notice to consumers of the problem. volvo has provided replacement trades and cash to some consumers who complained, but no overall notice to consumers. we didn't find out until it happened to us and started to research. additionally, the week before, the front left tire blew out when my wife was driving and i was out of town. uneven tire wear, uneven wear even with constant realignment, is another common issue with the 18" tires on volvo. they know of the issue, but not how to fix it. volvo did at least send a tow truck to put the spare on and my wife was not injured (fortunately). we didn't know of the safely flaws in the xc90 which was purchased because of volvo's marketing campaign of "safety" and "volvo for life" campaign. volvo is advertising falsely and the xc90 has safety issues. please help protect others! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 54414 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in PALOS VERDES ESTATES, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10258423 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have the ill fated xc90 t6...like clockwork at 53000 miles the dreaded transmission service urgent light comes on....now i am supposed to fork over 7000 bucks for a completely defective transmission! *tr.Mileage was 53000 miles. Volvo Xc90 2005 problem was reported in EDMOND, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Power Train DrivelineVolvo Xc90 2005 Power Train Driveline Review #10258423 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:DRIVELINE . i have the ill fated xc90 t6...like clockwork at 53000 miles the dreaded transmission service urgent light comes on....now i am supposed to fork over 7000 bucks for a completely defective transmission! *tr.Mileage was 53000 miles. Volvo Xc90 2005 problem was reported in EDMOND, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Power Train Review #10258423 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . i have the ill fated xc90 t6...like clockwork at 53000 miles the dreaded transmission service urgent light comes on....now i am supposed to fork over 7000 bucks for a completely defective transmission! *tr.Mileage was 53000 miles. Volvo Xc90 2005 problem was reported in EDMOND, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10260199 VOLVO XC90 2005 car safety problem was reported on Jan 22, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . coming to a stop sign, on a rural road, funny noise, then urgent transmission light came on. didn't hear anything, tried to move vehicle, go up a hill and it seem as if i lost first and second gear. towed to shop, they got the light to come off, they believe it needs a transmission but won't do anything. i'm trying to drive it occasionally and i've almost gotten stuck twice. transmission is slipping badly and locking intermittently. *tr.Mileage was 70000 miles. Volvo Xc90 2005 problem was reported in SIMSBURY, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 10 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10263722 VOLVO XC90 2005 car safety problem was reported on June 19, 2008.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . transmission failure at less than 65000 miles. originally reported at 54756 miles. oem warranty expired at 50,000 miles. own extended warranty but so far dealer has had vehicle 3 times over course of last 9 months and unable to get extended warranty company to replace transmission. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 54756 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in FISHERS, IN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10273725 VOLVO XC90 2005 car safety problem was reported on June 02, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have a 2005 volvo xc90 t6 the transmission just failed at only 75000 miles. my son bought the same car at the same time as me brand new. his transmission has been replaced twice. *tr.Mileage was 75000 miles. Volvo Xc90 2005 problem was reported in SUCCASUNNA, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10278145 VOLVO XC90 2005 car safety problem was reported on July 23, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . transmission on a 2005 volvo xc90 failed while driving on i-95 heading onto ri rt 37. thirty-five miles prior to this failure volvo dealer upgraded the software to remedy the "transmission service urgent" problem at a cost of $200. this seems to be a common and extremely costly problem among xc90s and must be remedied by volvo. *tr.Mileage was 102400 miles. Volvo Xc90 2005 problem was reported in COVENTRY, RI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10278245 VOLVO XC90 2005 car safety problem was reported on July 18, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . 2005 volvo xc-90, transmission failure. "transmission service urgent' light came on and the transmission began slipping at 131,997 miles; in july 2009. this was a new transmission, replaced by the dealer at 76,994 miles in january 2008. the vehicle has only been serviced by that dealership. the new transmission lasted less than 18 months and less than 54,000 miles at a cost of over $5,000.00. the replacement transmission was either defective or not new, which is what was proclaimed. *tr.Mileage was 131997 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in HODGES, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine Cooling Cooling SystemVolvo Xc90 2005 Engine And Engine Cooling Cooling System Review #10278646 VOLVO XC90 2005 car safety problem was reported on July 24, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . i have a 2005 volvo xc90 t6 with 71000 miles on it. on 7/23/09 the transmission began to "slip" and i took it to the volvo dealership on 7/24/09 for them to diagnose the problem. the transmission on this 4 year old vehicle need to be replaced at a cost of $5,300.00. volvo has been aware of the problem and so far has not owned up to responsibility. the transmission slips in low gears and upon acceleration. it is a safety issues because if the transmission slips while merging onto the highway it could cause an accident or at any other time for that matter. it is a very common problem and volvo should make this a recall to protect the safety of their customers but thus far there has been no recall. the transmission is on back order for 1 - 2 months which is completely unacceptable from any consumer or safety standpoint. *tr.Mileage was 71000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in DURHAM, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10278646 VOLVO XC90 2005 car safety problem was reported on July 24, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have a 2005 volvo xc90 t6 with 71000 miles on it. on 7/23/09 the transmission began to "slip" and i took it to the volvo dealership on 7/24/09 for them to diagnose the problem. the transmission on this 4 year old vehicle need to be replaced at a cost of $5,300.00. volvo has been aware of the problem and so far has not owned up to responsibility. the transmission slips in low gears and upon acceleration. it is a safety issues because if the transmission slips while merging onto the highway it could cause an accident or at any other time for that matter. it is a very common problem and volvo should make this a recall to protect the safety of their customers but thus far there has been no recall. the transmission is on back order for 1 - 2 months which is completely unacceptable from any consumer or safety standpoint. *tr.Mileage was 71000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in DURHAM, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10279847 VOLVO XC90 2005 car safety problem was reported on Apr 02, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . add me to the list of xc90 t6 owners that had to replace a defective transmission. i barely evaded a catastrophic accident when the trans failed at a busy intersection. there are thousands of posts on various forums detailing similar experiences. volvo has done nothing to address this irrefutable problem. what is the nhtsa doing to potentially save lives? like so many others, i have been quiet hoping that others speak up on my behalf. there are class action suits being initiated around the country. enough is enough. either volvo issue a recall and correct the issue or these vehicles should be replaced. i waited two months for the last transmission that was on back-order. hmmm, i wonder why it is on back-order? one doesn't need to be a genius to figure that out. i am 3k into the new trans and already experienced a slipped gear shift. i sense that there aren't many surprised by this. it is sad to say, but it will likely take some lost lives that are attributed to the faulty transmission before something is done. i didn't buy a volvo to worry about my family's welfare everytime they drive this vehicle. please help! *tr.Mileage was 51000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in BOYNTON BEACH, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Vehicle Speed ControlVolvo Xc90 2005 Vehicle Speed Control Review #10285742 VOLVO XC90 2005 car safety problem was reported on Sept 28, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with VEHICLE SPEED CONTROL . i had to wear wide width shoes due to my toe being pinched. i was driving a 2005 volvo xc90. a couple of times, instead of applying the brake, the shoe was on the accelerator. the gap between the accelerometer and brake is very little. when i was driving with a non-wide width shoe, i did not notice this problem. this happens almost all the time wearing this one particular shoe (4e wide). *tr.Vehicle Identification Number (VIN):YV1CY592751. Volvo Xc90 2005 problem was reported in SOUTHLAKE, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10292960 VOLVO XC90 2005 car safety problem was reported on Nov 13, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i am the owner of a 2005 xc90 volvo. this car only has 69,000 miles on it and the transmission has failed and needs to be replaced. my car broke down on a short road trip in the middle of no where on top of a snowy mountain. due to the poor quality of transmission coupled with the powerful engine the transmission shredded metal that reached the radiator and other coolant departments that also now need to be replaced. the total cost of repairing the damage caused is $6,700.00. i bought this car in hopes to have a secure vehicle to drive my kids around while my husband is deployed and expected to it last at least to 100,000 miles. the car is only 4 years old and should not be needing such extensive repairs. i contacted volvo and it is taking them a long time to get back to me. my car is sitting at a repair shop while i wait for a phone call to see if they will help cover the costs or not. a volvo technical support representative admitted to me that they are aware that this is a common problem with this year and make but were not saying that they would cover the expenses, rather she said that they would see if they could assist me in some way. i am dissatisfied with their lack of response and unwillingness to help correct their mistake. after doing some research it is obvious that many volvo owners of the cx90 2005 are having the same problem and this needs to be addressed and volvo needs to be help accountable for their faulty product, they need to sell cars that are safe for families to drive. *tr.Mileage was 69800 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in KLAMATH FALLS, OR. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10294466 VOLVO XC90 2005 car safety problem was reported on Nov 25, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . urgent service transmission light came on 2005 volvo xc90 t6 with 80,000 km. flush and new software tried to fix problem. it didn't solve anything. one month or two later the gears starting slipping from stopped position and while driving. light came on again. a large amount of sludge and filing were found in the pan. had to have to a complete rebuild of the transmission. *tr.Mileage was 85000 miles. Volvo Xc90 2005 problem was reported in CALEDONIA, 00. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10295099 VOLVO XC90 2005 car safety problem was reported on Nov 03, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . tl* the contact owns a 2005 volvo xc90. the bearings that were installed are steel. the bearings have deteriorated because they are not greased.. the vehicle was taken to the dealer for inspection. he was advised that the engine needed to be replaced at an expense of $16,000. the manufacturer has not been contacted. the failure mileage was 67,000. .Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in NORTH HOLLYWOOD, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10295111 VOLVO XC90 2005 car safety problem was reported on Dec 08, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . yesterday, our 2005 volvo xc90 stalled completely at around 84,000 miles and was towed for service. a diagnosis determined that the radiator leaked into the transmission causing a mechanical failure. this will likely require the replacement of the transmission and possibly the radiator. our extended warranty will cover the cost of major components such as the transmission and radiator but will not cover the new hoses and other required accessories. the nhtsa needs to act on this soon. as a brief search of the internet will show, these problems are far too common to be considered "normal wear and tear." most failures are occurring at around 4 years of age and between 50,000-88,000 miles. the frequency of failures in this make and model at the same age/mileage are clearly a result of a design and/or manufacturing defect. a mandatory safety recall seems to be the only logical resolution to this defect and would protect the safety of tens of thousands of us drivers who have yet to experience a transmission failure in this make and model. *tr.Mileage was 84400 miles. Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in VALRICO, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 15 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10297250 VOLVO XC90 2005 car safety problem was reported on Dec 13, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i am writing this letter to notify the nhtsa of a total system failure of my 2005 volvo xc90 that i believe was due to a manufacturer defect which should be part of a recall. after driving on the interstate (in extreme rainy conditions) for approx 2 hrs, the car displayed a warning message that read ?anti-skid disabled? and then ?brake system failure? at which point we experienced total brake failure. w/in a minute of this happening, the entire control panel illuminated then went blank and all the electronic components in the car turned off, including the windshield wipers. fortunately we were able to maneuver the car safely to side of the road (after the brakes reengaged)t. the car was towed to freedom volvo in va beach, va for inspection and repair. upon explaining the incident to the service mgr, we were informed that they were well aware of the problem we were describing as they had seen ?a rash? of this exact issue a few years back. i suspect that my car, with relatively low mileage for a 2005 (32,000), was just catching up with the other 2005 xc90?s that had already experienced the problem. the car was repaired without delay and ready for pick-up within two days. we were told the problem stemmed from water leaking in ?over time? through the engine bay harness which in effect caused the central electronic module (cem) to short out. after asking the service technician why this problem was not identified during the recommended maintenance check-ups (which was completed on our car just a few months prior to this incident), we were informed that this is not something that is inspected. he did go on to state that he has not seen any repeat problems for the vehicles that he had completed this exact repair. he also noted that the engine bay harness for the xc90 was redesigned after '06. i request that this problem with the engine bay harness on older model volvo xc90 be investigated. *tr.Mileage was 32357 miles. Vehicle Identification Number (VIN):YV1CZ592051. Volvo Xc90 2005 problem was reported in NORFOLK, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10297370 VOLVO XC90 2005 car safety problem was reported on Dec 15, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . we own a 2005 volvo xc90 and it has 54k miles on it. we heard a whining sound from the rear and took it to the dealer and they said the rear hub bearings need to be changed. we were not convinced and took it to our auto mechanic who works on our avalon, he looked at it and after spending 5hrs on it came to the conclusion that it was the rear differential. we went back to the volvo dealer and asked him to check again and said it may be the transmission. they came back and said yes it is the rear differential and it needs to be replaced. the price tag was for $5200. this seems to be the problem with all the xc90's. we are afraid to drive this car on the highway never knowing when our transmission will give way. *tr.Mileage was 54000 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in MINEOLA, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10298981 VOLVO XC90 2005 car safety problem was reported on Jan 01, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . we have recently had transmission failure on 2005 volvo xc90 t6 awd at 59,700 miles. we are 2nd owner and bought 12/31/09 with 59,074 and carfax check was stellar. the vehicle is just 9,700 miles out of warranty. we have contacted volvo usa concerning ¿goodwill policy¿ and vehicle is at tulsa dealer who are also working from their end. *tr .Mileage was 59700 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in TULSA, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10299965 VOLVO XC90 2005 car safety problem was reported on Jan 13, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i am the owner of a 2005 xc90 volvo with 79,000 miles on it and the transmission has failed and needs to be replaced. my car broke down on a busy interstate and i barely evaded a catastrophic accident when the trans failed and my vehicle came to an abrupt stop (endangering the life of my family of 7 traveling in the car). this common problem in the 2005 xc90's automatic transmissions are well documented throughout the internet by volvo owners. additionally, shredded metal reached the radiator and other coolant departments that also now need to be replaced. the total cost of repairing the damage caused is $6,700.00. i bought this car to provide my family a secure vehicle while i am deployed. i expected the vehicle to last at least to 100,000 miles. the car is only 4 years old and already needs the transmission replaced.. i contacted volvo and it is taking them a long time to get back to me. my car is sitting at a repair shop while i wait for a phone call to see if they will help cover the costs or not. a volvo technical support representative admitted to me that they are aware that this is a common problem with the 2005 model but are not saying that they would cover the expenses or initiate a recall, rather she said that they would "see" if they could assist me in some way. again, i have not heard from them and continue to call but have not made any progress with them. after doing some research it is obvious that many volvo owners of the xc90 2005 are having the same problem and this needs to be addressed by the nhtsa so that volvo is held accountable for a faulty product that has been clearly documented. there are thousands of posts on various forums detailing similar experiences. volvo has done nothing to address this irrefutable problem. what is the nhtsa doing to force volvo to initiate a recall? *tr.Mileage was 79000 miles. Vehicle Identification Number (VIN):YV1CZ911551. Volvo Xc90 2005 problem was reported in EWA BEACH, HI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine Cooling Cooling SystemVolvo Xc90 2005 Engine And Engine Cooling Cooling System Review #10299965 VOLVO XC90 2005 car safety problem was reported on Jan 13, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . i am the owner of a 2005 xc90 volvo with 79,000 miles on it and the transmission has failed and needs to be replaced. my car broke down on a busy interstate and i barely evaded a catastrophic accident when the trans failed and my vehicle came to an abrupt stop (endangering the life of my family of 7 traveling in the car). this common problem in the 2005 xc90's automatic transmissions are well documented throughout the internet by volvo owners. additionally, shredded metal reached the radiator and other coolant departments that also now need to be replaced. the total cost of repairing the damage caused is $6,700.00. i bought this car to provide my family a secure vehicle while i am deployed. i expected the vehicle to last at least to 100,000 miles. the car is only 4 years old and already needs the transmission replaced.. i contacted volvo and it is taking them a long time to get back to me. my car is sitting at a repair shop while i wait for a phone call to see if they will help cover the costs or not. a volvo technical support representative admitted to me that they are aware that this is a common problem with the 2005 model but are not saying that they would cover the expenses or initiate a recall, rather she said that they would "see" if they could assist me in some way. again, i have not heard from them and continue to call but have not made any progress with them. after doing some research it is obvious that many volvo owners of the xc90 2005 are having the same problem and this needs to be addressed by the nhtsa so that volvo is held accountable for a faulty product that has been clearly documented. there are thousands of posts on various forums detailing similar experiences. volvo has done nothing to address this irrefutable problem. what is the nhtsa doing to force volvo to initiate a recall? *tr.Mileage was 79000 miles. Vehicle Identification Number (VIN):YV1CZ911551. Volvo Xc90 2005 problem was reported in EWA BEACH, HI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10300323 VOLVO XC90 2005 car safety problem was reported on Jan 08, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl*the contact owns a 2005 volvo xc90. while driving 45 mph, he heard a loud noise. he shut the engine off and had the vehicle towed to a mechanic. he was told by the mechanic that the rear bearing needed to be replaced because there was no oil getting to the bearing (by design). he called the manufacturer and was informed that they could not assist him. the vehicle was being repaired when the complaint was filed. the current mileage was 76,431. the failure mileage was approximately 76,380..Mileage was 76380 miles. Vehicle Identification Number (VIN):YV1CZ852551. Volvo Xc90 2005 problem was reported in CHULA VISTA, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Steering Linkages Tie Rod AssemblyVolvo Xc90 2005 Steering Linkages Tie Rod Assembly Review #10310444 VOLVO XC90 2005 car safety problem was reported on Jan 23, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STEERING:LINKAGES:TIE ROD ASSEMBLY . i want to bring to your attention that there seems to be a problem with the volvo xc90 2005 rack and pinion going bad. i have been searching over the internet and there are so many people that are having the same problem. there must be an inferior workmanship/component, that is causing this part to become defective for so many customers. this problem is seriously dangerous as it causes the vehicle to develop sudden steering problem causing the vehicle to shift steering uncontrollably as soon as the brakes are applies when driving over 30 mph which can result in accident. the type pf shift (pull) tends to be even more dangerous when driver 60 miles an hour and it happens in very sudden and unexpected way. i hope that you take this seriously and you arrange for volvo to complete a recall or contact me about this as soon as possible. *tr the consumer stated there was a lot of stiffness when driving on the highway. the problem worsened after a few weeks and the vehicle became too dangerous to drive. the consumer took the vehicle to a local mechanic and it was determined that the tie rod end was faulty. the consumer called a local dealership and was informed there was a recall on the tie rod ends, but they were replaced back in 2006. the consumer stated the replacements parts were not up to standards. the local dealer did not want to replace the defective parts, so the local mechanic shop replaced the tie rods at a cost of $401.83. updated 06/16/10. *jb .Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in BROOKLYN, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 Steering Rack And PinionVolvo Xc90 2005 Steering Rack And Pinion Review #10310444 VOLVO XC90 2005 car safety problem was reported on Jan 23, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STEERING:RACK AND PINION . i want to bring to your attention that there seems to be a problem with the volvo xc90 2005 rack and pinion going bad. i have been searching over the internet and there are so many people that are having the same problem. there must be an inferior workmanship/component, that is causing this part to become defective for so many customers. this problem is seriously dangerous as it causes the vehicle to develop sudden steering problem causing the vehicle to shift steering uncontrollably as soon as the brakes are applies when driving over 30 mph which can result in accident. the type pf shift (pull) tends to be even more dangerous when driver 60 miles an hour and it happens in very sudden and unexpected way. i hope that you take this seriously and you arrange for volvo to complete a recall or contact me about this as soon as possible. *tr the consumer stated there was a lot of stiffness when driving on the highway. the problem worsened after a few weeks and the vehicle became too dangerous to drive. the consumer took the vehicle to a local mechanic and it was determined that the tie rod end was faulty. the consumer called a local dealership and was informed there was a recall on the tie rod ends, but they were replaced back in 2006. the consumer stated the replacements parts were not up to standards. the local dealer did not want to replace the defective parts, so the local mechanic shop replaced the tie rods at a cost of $401.83. updated 06/16/10. *jb .Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in BROOKLYN, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10310974 VOLVO XC90 2005 car safety problem was reported on Feb 14, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . we have a 2005 volvo xc90 t6 we had complained to volvo of a slipping transmission. they said it had no problems. now the transmission failed. we almost had an accident with our 3 small children. these cars need to be investigated. many have experienced problems and volvo is just replacing them with the same defective units. *tr.Mileage was 95000 miles. Vehicle Identification Number (VIN):YV1CZ911551. Volvo Xc90 2005 problem was reported in WEST CREEK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10313311 VOLVO XC90 2005 car safety problem was reported on Feb 13, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . ungreased bearing failing on 2005 v8 volvo xc90 a balance shaft bearing is failing due to the fact that the bearing is not greased and water can enter into the bearing cavity and make it rust. once this happens, it can produce a total engine failure, and besides the fact the engine is totally compromised and needs replacement, it would obviously impair the ability to drive the vehicle, especially at highway speeds. this particular car has an engine with only 60k miles, serviced regularly and with the last major service performed at a volvo dealer at about 50k miles. the car has been driven very lightly and it only has made about 10k miles in about two years. here is in summary what i found about this: -the bearing that is failing is not lubricated (so nothing to do with oil in this case), and it fails due to the fact that water and/or humidity gets to it, by washing the engine(?) ¿ never did that anyway - or by the car just sitting in a lot.. -there is a volvo bulletin that details what needs to be done, including drilling a weeping hole into the engine block to drain water; this shows that the problem is acknowledged and a fix has been put into place; it also shows that there is significant number of vehicles out there that have the same issue. -this seems to be a very common problem with this type of engine and year (2005 xc90, v8 engine, engine series less than #6800) ¿ i have pointed out a few threads below that mention the same issue. given all the reasons enumerated above, i am asking for an evaluation of this issue and i really feel volvo should recognize this as a design problem, issue a recall and step up to fix this issue. here are some pointers to different articles discussing this: http://forums.swedespeed.com/zerothread?id=132172 http://forums.swedespeed.com/zerothread?id=123707 http://forums.swedespeed.com/zerothread?id=126698 http://forums.swedespeed.com/zerothread?id=123707 http://www.v70xc.com/forums/showthread.php?p=104935. *tr.Mileage was 60000 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in SAN JOSE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10318392 VOLVO XC90 2005 car safety problem was reported on Feb 15, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . my car stalls while driving. when checked out by dealership they identified problems with the fuel pump. on your web site there is a recall for 2005 volvo xc90, which my car. however, volvo is declining my request to fix the fuel pump. *tr.Mileage was 105000 miles. Vehicle Identification Number (VIN):YV1CZ592651. Volvo Xc90 2005 problem was reported in LAS VEGAS, NV. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10322397 VOLVO XC90 2005 car safety problem was reported on Mar 26, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . my 2005 volvo xc90 t6 transmission has failed for a second time at 95,000 miles. this is the second defective transmission for the vehicle, which was originally replaced at 35,000 miles. while driving on the interstate and attempting to accelerate into traffic, the vehicle suddenly went into high rpms as if in "neutral", failed to properly accelerate, and the "service transmission warning" light came on. this dealer says the transmission must be replaced a second time. volvo is aware of the chronic problem with the 2003-2005 t6 version of the xc90 but thus far has not issued a recall. it is not unheard of for the vehicles to require 2 or three transmissions by 100,000 miles. there are hundreds if not thousands of similar reports available on internet websites. this is a dangerous situation because the vehicle suddenly stalls without warning while the driver is attempting to accelerate, such as when merging into interstate traffic..Mileage was 95000 miles. Vehicle Identification Number (VIN):YV1CZ911851. Volvo Xc90 2005 problem was reported in HOOVER, AL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10323233 VOLVO XC90 2005 car safety problem was reported on Mar 31, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i own a volvo 2005 xc90 and only 58,000 miles need to replace the transmission. i search in the internet for volvo xc90 transmission and it seems alot of people having the same problem with this model..Mileage was 58000 miles. Volvo Xc90 2005 problem was reported in SAN DIEGO, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10324165 VOLVO XC90 2005 car safety problem was reported on Nov 16, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . counter balance bearing failed at 55,504 miles. non-greased bearing failure, caused by rusting, due to moisture build up inside of engine chamber. vehicle had all required service done a volvo dealerships. engine was repaired not replaced, for a cost of $5000.00. repair work was done at volvo dealership. volvo mechanic drilled weeping hole in chamber where counter balance shaft sits to allow water caused by moisture build up to escape. drilling weeping hole was part of a tech bulletin issued by volvo. v8 engines for the xc90 produced in 2005 did not initially have this weeping hole in them. this design change was implemented part way through the production year (i believe post engine #6833). letter was written to the ceo of volvo cars of n.a. llc and representative from his office refused to provide any support, stating that the vehicle in question was out of warranty and that there were no recalls with regards to this issue. info provided to volvo from swedespeed.com (see odi id #10313311), however, this was rejected by volvo as a non-valid source of information (their own customers!). the repair job to replace the cb shaft and bearing was over 30 hours, not to mention the parts cost. what will it take volvo to admit there is a problem here and issue a recall to replace bearings and drill weeping holes in their 2005 xc90's with v8 engines? considering the cost they will incur, i'd suggest they will need to be pushed. the cost of engine repair is ($5,000) and engine replacement ($15,000+). all bearing failures outside of warranty are falling on the shoulders of the consumer. recalls are about safety not cost to the manufacture. just because this problem may only be linked to the 2005 v8 engines doesn't mean it is not important enough to be addressed for not only consumer financial protection but also for safety reasons. thankfully my engine didn't fail while my family was driving on a busy interstate! *tr.Mileage was 55504 miles. Vehicle Identification Number (VIN):YV1CZ852251. Volvo Xc90 2005 problem was reported in ROUND ROCK, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10325607 VOLVO XC90 2005 car safety problem was reported on Apr 14, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . my 2005 volvo xc90 with only 88000 miles is having transmission problems just this morning a message reads urgent transmission problem and i research and notice that many customers have had this same problem with the same vehicle model and year yet volvo has not done a recall on it. *tr.Mileage was 88000 miles. Volvo Xc90 2005 problem was reported in ORLANDO, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph. Volvo Xc90 2005 Latches/locks/linkagesVolvo Xc90 2005 Latches/locks/linkages Review #10330543 VOLVO XC90 2005 car safety problem was reported on Aug 01, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with LATCHES/LOCKS/LINKAGES . my 2005 volvo xc-90 does not automatically lock any of the vehicle doors when the car is put in drive and starts moving. this is a serious safety defect that i complained about to volvo, ford and nhtsa in 2005. ford motor company and volvo advertise the xc-90 as the safest vehicle on the road. ford and volvo have other cars before and after the xc-90's introduction that automatically locks the doors when the vehicle is put in drive and starts moving. ford motor company has had automatic door locks on many of their other vehicles for years so they trained us to expect it, and then they leave this feature off! i believe this design flaw has been in existence since the xc-90 was first introduction into the united states in 2004. this is unconscionable!!! *tr.Mileage was 0 miles. Vehicle Identification Number (VIN):YV1CY592651. Volvo Xc90 2005 problem was reported in HAMPTON COVE, AL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 5 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10330570 VOLVO XC90 2005 car safety problem was reported on May 15, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have a 2005 volvo xc90 t6. the transmission failed on the highway today,and i was nearly rear ended with two small children in the truck. the light came on now that said transmission service urgent. i complained to the volvo dealer 7 months ago. they did a software upgrade and said all was fine.volvo is well aware of this problem with many many 2005 xc 90 t6 vehicles. *tr.Mileage was 67680 miles. Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in MENASHA, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10333984 VOLVO XC90 2005 car safety problem was reported on May 27, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . my 2005 volvo xc90's transmission unexpectedly failed during acceleration while i was turning left across traffic causing a significant decrease in power which in turn required several cars to have to "slam" on their brakes to avoid hitting me. their "slamming" on the brakes caused the cars behind them to have to brake hard to avoid rear-ending them. after taking the suv to the dealership for diagnostic check and learning that our transmission needed to be replaced, i did a search on our car make and model and found that i was no where near the first person to experience a terrifying event like this due to volvo's transmission failures. i found page after page of accounts where peoples cars suddenly would not accelerate as usual due to transmission failure. this is a major safety issue that i think the ntsb needs to investigate due to volvo's refusal to either acknowledge or correct the problem. please don't wait until an entire family is hurt or killed before taking action. please do not repeat the toyota mistakes. *tr.0 person(s) were injured. 0 person(s) died.Volvo Xc90 2005 problem was reported in TOCCOA, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Power Train Manual TransmissionVolvo Xc90 2005 Power Train Manual Transmission Review #10341911 VOLVO XC90 2005 car safety problem was reported on July 07, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:MANUAL TRANSMISSION . transmission failure of volvo xc90 t6. known problem that the transmission in this car is bad. left stranded in the middle of an intersection and was almost rear-ended! "transmission service urgent" light came on and took to be checked out. was told couldn't find problem and replaced fluid. to no avail and was left stranded! i have found countless complaints online from others with this same issue!! *tr.Mileage was 64000 miles. Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in KATY, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10343465 VOLVO XC90 2005 car safety problem was reported on June 16, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . volvo xc90 2005 v8 - counter balance shaft failure leading to total engine failure and requiring engine replacement. *tr.Mileage was 48306 miles. Vehicle Identification Number (VIN):YV1TS97D0X1. Volvo Xc90 2005 problem was reported in BROOKFIELD, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10346533 VOLVO XC90 2005 car safety problem was reported on Mar 15, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . i have a 2005 volvo xc90 in which my low beam light just cuts out. it started about a year ago. it happens all of the time now. it has not been fixed yet. i was looking for possible information on this problem and learned that an investigation is underway now and that a recall may be issued. i just wanted to make you aware of another vehicle with the same problem. i also learned today that a friend with a volvo crosscountry wagon had the same problem until the cem was replaced. *tr.Mileage was 86000 miles. Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in RALEIGH, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10346640 VOLVO XC90 2005 car safety problem was reported on July 23, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . 2005 volvo xc90 t6, transmission failed after 64k miles. transmission failed at highway speeds nearly causing an accident as the vehicle slowed unexpectedly on i95 in heavy traffic. transmission failed after a program upgrade 3 weeks earlier. transmission was slipping and transmission service light appeared causing the vehicle to be towed to the dealer. dealer unable to find any fault codes but upgraded the software, "hoping this fixes it..." after complete failure, vehicle taken on flatbed to don beyer volvo who diagnosed failure as a "transmission failure" the dealership offered to replace transmission and several other parts at no cost. *tr .Mileage was 64000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in FORT BELVOIR, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Engine And Engine Cooling Cooling SystemVolvo Xc90 2005 Engine And Engine Cooling Cooling System Review #10346640 VOLVO XC90 2005 car safety problem was reported on July 23, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . 2005 volvo xc90 t6, transmission failed after 64k miles. transmission failed at highway speeds nearly causing an accident as the vehicle slowed unexpectedly on i95 in heavy traffic. transmission failed after a program upgrade 3 weeks earlier. transmission was slipping and transmission service light appeared causing the vehicle to be towed to the dealer. dealer unable to find any fault codes but upgraded the software, "hoping this fixes it..." after complete failure, vehicle taken on flatbed to don beyer volvo who diagnosed failure as a "transmission failure" the dealership offered to replace transmission and several other parts at no cost. *tr .Mileage was 64000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in FORT BELVOIR, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10349713 VOLVO XC90 2005 car safety problem was reported on Aug 05, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . 2005 volvo xc90 v8 turn signal does not work properly. sometimes need to flip the control bar for multiple times. fairly dangerous for changing lanes or turning to left or right. pushing the turn signal controller downward makes the signal work. problem is consistent. *tr.Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in AUSTIN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10350579 VOLVO XC90 2005 car safety problem was reported on Aug 17, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i bought a used volvo xc90, 2.5t model, manufactured in 2005. and yesterday i drove it for about 30 miles. volvo is famous for various safety features. however, i found that for many times the turn signal lever did not work well, which really scared me and almost caused crashes on highway 610 of houston. the symptom of malfunction is that sometimes when i move the turn signal lever, it either did not respond or showed a "lag". and sometimes the signal kept flashing left, even i gave left turn to the right. i reported this potential malfunction to you because i just read the news on http://wot.motortrend.com/6669043/recalls/nhtsa-investigates-2004-2005-volvo-xc90-for-faulty-lights-signals/index.html, which makes me believe that it is not only an individual case. hope you can have a thorough investigation, for the safety of all. thank you. *tr.Mileage was 62900 miles. Vehicle Identification Number (VIN):YV1CN592151. Volvo Xc90 2005 problem was reported in HOUSTON, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical System Review #10350864 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . this is a second report i submit. the other day i just reported malfunction of turn signal switch of my volvo xc90, 2.5t, 2005. i tested and observed the performance of the turn signal switch carefully and i think the potential severe design defect in the turn signal switch, or, maybe the electronic control module, will cause fatal incidents. its performance is totally unpredictable. it refused to respond at any time, either stopped or running. moreover, i found that sometimes a right movement of the lever gives a left signal, which is extremely dangerous. here i would like to strongly request that the investigation of volvo xc90 electronic system be conducted thoroughly. i would not be surprised at all to hear any fatal incident caused by the unpredictable malfunction. and i hope this could be part of a recall. interestingly, i observed that all the functions related to the switch lever either disappear altogether or works well altogether. this partially support that there is defect in the control module. i would like to help the investigation. i also have two witnesses who helped me to test drive my xc90. *tr.Mileage was 63000 miles. Vehicle Identification Number (VIN):YV1CN592151. Volvo Xc90 2005 problem was reported in HOUSTON, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10350864 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . this is a second report i submit. the other day i just reported malfunction of turn signal switch of my volvo xc90, 2.5t, 2005. i tested and observed the performance of the turn signal switch carefully and i think the potential severe design defect in the turn signal switch, or, maybe the electronic control module, will cause fatal incidents. its performance is totally unpredictable. it refused to respond at any time, either stopped or running. moreover, i found that sometimes a right movement of the lever gives a left signal, which is extremely dangerous. here i would like to strongly request that the investigation of volvo xc90 electronic system be conducted thoroughly. i would not be surprised at all to hear any fatal incident caused by the unpredictable malfunction. and i hope this could be part of a recall. interestingly, i observed that all the functions related to the switch lever either disappear altogether or works well altogether. this partially support that there is defect in the control module. i would like to help the investigation. i also have two witnesses who helped me to test drive my xc90. *tr.Mileage was 63000 miles. Vehicle Identification Number (VIN):YV1CN592151. Volvo Xc90 2005 problem was reported in HOUSTON, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 EquipmentVolvo Xc90 2005 Equipment Review #10352409 VOLVO XC90 2005 car safety problem was reported on Nov 23, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EQUIPMENT . counterbalance shaft bearings breakdown in nov 2009 and had repairs done at independent repair shop; august 2010 cylinder head leak/crack which brings oil to water coolant. repair shop advised to get rid of car 2005 xc 90 v8 volvo. i am fearful of driving this car. to repair and replace engine and new transmission too much $$$ for this volvo. with no guarantee. volvo needs to own up to the bad quality of this particular model. i feel it is dangerous to drive with so many cars on the road. it's an accident waiting to happen. *tr.Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in NORTH HOLLYWOOD, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10352409 VOLVO XC90 2005 car safety problem was reported on Nov 23, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . counterbalance shaft bearings breakdown in nov 2009 and had repairs done at independent repair shop; august 2010 cylinder head leak/crack which brings oil to water coolant. repair shop advised to get rid of car 2005 xc 90 v8 volvo. i am fearful of driving this car. to repair and replace engine and new transmission too much $$$ for this volvo. with no guarantee. volvo needs to own up to the bad quality of this particular model. i feel it is dangerous to drive with so many cars on the road. it's an accident waiting to happen. *tr.Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in NORTH HOLLYWOOD, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10355043 VOLVO XC90 2005 car safety problem was reported on Sept 03, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i own a 2005 volvo xc 90 model t6 with about 60,000 miles on it. recently, the car failed and i got the "urgent transmission service" warning. volvo initially wanted to charge me nearly $7000 to replace the transmission but finally agreed to cover the cost (minus a $160 "diagnosis plus my towing costs). after some internet research i saw that this has been a common problem in model year 2003-2005 t6 models; all catastrophic transmission failures with low mileage, in some cases multiple transmissions involved. see attached link: http://townhall-talk.edmunds.com/direct/view/.f18a651 talking to the service representative, they claimed it was because they used a gm transmission that was not able to handle the power of the engine (or perhaps the weight of the car). they installed a "remanufactured" transmission, they claim with "beefed up" clutch parts. there have been service bulletins since 2008 about leaks from the radiator contaminating the transmission fluid (leading to failures as well). it is my understanding that there have been hundreds of these failures. there is also a class action lawsuit underway as well. in my case, i was on a major highway, and it was a very dangerous situation. i don't understand why the government is not doing anything about this, as i was able to find a great deal of information after just a few simple internet searches. i would like to request an investigation, and if warranted, a recall and compensation (the used car value for this car have dropped because of the lack of reliability of the transmissions). i believe volvo is trying to deal with this on a case by case basis to cover it up and minimize their costs. *tr.Mileage was 63000 miles. Volvo Xc90 2005 problem was reported in SAN RAFAEL, CA. Accident was reported to Police. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10355742 VOLVO XC90 2005 car safety problem was reported on Sept 13, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . me and my wife just bought our first volvo 4 days ago!!! and my wife was on the high way with our 7 month old son when the transmission failed on her and they almost got into a car accident. thank god she was able to pull over on the side of the high way and call aaa and we had the car towed to the volvo dealer were we bought it from because they gave us a 3 month/ 3000 mile warranty. and now it's been 3 days and we have no car and the dealer is saying that they are trying to reprogram the transmission. i wish that i would have read some of these reviews on this model car. because they all seem to have transmission problems and they should have recalled that problem. what should we do? [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr.Mileage was 102201 miles. Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in ERIE, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10358883 VOLVO XC90 2005 car safety problem was reported on Dec 01, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . i have a 2005 volvo xc90 awd. my head lights have intermittent failures almost every time i am driving at night. it started about 10 months ago and has been getting more frequent. sometimes left head light fails, sometimes right head light fails, sometimes both go out. they will resume working, sometimes if i do nothing, but always if i turn them off & back on. but will continue to fail. the dealer said they cannot find any problem. *tr.Mileage was 41000 miles. Vehicle Identification Number (VIN):YV1CZ852251. Volvo Xc90 2005 problem was reported in RANCHO PALOS VERDES, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10358892 VOLVO XC90 2005 car safety problem was reported on Sept 28, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . 2005 volvo xc 90 t6 transmission failure and turn signal not operating. *tr.Mileage was 42000 miles. Vehicle Identification Number (VIN):YV1CZ911351. Volvo Xc90 2005 problem was reported in SAN CARLOS, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10358892 VOLVO XC90 2005 car safety problem was reported on Sept 28, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . 2005 volvo xc 90 t6 transmission failure and turn signal not operating. *tr.Mileage was 42000 miles. Vehicle Identification Number (VIN):YV1CZ911351. Volvo Xc90 2005 problem was reported in SAN CARLOS, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10360458 VOLVO XC90 2005 car safety problem was reported on Aug 14, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . vehicle has driver's side headlight failure. replaced bulb with certified volvo replacement and still did not work. certified volvo mechanic traced fuses and all electrical components (5 hours paid service) and found that a plastic part designed to keep water out of the interior (via windshield) was defective, therefore, causing water leakage to damage the central electrical module . *tr .Mileage was 106000 miles. Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in CLEVELAND, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10360458 VOLVO XC90 2005 car safety problem was reported on Aug 14, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . vehicle has driver's side headlight failure. replaced bulb with certified volvo replacement and still did not work. certified volvo mechanic traced fuses and all electrical components (5 hours paid service) and found that a plastic part designed to keep water out of the interior (via windshield) was defective, therefore, causing water leakage to damage the central electrical module . *tr .Mileage was 106000 miles. Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in CLEVELAND, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10362949 VOLVO XC90 2005 car safety problem was reported on Apr 10, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . i have a 2005 volvo xc90 t6. bought this car brand new. had so many problems including transmission out; the blinkers do not work. the quality and safety of this vehicle is misleading and this is a horrible safety issue since blinker don't work. looking into it, seems like this is an ongoing issue with many owner of volvo xc90 2005. they really need to recall this before it's too late and cause fatalities. *tr.Mileage was 90000 miles. Vehicle Identification Number (VIN):YV1CM911651. Volvo Xc90 2005 problem was reported in KILLEEN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10362949 VOLVO XC90 2005 car safety problem was reported on Apr 10, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i have a 2005 volvo xc90 t6. bought this car brand new. had so many problems including transmission out; the blinkers do not work. the quality and safety of this vehicle is misleading and this is a horrible safety issue since blinker don't work. looking into it, seems like this is an ongoing issue with many owner of volvo xc90 2005. they really need to recall this before it's too late and cause fatalities. *tr.Mileage was 90000 miles. Vehicle Identification Number (VIN):YV1CM911651. Volvo Xc90 2005 problem was reported in KILLEEN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10363533 VOLVO XC90 2005 car safety problem was reported on Nov 01, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . 60,000 miles on a 1995 volvo xc90 and the transmission just failed for the fourth time. the transmission was already replaced three times. failure results in car stopping without warning. anytime, anyplace, it just loses power. *tr.Mileage was 60000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in PALMDALE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10363820 VOLVO XC90 2005 car safety problem was reported on Oct 24, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . october 10, 2010 purchased cash 2005 xc90 v8. went through safety and emission service for registration-- okay. october 22 heard a strange noise from engine, called volvo dealership to request service. didn't drive on october 23, 2010. on sunday, october 24, went out to move the car for opposite side parking and to gas up for drive to service center. car stopped at service station, and had to be towed to dealership. dealership diagnostics october 25, 2010 confirmed: noise is from either broken connecting rod or balance shaft....advice to customer "needs engine" at a cost of $14,000+. the car did not come with a warranty and even now the dealer is becoming increasingly evasive--as he says he was the owner/dealer at the time of sale, and as individual seller registered in another state and not new york, so does not have to honor warranty or assume responsibility. call volvo north america on october 26, 2010 with no knowledge of our ownership, (still haven¿t received title to car). response was --no warranty no assistance with this counter balance or any other issue beyond 4 year/50,000 miles. concern: before purchase when asking the dealer no mention nor when researched no revelation of the counterbalance shaft being an ongoing issue for the 2005 xc90 v8. however, further evidence clearly shows design flaws in the original yamaha engines, and a slight covert attempt by volvo to fix it via its limited edition technical service bulletin(tsb) to drill the hole in the shaft to let build up moisture escape. additionally, volvo's second attempt to slightly address the counter balance issue is evidenced via its limited and pay-to-get tsb informing dealerships not consumers ¿of not washing the engine,¿ which may lead to moisture build up and total engine failure. our attempts are now being made for volvo to maintain its slogan of "safety for life." we want the safety attribute to be effective and useful when the car is operable, and not when the car is inoperable. *tr.Mileage was 85698 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in NEW YORK, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10368105 VOLVO XC90 2005 car safety problem was reported on Aug 28, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . tl*the contact owns a 2005 volvo xc90. the contact stated that while driving at various speeds, the driver side headlight would shut off intermittently. the vehicle was inspected by a dealer where the contact was informed that they would have to replace the cem unit. the vehicle had not been repaired. the failure mileage was approximately 70,000. .Mileage was 70000 miles. Vehicle Identification Number (VIN):YV1CZ592951. Volvo Xc90 2005 problem was reported in GREENVILLE, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10371228 VOLVO XC90 2005 car safety problem was reported on Dec 19, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i was driving with my daughter on a very long bridge at night in my 2005 volvo xc90. the check engine light came on and while the car stayed on, it appeared to have lost power. i have had other electrical problems with the car and have had it to the dealer 3 times but they say they can't find anything wrong with it. this was by far the most dangerous incident! after doing some internet research, i have read hundreds of reports similar to mine. there is a definite issue with this car and it should be recalled. *tr.Mileage was 100093 miles. Vehicle Identification Number (VIN):YV1CY592351. Volvo Xc90 2005 problem was reported in COVINGTON, LA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10375029 VOLVO XC90 2005 car safety problem was reported on Jan 06, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . balance shaft failure on 2005 volvo xc90 v8 with 115k miles. unbelievable that volvo will not issue a recall for this. balance shaft failed today at just under 115k miles... unbelievable... and i thought it was just an internet rumor. if you have a 2005 xc90, sell it now! seriously, this is unacceptable for a $50,000 vehicle, and even more unacceptable for volvo not to issue a recall. needless to say, i seriously doubt we will ever buy another volvo again simply because they should have issued a recall for this problem. should have stuck with the germans (audi or bmw), or dare i say it the japanese, or even the americans! i can replace a lot of wheel bearings on a yukon for what this balance shaft is going to cost me. volvo needs to make it right with every owner of a 2005 xc90. volvo knows of this problem and that is why they issued a tsb to drill a drain hole in the block, but they need to step up and issue a recall or, at the very least if an owner comes into the dealership with this problem, they need to fix it at no charge. it was their mistake, own up to it and fix it! *tr.Mileage was 115000 miles. Volvo Xc90 2005 problem was reported in WEST HENRIETTA, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10379327 VOLVO XC90 2005 car safety problem was reported on Jan 20, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . tl*the contact owns a 2005 volvo xc90. the contact stated that fuel was leaking from the fuel tank when he was driving 25 mph. the contact referenced recall 09v483000 (fuel system, gasoline: delivery: fuel pump) but was informed by the manufacturer that the vehicle was not included. the failure mileage was 64,000..Mileage was 64000 miles. Vehicle Identification Number (VIN):YV1CN592251. Volvo Xc90 2005 problem was reported in COLUMBIA, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Fuel System, OtherVolvo Xc90 2005 Fuel System, Other Review #10379781 VOLVO XC90 2005 car safety problem was reported on Jan 18, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, OTHER . 2005 xc90 v8-many problems with check engine light coming on and car losing power. lost power on interstate-car would lose power and speed-needed tow-happened twice. current issue check engine light came on followed by all lights coming on stating brake failure, power overload, limp mode and brake failure. dealer replaced alternator at cost of $1006. 10 days later check engine light and anti skid light came on followed by brake failure light. car lost headlights and windshield wipers-9 pm and sleeting. dealer now says need to replace cem and battery at a cost of $3,000 due to water in cem. it was raining or sleeting both times the check engine light came on. volvo redesigned the cover to prevent water intrusion but needs to issue recall. very dangerous- ticking time bomb. someone will have an accident on rainy night on interstate. please consider requiring recall-owners of this vehicle are spending thousands of dollars due to volvo xc90 v8 design flaws. how can volvo be allowed to sell vehicles that should not be driven outside/or in the rain. *tr.Mileage was 131000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10379781 VOLVO XC90 2005 car safety problem was reported on Jan 18, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . 2005 xc90 v8-many problems with check engine light coming on and car losing power. lost power on interstate-car would lose power and speed-needed tow-happened twice. current issue check engine light came on followed by all lights coming on stating brake failure, power overload, limp mode and brake failure. dealer replaced alternator at cost of $1006. 10 days later check engine light and anti skid light came on followed by brake failure light. car lost headlights and windshield wipers-9 pm and sleeting. dealer now says need to replace cem and battery at a cost of $3,000 due to water in cem. it was raining or sleeting both times the check engine light came on. volvo redesigned the cover to prevent water intrusion but needs to issue recall. very dangerous- ticking time bomb. someone will have an accident on rainy night on interstate. please consider requiring recall-owners of this vehicle are spending thousands of dollars due to volvo xc90 v8 design flaws. how can volvo be allowed to sell vehicles that should not be driven outside/or in the rain. *tr.Mileage was 131000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10379781 VOLVO XC90 2005 car safety problem was reported on Jan 18, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . 2005 xc90 v8-many problems with check engine light coming on and car losing power. lost power on interstate-car would lose power and speed-needed tow-happened twice. current issue check engine light came on followed by all lights coming on stating brake failure, power overload, limp mode and brake failure. dealer replaced alternator at cost of $1006. 10 days later check engine light and anti skid light came on followed by brake failure light. car lost headlights and windshield wipers-9 pm and sleeting. dealer now says need to replace cem and battery at a cost of $3,000 due to water in cem. it was raining or sleeting both times the check engine light came on. volvo redesigned the cover to prevent water intrusion but needs to issue recall. very dangerous- ticking time bomb. someone will have an accident on rainy night on interstate. please consider requiring recall-owners of this vehicle are spending thousands of dollars due to volvo xc90 v8 design flaws. how can volvo be allowed to sell vehicles that should not be driven outside/or in the rain. *tr.Mileage was 131000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10380677 VOLVO XC90 2005 car safety problem was reported on Dec 15, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . counterbalance shaft bearing failure at 113,000 miles luckily failure happened on the way to the repair shop. if this would have taken place on the highway my wife and kids could have been seriously injured. volvo knows this is an issue or would not have released a technical service bulletin on ways to remedy the problem by drilling weep holes in the block to shed moisture. the trapped moisture causes the bearing to rust and finally fail causing catastrophic engine failure. volvo has offered a mere $3,000.00 to correct a $15,000.00 problem. i have read numerous testimonies from other 2005 xc-90 owners with engine failure always from the failed counterbalance shaft bearing. how do we force volvo to issue a recall before someone gets seriously injured..0 person(s) were injured. 0 person(s) died.Mileage was 113000 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in ST. SIMONS ISLAND, GA. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Engine And Engine Cooling Cooling SystemVolvo Xc90 2005 Engine And Engine Cooling Cooling System Review #10383297 VOLVO XC90 2005 car safety problem was reported on Jan 06, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . 2005 volvo xc90 counter balance shaft broke and seized engine. only 68,000 miles and a well maintained vehicle! volvo refuses to take any responsibility for this poorly designed system. quoted $16,850 plus tax for remanufactured unit. incidentally, just this past sept also had to replace oil cooler, thermostat and expansion tank when the vehicle broke down as were driving through virginia. this is another well documented issue with this vehicle! *ln.Mileage was 68000 miles. Vehicle Identification Number (VIN):YV1CZ852151. Volvo Xc90 2005 problem was reported in CRANFORD, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10383884 VOLVO XC90 2005 car safety problem was reported on Feb 19, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . while driving on the highway in rain, the headlights of the car began flashing on and off (sometimes drivers side, sometimes passenger side, sometimes both) intermittently. i pulled over and turned off and restarted car. this solved the problem for a few miles, then it did it again. now, the right light is out completely, but at least the left seems to be staying on. this exact same thing happened one other time. the dealership claimed they could find nothing wrong with the vehicle. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 61000 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in DENVER, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10383884 VOLVO XC90 2005 car safety problem was reported on Feb 19, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . while driving on the highway in rain, the headlights of the car began flashing on and off (sometimes drivers side, sometimes passenger side, sometimes both) intermittently. i pulled over and turned off and restarted car. this solved the problem for a few miles, then it did it again. now, the right light is out completely, but at least the left seems to be staying on. this exact same thing happened one other time. the dealership claimed they could find nothing wrong with the vehicle. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 61000 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in DENVER, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10386045 VOLVO XC90 2005 car safety problem was reported on Nov 23, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl* the contact owns a 2005 volvo xc90. while driving approximately 30 mph, the contact began to hear a knocking noise coming from the engine. the vehicle was taken to an authorized dealer where the contact was told that the bearing and cam shafts would need to be replaced. the vehicle was repaired. the failure mileage was 126,000 and the current mileage was 128,000. .Mileage was 126000 miles. Vehicle Identification Number (VIN):YV1CZ852951. Volvo Xc90 2005 problem was reported in SCHENECTADY, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10392462 VOLVO XC90 2005 car safety problem was reported on Mar 13, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i purchased a 2005 xc90 v8 awd with 65000, after a month or so i noticed hard shifting, yesterday we took a trip up the mountain and i actually lost my transmission for a min, it slipped out of place while passing a vehichle, rpm shot up to 5-6k, it kicked back in again once we slowed and we pulled to the side to make sure it would stay in gear before going again. now it has gone back to hard shifting occasionally. i feel very unsafe and found lots of reports of similar incidents. contacting volvo has not been helpful at all they want 7k for a new crappy built transmission. new veh 45k and new transmission every 50k mi, what a deal this car is. i dont want to wait till me or my family is hurt or killed to report it. .Mileage was 72000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in PHOENIX, AZ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10392720 VOLVO XC90 2005 car safety problem was reported on Mar 16, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . tl* the contact owns a 2005 volvo xc90. while driving approximately 40 mph in rainy weather, the driver attempted to turn on the windshield wipers but they would not engage. the vehicle was taken to an authorized dealer where the contact was told that the central electronic module would need to be replaced because rain was seeping into the central electronic module. the vehicle was repaired. updated 05/05/11*lj updated 05/13/11.Mileage was 49700 miles. Vehicle Identification Number (VIN):YV1CZ592851. Volvo Xc90 2005 problem was reported in ARLINGTON, VA. Vehicle was purchased on Feb 01, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 40 mph. DEALER'S NAME: DON BEYER VOLVO . DEALER'S TELEPHONE NUMBER: 703-768-5800 . DEALER'S CITY: ALEXANDRIA . DEALER'S STATE CODE: VA. DEALER'S ZIPCODE: 22306 . Volvo Xc90 2005 Visibility Windshield Wiper/washerVolvo Xc90 2005 Visibility Windshield Wiper/washer Review #10392720 VOLVO XC90 2005 car safety problem was reported on Mar 16, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with VISIBILITY:WINDSHIELD WIPER/WASHER . tl* the contact owns a 2005 volvo xc90. while driving approximately 40 mph in rainy weather, the driver attempted to turn on the windshield wipers but they would not engage. the vehicle was taken to an authorized dealer where the contact was told that the central electronic module would need to be replaced because rain was seeping into the central electronic module. the vehicle was repaired. updated 05/05/11*lj updated 05/13/11.Mileage was 49700 miles. Vehicle Identification Number (VIN):YV1CZ592851. Volvo Xc90 2005 problem was reported in ARLINGTON, VA. Vehicle was purchased on Feb 01, 2005. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. FUEL SYSTEM:Turbo. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 40 mph. DEALER'S NAME: DON BEYER VOLVO . DEALER'S TELEPHONE NUMBER: 703-768-5800 . DEALER'S CITY: ALEXANDRIA . DEALER'S STATE CODE: VA. DEALER'S ZIPCODE: 22306 . Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10392958 VOLVO XC90 2005 car safety problem was reported on June 06, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . safety complaint - sudden vehicle disabled ? 2005 volvo xc90 v8 ? june 2010 130000 miles. wife was driving busy urban road and vehicle suddenly stopped without warning in the middle of the intersection. vehicle had to be pushed from middle of intersection. counterbalance shaft bearing failure. the timing chain had broken and the engine had a catastrophic failure. repay was $10,000 with a used 60,000 mile engine installed. volvo would not cover any cost even though a product bulletin was put out. vehicle always serviced by dealer and no mention ever made of potential for failure or the bulletin. *tr.Mileage was 130000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in MOORESVILLE, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 48 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10392960 VOLVO XC90 2005 car safety problem was reported on Feb 02, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . safety complaint ¿second occurrence same vehicle - sudden vehicle disabled ¿ 2005 volvo xc90 v8 ¿ february 2011 153,000 miles. daughter with learner permit driving down busy urban road and vehicle suddenly stopped without warning in the right of way. vehicle had to be pushed to side of road second counterbalance shaft bearing failure. this failure occurred on the replaced engine from the prior occurrence ¿ see complaint number 10392958. this engine had 77,000 miles at time of failure. the timing chain had not broken and the balancer shaft, idler gear could be replaced and engine repaired after the engine had to be removed - $3,000 repair. volvo would not cover any cost even though a product bulletin was put out. vehicle always serviced by volvo dealer and no mention ever made of potential for failure or the bulletin. research now indicates this to be a common problem for this model year configuration. we have purchased another brand due to safety concern, failure to provide service by the dealer and failure of volvo to acknowledge any responsibility. the % of 2005 volvo xc 90 v8 vehicles with this safety issue and engine failure rate needs to be analyzed. please review and initiate an investigation. *tr.Mileage was 152000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in MOORESVILLE, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10394215 VOLVO XC90 2005 car safety problem was reported on Feb 24, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . out of the blue a well-maintained and well cared for 2005 volvo xc90 v8 suv developed a severe engine knocking/banging sound (all service records completed at required time periods). actually sounded like ball bearings rolling around inside the engine compartment. 58,000 miles on the vehicle. engine was shut down immediately and vehicle flatbedded to the service dealer. upon inspection, the counterbalance bearing and shaft failed. if engine had not been shut down there was a very real possibility of the bearing seizing and the shaft hits the inside of the engine block breaking the timing chain bending all the valves(i.e. catastrophic engine failure)! as the manufacturer, volvo should bear the full monetary responsibility when it come to this repair. a serious design flaw in their engine is the cause of this failure. the service tech must tear you engine apart (literally remove the engine from the vehicle and open the engine block!) to properly complete the repair. volvo should be picking up the entire cost of this fiasco. parts and labor. period. to date volvo making owners pay for the replacement parts. the parts are between $1200-2000. it is not the correct way for a so-called ¿quality automobile manufacturer¿ to handle the situation. when customers pay $45000-$55,000 for an automobile, they expect the car (and the engine!) to last a wee longer than 55,000-75,000 miles (sarcasm intended). frankly, this will be my last volvo. *tr.Mileage was 58070 miles. Vehicle Identification Number (VIN):YV1CZ852951. Volvo Xc90 2005 problem was reported in CANTON, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10398189 VOLVO XC90 2005 car safety problem was reported on Apr 27, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . i have an 2005 volvo xc90 with only 53,000 miles and the transmission has already gone out leaving my family stranded on the side of the freeway. *tr.Mileage was 53000 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in ALISO VIEJO, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10398294 VOLVO XC90 2005 car safety problem was reported on Apr 20, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . tl* the contact owns a 2005 volvo xc90. while driving approximately 70 mph, the vehicle began to jerk excessively with a substantial loss of engine power. the contact was able to maneuver to the side of the road as the engine stalled. in addition, the contact noticed a strong odor of fuel both inside and outside of the vehicle. the vehicle was towed to an independent mechanic where the fuel pump was replaced. the similar failure recurred and the fuel pump was replaced three different times. there was a recall associated with nhtsa campaign id number: 09v483000 (fuel system, gasoline:delivery:fuel pump). the contact experienced the identical failure as mentioned in the recall yet the vin was not included in the recall. the failure mileage was 50,000. the vin was unavailable. .Mileage was 50000 miles. Volvo Xc90 2005 problem was reported in HARTSVILLE, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 70 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10400706 VOLVO XC90 2005 car safety problem was reported on Oct 30, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . 2005 volvo xc90 v8 awd-numerous electrical issues since purchasing vehicle from a local dealer in upstate ny in 2010. odd problems such as headlights failing, power windows opening and "anti" theft features (key lock) being activated for unknown reason-the vehicle required a balance shaft replacement at about 70k miles (i believe it had 65k miles when i purchased it) which apparently was due to manufacturer not having drip holes in engine compartment. i believe the electrical issues are somewhat related to that problem in that water seems to be a problem for this vehicle. the odd electrical issues don't always happen when its raining but moisture appears to be a factor. latest issue was a locked shifter in the park position-car would start but could not put into any gear-towed to dealer and they replaced the cem (central electronics module) for $2300.00. i made them give me the defective module so have it if you would like to examine it examine it. luckily, i only had one dangerous issue and that is when the headlights failed during a dark/rainy night. too early to tell if the cem fixes the problem as just had it fixed today 5/13/2011. started researching why this would be an issue and that's when i started reading other volvo drivers experiences that seemed quite similar to mine. i never had complete vehicle failure but losing the headlights was not fun...i think volvo knows exactly what the issue as they didn't hesitate in installing the cem...i am listing the specific date that the headlights failed below-they failed several other times but cant recall the specific dates. *tr.Mileage was 70000 miles. Vehicle Identification Number (VIN):YV1CZ852251. Volvo Xc90 2005 problem was reported in EAST AMHERST, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10400868 VOLVO XC90 2005 car safety problem was reported on Aug 10, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . 2005 xc90 v8. power reduction, engine noise, engine failure due to defective rear counter balance shaft bearing. failure at 35,000 miles on engine, 4 yr old, dealer serviced. long block replaced while under extended 7-yr warranty. by dealer. total repair cost (w/o warranty) would have been $15,000. *tr.Mileage was 35000 miles. Vehicle Identification Number (VIN):YV1CZ852051. Volvo Xc90 2005 problem was reported in CA, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10402177 VOLVO XC90 2005 car safety problem was reported on Jan 12, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl*the contact owns a 2005 volvo xc90. the contact stated while driving 30 mph the vehicle shut off without warning. the contact had the vehicle towed to a local mechanic. the mechanic notice the timing chain broke causing the engine to lock up. the mechanic stated the engine needs to replaced. the mechanic replaced the engine. the contact notice numerous complaint regarding engine malfunctions for this year make and model. the contact called the manufacturer and the manufacturer stated since the vehicle has not been serviced at a dealer they are not responsible for the repairs. the contact stated if the vehicle was on the highway and the engine failed a crash could have occurred. the failure mileage was 75,000. .0 person(s) were injured. 0 person(s) died.Mileage was 75000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in NEWBURY PORT, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Service Brakes, HydraulicVolvo Xc90 2005 Service Brakes, Hydraulic Review #10403529 VOLVO XC90 2005 car safety problem was reported on June 11, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with SERVICE BRAKES, HYDRAULIC . a national distributor of replacement automobile parts provided the incorrect size front brake rotors for a 2005 volvo xc-90. a owens cross road, al auto repair shop that installed these front brake rotors blamed the national distributor¿s catalog error for smaller (approximately 0.50 inch) front brake rotors which are sold as an exact replacement for the original volvo rotors. the front brake pads actually exceeded the front rotors outer diameter and should have been obvious to any responsible auto mechanic. the national distributors catalog error is recklessly endangering people all over the united states. the name of the national distributor is unknown but certainly could be obtained from the owens cross road auto repair service. the national distributor should be fined and required to notify every auto repair shop which they have supplied with the incorrect size front rotors. .0 person(s) were injured. 0 person(s) died.Mileage was 106550 miles. Vehicle Identification Number (VIN):YV1CY592651. Volvo Xc90 2005 problem was reported in OWENS CROSS ROAD, AL. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10404373 VOLVO XC90 2005 car safety problem was reported on June 03, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . i have a 2005 volvo xc90 v8 the car has been developing a shake, i brought it to volvo for a check up, nothing was reported as unusual. yesterday i heard knocking in the engine and immediately flatbedded it to the dealership, the went to diagnose and the engine has froze. the dealer is researching and explained it is out of warranty with a new engine costing $14,000.00, reading other bulletins i suspect this is a counterbalance shaft bearing failure and is occurring with all 2005 v8 xc90's as they increase in age and exit any warranty period. i hope someone can do something, a new engine cost as much as it's trade-in value. such a know issue should be investigated with volvo picking up the cost. *tr.Mileage was 85000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in OVIEDO, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10405718 VOLVO XC90 2005 car safety problem was reported on Aug 01, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . 1. normal city/highway driving. 2. turn signals sporadically do not function. ambient temperature does not matter, whether in winter or summer. 3. nothing was done to correct. *tr.Mileage was 42000 miles. Vehicle Identification Number (VIN):YV1CM592X51. Volvo Xc90 2005 problem was reported in DEARBORN, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10405718 VOLVO XC90 2005 car safety problem was reported on Aug 01, 2009.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . 1. normal city/highway driving. 2. turn signals sporadically do not function. ambient temperature does not matter, whether in winter or summer. 3. nothing was done to correct. *tr.Mileage was 42000 miles. Vehicle Identification Number (VIN):YV1CM592X51. Volvo Xc90 2005 problem was reported in DEARBORN, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10405733 VOLVO XC90 2005 car safety problem was reported on June 01, 2005.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . during rain the windshield wipers stop working, headlights go out and car loses power. i have come dangerously close to high speed accidents due to the loss of power. also car has a severe jerk in the transmission when accelerating after a turn. so strong i thought i was hit from behind. there is a problem nhtsa investigated with water getting into the cem. volvo acknowledged manufacturer defect that results in water getting in cem but will not replace the defective cover. there is no way of knowing when this might happens-appears to depend on how heavy the rain, if roadway has a lot of water. this needs to be recalled for safety reasons-volvo continues to put consumers at risk. *tr .Mileage was 130000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10407737 VOLVO XC90 2005 car safety problem was reported on May 20, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . transmission complete failure at 92,000 miles. appears to be a material manufacturing defect. volvo tech spec describes defective part, yet volvo dealership requiring complete replacement of transmission. *tr.Mileage was 92000 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in FORT MITCHELL, KY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 15 mph. Volvo Xc90 2005 Power Train Automatic Transmission Review #10408783 VOLVO XC90 2005 car safety problem was reported on June 13, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . transmission problem on 2005 xc90 t6. slipping and shifting problems. found metal chunks in transmission oil pan. reported to volvo na for "goodwill" repair or replacement. denied because vehicle has over 100k miles. vehicle is only used on weekends an long trips. not being driven hard. volvo not living up to expectations or reputation. *tr.Mileage was 124000 miles. Volvo Xc90 2005 problem was reported in VALLEJO, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Visibility Sun Roof AssemblyVolvo Xc90 2005 Visibility Sun Roof Assembly Review #10411735 VOLVO XC90 2005 car safety problem was reported on July 09, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with VISIBILITY:SUN ROOF ASSEMBLY . driving at highway sped in 2005 volvo xc 90 when sunroof glass exploded. glass repair facility said there was likely a flaw in the glass. volvo says not likely. if i had had the shade open all that glass would have fallen onto me/passengers and into eyes. shattered into a thousand little pieces. could have caused a accident and/or personal injury. *tt.Mileage was 110000 miles. Vehicle Identification Number (VIN):YV1CZ592551. Volvo Xc90 2005 problem was reported in LINCOLN, NE. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10414917 VOLVO XC90 2005 car safety problem was reported on May 03, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . 1. heard marble noises underhood after 56,000 miles of normal driving. well maintained. 2. balance shaft bearing broke apart and put out metal shards between cylinder heads. loud metallic noise from engine. vehicle was shut down immediately after pulling over to avoid engine destruction and traffic accident due to halted vehicle. had to be towed. 3. balance shaft bearing is being replaced. old part (in pieces) available for analysis. *tr.Mileage was 56201 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in ANN ARBOR, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 10 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10415470 VOLVO XC90 2005 car safety problem was reported on July 08, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . 1.july 8, 2011. 2005 volvo xc90 balance shaft broke off within car engine. heard a loud sound coming from car engine, and lost a great deal of power while driving on highway. 2.further damage to the vehicle engine could have been done due to accelerating to get of the highway in order to avoid a collision from vehicles coming from behind. this was a scary life and dangerous experience. 3.volvo having explained what created the problem to date. the engine will have to be pulled out and almost re-built at a cost to almost $8500.00 extended warranty i paid $4,100 for is not covering full cost. i am responsible for over $2000 + cost of car rentals to date. july 28, 2011, car is still with volvo. *tr.Mileage was 64780 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in BRENTWOOD, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10417710 VOLVO XC90 2005 car safety problem was reported on July 25, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . brakes lights always on. took car to dealer and they advised that water had leaked into cem module and main wireharness and required replacemnet at a cost of $7000. known issue to volvo with service bulletin sent to dealers. found independent volvo repair shop willing to replace module only (software download from dealer) and clean build-up on harness connectors. requiring removal of part of dash, driver seat. took 4 days at repair shop. repair completed for under $2000. *tt.Mileage was 130000 miles. Volvo Xc90 2005 problem was reported in ARCADIA, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10418848 VOLVO XC90 2005 car safety problem was reported on July 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . i'd like to add my complaint to the list of those already reporting the abrupt loss of all electronics, including windshield wipers and all dashboard gauges, during a rainstorm. my issue was also identified as a prematurely corroded central electronic module (cem) caused by a design flaw allowing water to access the cem connector. i'm shocked to find out volvo knew about this in 2005, well within the warranty period for most of these affected vehicles, and did nothing to correct or even alert their owners. i urge the nhtsa to revisit their investigation, and force a recall if volvo continues to refuse. i can assure you as a driver during this event, this is indeed a safety issue, and i hope we aren't waiting for enough injuries or deaths before you get to that obvious conclusion..0 person(s) were injured. 0 person(s) died.Mileage was 93834 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in CHAMPLIN, MN. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10418848 VOLVO XC90 2005 car safety problem was reported on July 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i'd like to add my complaint to the list of those already reporting the abrupt loss of all electronics, including windshield wipers and all dashboard gauges, during a rainstorm. my issue was also identified as a prematurely corroded central electronic module (cem) caused by a design flaw allowing water to access the cem connector. i'm shocked to find out volvo knew about this in 2005, well within the warranty period for most of these affected vehicles, and did nothing to correct or even alert their owners. i urge the nhtsa to revisit their investigation, and force a recall if volvo continues to refuse. i can assure you as a driver during this event, this is indeed a safety issue, and i hope we aren't waiting for enough injuries or deaths before you get to that obvious conclusion..0 person(s) were injured. 0 person(s) died.Mileage was 93834 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in CHAMPLIN, MN. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Power Train Automatic TransmissionVolvo Xc90 2005 Power Train Automatic Transmission Review #10419178 VOLVO XC90 2005 car safety problem was reported on Aug 12, 2006.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . tl* the contact owns a 2005 volvo xc90. while driving approximately 65 mph, the vehicle stalled without warning. the vehicle was towed to the dealer where the technicians stated that the transmission had to be replaced. after the replacement, the failure recurred approximately 40,000 miles after the transmission was replaced. the vehicle was not further repaired. the vin was not available. the approximate failure mileage was 60,000. .Mileage was 60000 miles. Volvo Xc90 2005 problem was reported in BROOKFIELD, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10419955 VOLVO XC90 2005 car safety problem was reported on July 17, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . purchased used 2005 volvo xc90 in spring of 2010. during the next year experienced very intermittent electrical issues. examples are locks not working, blinker, radio. these issues literally only happened a couple times. in april 2011 had biyearly safety and emissions done at local dealership (non volvo) and it did not pass emissions. next day took my volvo xc90 to weiss volvo and it passed emissions (without me knowing they cleared errors on the car to get it to pass. this must be the reason in europe that dealerships can't inspect their own make of cars) on july 17 2011 i was driving down the highway with my 1 year old in the back seat. radio went out. a few minutes later almost everything in the car shut down except for the engine. lost a/c (it was 110 that day), lost power steering, braking was intermittent, no blinkers, no headlights, no lights in interior, while i was at full speed on the highway. i am not sure if engine was intermittent or not because i got off as soon as i could. i was very close to weiss volvo so dropped it off there again on the date of the total failure. called volvo customer care on july 18 2011 to file complaint. weiss volvo called back and told us car wouldn't start. called back later in the day and said they saw that everything went out and car was full of codes. weiss sent in an estimate for $1500 to replace ecm. i asked weiss to perform an emissions test (by mo law manufacturer's cars must pass emissions test up to 80k miles and my car had 61k) i researched ecm and found very similar stories to mine and brought this up to volvo na. volvo na told weiss volvo to "reset" my car (again without my permission). the car then was functional after reset. weiss then "tested" my car for almost 3 weeks to figure out the design flaw for a total of 451 miles. the mechanic told me it was the ecm but volvo na said it was various other reasons and wouldn't replace it. car still broke. reached limit. *kb.Mileage was 60800 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in KIRKWOOD, MO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Engine And Engine Cooling EngineVolvo Xc90 2005 Engine And Engine Cooling Engine Review #10419955 VOLVO XC90 2005 car safety problem was reported on July 17, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING:ENGINE . purchased used 2005 volvo xc90 in spring of 2010. during the next year experienced very intermittent electrical issues. examples are locks not working, blinker, radio. these issues literally only happened a couple times. in april 2011 had biyearly safety and emissions done at local dealership (non volvo) and it did not pass emissions. next day took my volvo xc90 to weiss volvo and it passed emissions (without me knowing they cleared errors on the car to get it to pass. this must be the reason in europe that dealerships can't inspect their own make of cars) on july 17 2011 i was driving down the highway with my 1 year old in the back seat. radio went out. a few minutes later almost everything in the car shut down except for the engine. lost a/c (it was 110 that day), lost power steering, braking was intermittent, no blinkers, no headlights, no lights in interior, while i was at full speed on the highway. i am not sure if engine was intermittent or not because i got off as soon as i could. i was very close to weiss volvo so dropped it off there again on the date of the total failure. called volvo customer care on july 18 2011 to file complaint. weiss volvo called back and told us car wouldn't start. called back later in the day and said they saw that everything went out and car was full of codes. weiss sent in an estimate for $1500 to replace ecm. i asked weiss to perform an emissions test (by mo law manufacturer's cars must pass emissions test up to 80k miles and my car had 61k) i researched ecm and found very similar stories to mine and brought this up to volvo na. volvo na told weiss volvo to "reset" my car (again without my permission). the car then was functional after reset. weiss then "tested" my car for almost 3 weeks to figure out the design flaw for a total of 451 miles. the mechanic told me it was the ecm but volvo na said it was various other reasons and wouldn't replace it. car still broke. reached limit. *kb.Mileage was 60800 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in KIRKWOOD, MO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10420879 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . volvo xc90 2005 low beam bulb failure error and one beam turns off. then comes back on, and sometimes all lights go off. very dangerous at night. if you turn the headlight dial to another setting they will come back on, but then blink off again, and sometimes off completely. the biggest issue is the intermittent occurrence of this. the car is not safe to drive. *tr.Mileage was 75000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in CENTERTON, AR. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10420879 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . volvo xc90 2005 low beam bulb failure error and one beam turns off. then comes back on, and sometimes all lights go off. very dangerous at night. if you turn the headlight dial to another setting they will come back on, but then blink off again, and sometimes off completely. the biggest issue is the intermittent occurrence of this. the car is not safe to drive. *tr.Mileage was 75000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in CENTERTON, AR. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Exterior Lighting Turn SignalVolvo Xc90 2005 Exterior Lighting Turn Signal Review #10421666 VOLVO XC90 2005 car safety problem was reported on Aug 03, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING:TURN SIGNAL . volvo xc90 2005, turning signal acts dangerously. sometimes it works but most time no action happens. completely dead and restarting car sometimes fix the problem. multiple cases of dangerous incidents due to no signal. *tt.Mileage was 85000 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in AUSTIN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10423007 VOLVO XC90 2005 car safety problem was reported on Aug 30, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . a complaint was previous filed regarding to turn signal problem. situation getting worse. volvo xc90 v8 2005; replaced cem unit two years back. recently following problems happened. 1. turn signal stop working 2. no high beam 3. no windshield washing 4. no cruise control 5. no vehicle information function problems look like associated with faulty cem again. vehicle is very risky to drive with unreliable or not-functioning turn signal. *tr.Mileage was 90000 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in AUSTIN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10423007 VOLVO XC90 2005 car safety problem was reported on Aug 30, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with EXTERIOR LIGHTING . a complaint was previous filed regarding to turn signal problem. situation getting worse. volvo xc90 v8 2005; replaced cem unit two years back. recently following problems happened. 1. turn signal stop working 2. no high beam 3. no windshield washing 4. no cruise control 5. no vehicle information function problems look like associated with faulty cem again. vehicle is very risky to drive with unreliable or not-functioning turn signal. *tr.Mileage was 90000 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in AUSTIN, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10425724 VOLVO XC90 2005 car safety problem was reported on Sept 04, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . heard loud ticking noise coming from engine at 86330k miles. vehicle ride became somewhat rough. diagnosed at volvo dealership as balance shaft bearing "part failure". est. to fix: ~$3800. volvo agreed to compensate for the parts, approx $1500. balance of $2325.50 paid by vehicle owner. took 1 week for volvo to obtain parts as they are not commonly stocked or were back ordered. on line research revealed this to have been a problem with early 2005 xc90 v8's. water/condensation/vapor is able to get in and rust the bearing leading to engine failure. a tsb was issued (? when) for a fix to drill a "weeping hole" in engine block to drain water from the bearing. *tt.Mileage was 86330 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in FOXBORO, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10434122 VOLVO XC90 2005 car safety problem was reported on Aug 21, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl* the contact owns a 2005 volvo xc90. while driving approximately 25 mph, the contact heard a loud noise emitting from the front end of the vehicle. immediately there was a slight loss of engine power during acceleration. the malfunction progressed and the vehicle was towed to an authorized dealer who stated the engine would need to be replaced as a result to the engine balance shaft fracturing. the vehicle had not been repaired. the manufacturer was made aware of the problem. the approximate failure mileage was 60,000. .Mileage was 60000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in SEASIDE PARK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10438548 VOLVO XC90 2005 car safety problem was reported on Nov 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . the balancer bearing and shaft on the 2005 volvo xc90 suv is defective in the first 6000 vehicles manufactured for that model year. the balancer shaft bearing can go bad at any time without warning, causing catastrophic engine damage. if this happens on a highway while traveling at a high rate of speed, the results could be deadly. volvo north america is aware of this and does nothing to address this serious, potentially deadly situation. we have been working to get volvo of north america to recognize this issue and they have doing nothing to date except point to maintenance, which has no impact on the problem. there is no maintenance procedure to insure this does not happen and volvo will not pay for damages. the remedy in most cases is an engine replacement which costs about $15,000 , and as mentioned, volvo will not pay for it. volvo must be forced to recall these vehicles and fix the problem and compensate owners who have been impacted. these vehicles must be recalled and the problem must be fixed before countless lives are put at risk by this ticking time bomb that will go off. at 70 miles an hour , a failed engine could lead to death. there are 6000 volvo xc90's with this problem. *tr the dealer diagnosed the problem as a complete engine failure due to the balancer becoming damaged and causing catastrophic engine failure. the consumer was informed it would cost $ 14,700 to replace the engine. updated ivoq 03/09/12.Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in ORTLEY BEACH, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. DEALER'S NAME: DEB LENTZ VOLVO . Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive)Volvo Xc90 2005 Power Train Transfer Case (4-wheel Drive) Review #10438789 VOLVO XC90 2005 car safety problem was reported on Dec 21, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . tl* the contact owns a 2005 volvo xc90. while stopped at a traffic stop, the vehicle began to shake back and forth uncontrollably. the contact applied pressure to the brake pedal in order for the vehicle to stop shaking. the vehicle was taken to the dealer for diagnostic testing where the technician advised that the four wheel drive motor was not engaging and would have to be replaced. the four wheel drive warning light was not indicating that there was a failure. the vehicle was not repaired. the approximate failure mileage was 39,000. .Mileage was 39000 miles. Vehicle Identification Number (VIN):YV1CM592951. Volvo Xc90 2005 problem was reported in ANCHORAGE, AK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10439784 VOLVO XC90 2005 car safety problem was reported on Dec 08, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . counter balance shaft failure leading to complete engine failure. defective design. *tr.Mileage was 70422 miles. Vehicle Identification Number (VIN):YV1CZ852051. Volvo Xc90 2005 problem was reported in DALLAS, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10441365 VOLVO XC90 2005 car safety problem was reported on Oct 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl* the contact owns a 2005 volvo xc90. the contact stated that the vehicle stalled while driving at various speeds. the first occurrence occurred while driving approximately 55 mph. the contact was able to successfully restart the vehicle after the failures occurred. the vehicle was not taken to have the failure diagnosed or repaired. the manufacturer was not made aware of the failure. the failure mileage was 110,000. .Mileage was 110000 miles. Vehicle Identification Number (VIN):YV1CY592751. Volvo Xc90 2005 problem was reported in LEXINGTON, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10442570 VOLVO XC90 2005 car safety problem was reported on Jan 05, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . sludge build up in the engine even after scheduled oil changes. was told the engine/turbo would have to be placed after 100,000 miles. *tr.Vehicle Identification Number (VIN):YV1CY592X51. Volvo Xc90 2005 problem was reported in RIDGELAND, MS. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Engine And Engine Cooling Review #10442647 VOLVO XC90 2005 car safety problem was reported on Jan 06, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . tl* the contact owns a 2005 volvo xc90. the contact stated that while driving approximately 45 mph, the vehicle suddenly stalled without any warning. the contact was able to restart the vehicle after waiting a few moments. the vehicle had not been inspected by a dealer and was not repaired. the dealer was later notified, but the contact had yet to receive a response. the failure mileage was approximately 75,000. updated 02/15/12*bf updated 02/27/12 .Mileage was 75000 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in PACIFIC PALISIDES, CA. Original Owner. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. VEHICLE SPEED: 60 mph. DEALER'S NAME: SANTA MONICA VOLVO . Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10443420 VOLVO XC90 2005 car safety problem was reported on Jan 11, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . strong fuel odor within cabin after fuel fillup, there is a recall on fuel pumps due to fire risk on this exact model, just not on my vehicle. should i wait for a fire before a recall is issued? *tr.Mileage was 71000 miles. Vehicle Identification Number (VIN):YV1CZ592251. Volvo Xc90 2005 problem was reported in LIVINGSON, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10444391 VOLVO XC90 2005 car safety problem was reported on Jan 13, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . while leaving house to go and pick-up son from school .down the street vehicle started making a grinding noise. i pulled over and had vehicle towed to the volvo dealer to be repaired. thinking it would be covered by extended warranty i was told no. the problem was with the counterbalance shaft bearing. even though it was a manufactures flaw with the design of their engine repairs ran close to $3500.00 . i was planning to purchase another volvo vehicle but maybe not . i think i'll go american. *tr.Mileage was 90000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in SPRINGFIELD, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10444427 VOLVO XC90 2005 car safety problem was reported on Jan 17, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . i drove in severe down pour yesterday and experienced an yellow error message followed by an electrical short and anti skid message. i reduced my speed to 50 mph on the interstate and proceeded home. after stopping the lights would not turn off and i immediately took it in for service where the technician advised me that this was a problem with water getting into the engine compartment wiring harness and causing the central electronic module to short ciruit and rust. this repair alone costs over $5000 due their defective design and improper sealing of important electrical components. i avoided any possible accidents by driving slowly but do not feel safe were i to travel in inclement weather in the future. i do believe that the electrical system would short circuit leaving me without essential power and possibly hurt or stranded. i can see from your database that an investigation was completed on 11/22/2010 under id pe10025 citing no real safety issues. i disagree and would encourage you to revisit this issue immediately. volvo has conceded to replace the cem ($753.52) unit but not the engine compartment ($3034.71) that houses it, therefore owners like myself will continue to experience the same problem and real danger from it..Mileage was 76132 miles. Vehicle Identification Number (VIN):YV1CY592X51. Volvo Xc90 2005 problem was reported in OLD HICKORY, TN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 Electronic Stability ControlVolvo Xc90 2005 Electronic Stability Control Review #10444427 VOLVO XC90 2005 car safety problem was reported on Jan 17, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRONIC STABILITY CONTROL . i drove in severe down pour yesterday and experienced an yellow error message followed by an electrical short and anti skid message. i reduced my speed to 50 mph on the interstate and proceeded home. after stopping the lights would not turn off and i immediately took it in for service where the technician advised me that this was a problem with water getting into the engine compartment wiring harness and causing the central electronic module to short ciruit and rust. this repair alone costs over $5000 due their defective design and improper sealing of important electrical components. i avoided any possible accidents by driving slowly but do not feel safe were i to travel in inclement weather in the future. i do believe that the electrical system would short circuit leaving me without essential power and possibly hurt or stranded. i can see from your database that an investigation was completed on 11/22/2010 under id pe10025 citing no real safety issues. i disagree and would encourage you to revisit this issue immediately. volvo has conceded to replace the cem ($753.52) unit but not the engine compartment ($3034.71) that houses it, therefore owners like myself will continue to experience the same problem and real danger from it..Mileage was 76132 miles. Vehicle Identification Number (VIN):YV1CY592X51. Volvo Xc90 2005 problem was reported in OLD HICKORY, TN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10445712 VOLVO XC90 2005 car safety problem was reported on Jan 23, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . 2005 volvo xc90 v8 engine number 5569. balance shaft failure. or counter balance shaft failure. due to engine defect. balance shaft bearings in closed, non-lubricated area. bearings rest in an area that retains moisture and the bearings eventually deteriorate and fail. when this happens there is catastrophic engine failure. there are approximately 7000 vehicles with this defect. the defect was realized after engine 6883. we are very lucky that the failure did not occur the previous day on our 200 mile interstate trip. engine destruction at 75 mph could have proved fatal. loud popping and rattling from the engine was the only warning...no check engine light. volvo is aware of this defect and has sent service memos to drill holes to allow water in this area to drain and prevent rusting of bearings. there are many documented cases on this site and other traffic safety sites. a recall needs to be issued! *tr.Mileage was 86000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MT PLEASANT, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10446668 VOLVO XC90 2005 car safety problem was reported on Feb 06, 2010.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . our car wouldn't start in our garage one morning. turns out, we needed a new cem due to a leaking protection box (i can't remember the name of it but it started with a p). after 843 in parts and 816 in labor and almost a month at the dealer due to a backordered wiring harness the problem was fixed. after doing some research we have discovered that this is an epidemic among volvo owners and we are actually one of the lucky ones whose car died while it was parked instead of while we were driving! this is ridiculously dangerous and the fact that this leaking box is a common problem and that volvo has actually developed a redesigned model to fix the issue with their first gen model leads me to believe that they should be forced to replace their faulty design in all of their xc90s. as someone who bought her volvo for its reputation for safety, i am disgusted that this problem has been allowed to go on for so long. *kb.Mileage was 66754 miles. Vehicle Identification Number (VIN):YV1CM592551. Volvo Xc90 2005 problem was reported in PLYMOUTH, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Structure Body DoorVolvo Xc90 2005 Structure Body Door Review #10446874 VOLVO XC90 2005 car safety problem was reported on Jan 03, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with STRUCTURE:BODY:DOOR . tl* the contact owns a 2005 volvo xc90. while driving approximately 70 mph the front passenger's side door abnormally opened. the contact maneuvered to the side of the road with caution and closed the door securely however, the failure recurred once the vehicle was in motion. the vehicle was taken to an authorized dealer where the door cable was replaced. the manufacturer was notified of the defect and they were unable to provide assistance. the approximate failure mileage was 98,000. the consumer stated the dealer found a broken cable. the cable was replaced at a cost of $ 135.93. updated 03/01/12.Mileage was 98000 miles. Vehicle Identification Number (VIN):YV1CZ592351. Volvo Xc90 2005 problem was reported in LOTTSBURG, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. VEHICLE SPEED: 70 mph. DEALER'S NAME: ROSNER VOLVO . DEALER'S CITY: FREDERICKBURG . DEALER'S STATE CODE: VA. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10447496 VOLVO XC90 2005 car safety problem was reported on Jan 17, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . the trains has gone and it only has 66,000 miles on it cost to fix $ 5500.00. *tr.Mileage was 66000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in MASURY, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10451247 VOLVO XC90 2005 car safety problem was reported on Mar 12, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ELECTRICAL SYSTEM . this complaint refers to nhtsa action number pe10025. service bulletin number tnn 37-35. it is outrageous and unacceptable for you to not have issued a recall on this matter. volvo should be expected to replace my wiring grommet and/or plenum cover at no charge. it is applauding that volvo would not take this serious and issue a recall as it is clearly a defect and a safety hazard. my children and i were on the interstate when this happened to us and it was very dangerous. it is clearly a problem and safety issue that volvo recognizes or they would have not changed the design and issued a bulletin. i do not understand how a company can sell me a product that malfunctions and then expect me to pay them to repair it. *tr.Mileage was 190000 miles. Vehicle Identification Number (VIN):YV1CY592051. Volvo Xc90 2005 problem was reported in MARION, AR. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10453277 VOLVO XC90 2005 car safety problem was reported on Mar 15, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . transmission service urgent light came out. transmission was stuck in 3rd gear. had hard up shifts. *tr.Mileage was 68723 miles. Volvo Xc90 2005 problem was reported in FLORENCE, KY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10453277 VOLVO XC90 2005 car safety problem was reported on Mar 15, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . transmission service urgent light came out. transmission was stuck in 3rd gear. had hard up shifts. *tr.Mileage was 68723 miles. Volvo Xc90 2005 problem was reported in FLORENCE, KY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10453807 VOLVO XC90 2005 car safety problem was reported on Mar 16, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . my volvo 2005 xc 90 v8 engine failed. could not drive it so i had it towed to the volvo dealership. i was told, after 2 days of diagnosis, that the engine had to be replaced. i was told that volvo could not help with cost of new engine since i was out of warranty, date -wise but not mileage- wise. i have since discovered that a large number of like engines have suffered the same catastrophic engine failure due to a design defect concerning a bearing/shaft. to date, volvo has done nothing to help me. at a higher speed, this engine failure could have been fatal. *tr.Mileage was 87147 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in SHELBY, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10455001 VOLVO XC90 2005 car safety problem was reported on Mar 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with FUEL SYSTEM, GASOLINE . when i fill my tank up all the way my gasoline only lasts about 150 miles. the gas has got to be leaking somewhere!!! i have to fill my tank up several times a week. *tr.Vehicle Identification Number (VIN):YV1CY592351. Volvo Xc90 2005 problem was reported in NASHVILLE, TN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10455001 VOLVO XC90 2005 car safety problem was reported on Mar 01, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE AND ENGINE COOLING . when i fill my tank up all the way my gasoline only lasts about 150 miles. the gas has got to be leaking somewhere!!! i have to fill my tank up several times a week. *tr.Vehicle Identification Number (VIN):YV1CY592351. Volvo Xc90 2005 problem was reported in NASHVILLE, TN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10458080 VOLVO XC90 2005 car safety problem was reported on May 08, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . i attempted to pass another car and the engine revved very high while the transmission was slipping and could not go into gear. this put my children and i in a very dangerous situation with oncoming traffic. although i was able to swerve back into my own lane in time, it was a very scary 10 or 15 seconds. i have been afraid to drive it until i can get it into the repair shop, but have driven it on short trips around town. the transmission continues to slip some in normal driving. i'm taking it to volvo service tomorrow but some quick research found that this is a very common issue with this suv, and that volvo is completely aware of it. in fact, the customer service person i spoke with from volvo n.am said "it's an epidemic", and the service writer for northpoint volvo has seen it many, many times. it looks like i'm in for as much as $8500 for a transmission, and even more for possible damage to the axles as well as a new radiator, which seems to be the cause of the whole problem due to fluid contamination (glycol into the transmission fluid). i wasn't aware of the problem until now, but i had certainly wondered why my $48,000 vehicle had plummeted in value compared to other cars! this is not only a serious safety hazard but also a financial hardship on the many people who purchased this suv based on an expectation of quality at least in line with minimum industry standards. clearly this company is not standing behind their product and a recall is in order. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in SUWANEE, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 SuspensionVolvo Xc90 2005 Suspension Review #10458080 VOLVO XC90 2005 car safety problem was reported on May 08, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with SUSPENSION . i attempted to pass another car and the engine revved very high while the transmission was slipping and could not go into gear. this put my children and i in a very dangerous situation with oncoming traffic. although i was able to swerve back into my own lane in time, it was a very scary 10 or 15 seconds. i have been afraid to drive it until i can get it into the repair shop, but have driven it on short trips around town. the transmission continues to slip some in normal driving. i'm taking it to volvo service tomorrow but some quick research found that this is a very common issue with this suv, and that volvo is completely aware of it. in fact, the customer service person i spoke with from volvo n.am said "it's an epidemic", and the service writer for northpoint volvo has seen it many, many times. it looks like i'm in for as much as $8500 for a transmission, and even more for possible damage to the axles as well as a new radiator, which seems to be the cause of the whole problem due to fluid contamination (glycol into the transmission fluid). i wasn't aware of the problem until now, but i had certainly wondered why my $48,000 vehicle had plummeted in value compared to other cars! this is not only a serious safety hazard but also a financial hardship on the many people who purchased this suv based on an expectation of quality at least in line with minimum industry standards. clearly this company is not standing behind their product and a recall is in order. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 67000 miles. Vehicle Identification Number (VIN):YV1CZ911451. Volvo Xc90 2005 problem was reported in SUWANEE, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10466325 VOLVO XC90 2005 car safety problem was reported on July 11, 2012.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with POWER TRAIN . the transmission in this vehicle is slipping. trying to pass a car on the highway and could not get the car into gear. note: the vin # [xxx] - but i can't validate it on this form but it is the correct number. information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr.0 person(s) were injured. 0 person(s) died.Mileage was 64000 miles. Vehicle Identification Number (VIN):YC1CZ911151. Volvo Xc90 2005 problem was reported in MONROE, WA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10466349 VOLVO XC90 2005 car safety problem was reported on Jan 05, 2011.VOLVO XC90 2005, manufactured by VOLVO CARS OF N.A. LLC. had a problem with ENGINE . i noticed a grinding noise while driving at normal highway speed as it got worse over the next day or so i brought it to my local volvo specialist. after some research i was told that the problem was with the balance shaft and was specific to the 2005 xc90 v8. i contacted volvo north america and received no compensation or even satisfactory customer service. my local volvo tech recommended i bring the car to the volvo dealer, who were the only one's authorized to do the repair. the engine head had to be removed to replace the balance shaft and the bearings needed to be reassembled. it's amazing that the same exact problem can be reported to this extent and volvo still does nothing!! $4200 dollars later, the car was fixed. i'm glad it was caught prior to the engine needed to be replaced.. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 64983 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in POWDER SPRINGS, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Engine Review #10471742 VOLVO XC90 2005 car safety problem was reported on Dec 25, 2011.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . tl* the contact owns a 2005 volvo xc90. the contact stated that while driving approximately 35 mph, the engine stalled without any warning. the vehicle failed to restart and was towed to an independent auto shop for diagnosis. the technician stated the counter balance shaft bearing was frozen and the engine needed to be replaced. the vehicle was repaired. in addition, the headlights would intermittently operate and had not been repaired. the manufacturer was made aware of the problem. the approximate failure mileage was 88,000. updated 10/3/12 *cn updated 10/09/2012 *js.0 person(s) were injured. 0 person(s) died.Mileage was 88000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was purchased on Aug 29, 2010. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 35 mph. DEALER'S NAME: M AND I IMPORTS . DEALER'S CITY: HIGHLAND PARK . DEALER'S STATE CODE: IL. DEALER'S ZIPCODE: 60035 . Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10471742 VOLVO XC90 2005 car safety problem was reported on Dec 25, 2011.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . tl* the contact owns a 2005 volvo xc90. the contact stated that while driving approximately 35 mph, the engine stalled without any warning. the vehicle failed to restart and was towed to an independent auto shop for diagnosis. the technician stated the counter balance shaft bearing was frozen and the engine needed to be replaced. the vehicle was repaired. in addition, the headlights would intermittently operate and had not been repaired. the manufacturer was made aware of the problem. the approximate failure mileage was 88,000. updated 10/3/12 *cn updated 10/09/2012 *js.0 person(s) were injured. 0 person(s) died.Mileage was 88000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was purchased on Aug 29, 2010. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 35 mph. DEALER'S NAME: M AND I IMPORTS . DEALER'S CITY: HIGHLAND PARK . DEALER'S STATE CODE: IL. DEALER'S ZIPCODE: 60035 . Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10476961 VOLVO XC90 2005 car safety problem was reported on Sept 24, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . my car was at traffic light, on green light, i tried to accelerate , i heard a big noise from somewhere in engine area. after that noise, a light come on with a message " transmission service urgent". the car has real hard time to accelerate. even at 4000 rpm, it did not accelerate. browse on internet for 3 hours and finally come to know that this particular model has transmission problem. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 96005 miles. Vehicle Identification Number (VIN):YV1CZ911651. Volvo Xc90 2005 problem was reported in BRYANT, AR. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Fuel/propulsion SystemVolvo Xc90 2005 Fuel/propulsion System Review #10479719 VOLVO XC90 2005 car safety problem was reported on Oct 07, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL/PROPULSION SYSTEM . tl* the contact owns a 2005 volvo xc90. the contact stated that the interior of the vehicle smelled of gasoline and had stalled on multiple occasions. the vehicle was taken to the dealer who diagnose that the fuel pump needed to be replaced. the dealer notified the contact that the vehicle was not included in nhtsa campaign id number: 09v483000 (fuel system, gasoline: delivery: fuel pump). the failure and current mileage was 105,000..0 person(s) were injured. 0 person(s) died.Mileage was 105000 miles. Vehicle Identification Number (VIN):YV1CZ852251. Volvo Xc90 2005 problem was reported in RINGGOLD, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10480745 VOLVO XC90 2005 car safety problem was reported on Oct 14, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . sunday morning (10.14.12) car making a horrible noise from engine block. sounds like loose bolts rattling around inside engine block. checked trusted volvo forums on web. i have had four volvos between myself and my wife: 2000 s40 (wife), 2001 s80 and now 2005 s40 (wife) and my xc90 - used these forums to stay up on latest issues/maintenance. there were several posts with identical issue with this model, year and v8 engine. apparently, ongoing issue with counter balance shaft bearing. design flaw allows rust to occur at bearing and then then cb-shaft fails. will cause incredible damage to engine - maybe even death if occurs at high speeds. called dealer this morning, they are familiar with issue, wanted me to drive in or tow. cost is prohibitive and based on legions of similar consumer reports, am already certain of diagnosis. volvo na even distributed technical bulletin to service depts to drill moisture relief hole in bearing area as fix for those under warranty!!! that's insane!!! links to posts about issue (one owner even posted video of his engine noise): http://forums.swedespeed.com/showthread.php?123707-intermittent-clattering-noise-form-head-of-block-with-rough-running also http://s298.photobucket.com/albums/mm262/dlrnordic/vehicle20pictures202010/action=view¤t=img_0385.mp4 and http://wwwodi.nhtsa.dot.gov/complaints/results.cfmodi_ids=10313311&searchtype=quicksearch&summary=true&refurl=email need volvo na to step up and help, help, help! hardworking family man without estimated 10-15k to fix this!!! also, issue with internal rain leaks on 2005 s40 but never raised fuss. love our volvos but in a real spot here. come on volvo na, do the right thing!! will acknowledge volvo's committment to consumer all across web!!! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 81500 miles. Vehicle Identification Number (VIN):YV1CZ852451. Volvo Xc90 2005 problem was reported in WILLIAMSTOWN, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 45 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10483622 VOLVO XC90 2005 car safety problem was reported on Oct 01, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . the left headlight will suddenly go out, sometimes while driving and other times the headlight will not light when the vehicle is started. at times it remained off for only a few minutes and other times it will be for days. i'd taken the vehicle in for service, but each time i did, the left headlamp was again working. i'd also replaced the headlamp in question, but still the headlamp worked only intermittently. i just returned from my 4th visit to the dealer, at which time they replaced the left front light ballast ($440.00). the headlamp is currently working. my wife has been reluctant to drive the vehicle at night, for fear that both headlamps would go out. in researching online, i'm finding that this has been a recurrent problem with 2004 and 2005 volvo xc-90's. i understand that the nhtsa has been investigating this problem with the volvo xc-90 and a recall is being considered. we purchased the vehicle primarily due to it's 5-star safety rating, but we are not convinced that volvo has adequately addressed a known problem. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 110550 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in EAU CLAIRE, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10489205 VOLVO XC90 2005 car safety problem was reported on Nov 14, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . volvo knows the v8 engine on the 2005 xc90 is faulty. specifically, the counterbalance shaft bearing failing due to water intrusion. fortunately mine failed while at idle. unfortunately the entire engine is now seized up and my otherwise clean car is a large and useless paperweight. if this were to happen while the car is moving at speed, it could cause a horrible accident. unless volvo actively finds the remaining engines in service and fixes this problem, it remains a risk regardless of the mileage. appropriately, they should also reimburse anyone who was affected by this problem since they learned of it back in 2005. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 115000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in OAKTON, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10489205 VOLVO XC90 2005 car safety problem was reported on Nov 14, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . volvo knows the v8 engine on the 2005 xc90 is faulty. specifically, the counterbalance shaft bearing failing due to water intrusion. fortunately mine failed while at idle. unfortunately the entire engine is now seized up and my otherwise clean car is a large and useless paperweight. if this were to happen while the car is moving at speed, it could cause a horrible accident. unless volvo actively finds the remaining engines in service and fixes this problem, it remains a risk regardless of the mileage. appropriately, they should also reimburse anyone who was affected by this problem since they learned of it back in 2005. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 115000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in OAKTON, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Unknown Or OtherVolvo Xc90 2005 Unknown Or Other Review #10489205 VOLVO XC90 2005 car safety problem was reported on Nov 14, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with UNKNOWN OR OTHER . volvo knows the v8 engine on the 2005 xc90 is faulty. specifically, the counterbalance shaft bearing failing due to water intrusion. fortunately mine failed while at idle. unfortunately the entire engine is now seized up and my otherwise clean car is a large and useless paperweight. if this were to happen while the car is moving at speed, it could cause a horrible accident. unless volvo actively finds the remaining engines in service and fixes this problem, it remains a risk regardless of the mileage. appropriately, they should also reimburse anyone who was affected by this problem since they learned of it back in 2005. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 115000 miles. Vehicle Identification Number (VIN):YV1CZ852X51. Volvo Xc90 2005 problem was reported in OAKTON, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10490593 VOLVO XC90 2005 car safety problem was reported on Oct 06, 2011.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL SYSTEM, GASOLINE . tl* the contact owns a 2005 volvo xc90. the contact stated that the check engine warning light was illuminated on the instrument panel. the contact stated that he took the vehicle to a mechanic for inspection where they advised that the fuel pump module needed to be replaced. the contact notified the dealer three times but they did not complete the repair. the manufacturer was not notified. the failure mileage was unknown. updated 9/4/13 *cn.0 person(s) were injured. 0 person(s) died.Mileage was 131244 miles. Vehicle Identification Number (VIN):YV1CZ592551. Volvo Xc90 2005 problem was reported in STERLING HEIGHTS, MI. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 66 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10490743 VOLVO XC90 2005 car safety problem was reported on Dec 27, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . driving in pitch black night on backroads of charleston, sc. lights went out after left headlight flickered for a few days. lights went out and car went off road as we were in a curve. regained control after spinning on wet grass. i need the headlights repaired by volvo at their expense and reimbursement for the failed engine i had to replace. *tr.Vehicle was involved in a crash. 0 person(s) were injured. 0 person(s) died.Mileage was 103000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10490743 VOLVO XC90 2005 car safety problem was reported on Dec 27, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . driving in pitch black night on backroads of charleston, sc. lights went out after left headlight flickered for a few days. lights went out and car went off road as we were in a curve. regained control after spinning on wet grass. i need the headlights repaired by volvo at their expense and reimbursement for the failed engine i had to replace. *tr.Vehicle was involved in a crash. 0 person(s) were injured. 0 person(s) died.Mileage was 103000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10490848 VOLVO XC90 2005 car safety problem was reported on Dec 20, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . while driving on a gentle incline the transmission started slipping & shifting back & forth between gears. it lost power when trying to accelerate. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 85812 miles. Vehicle Identification Number (VIN):YV1CZ911351. Volvo Xc90 2005 problem was reported in PACIFIC GROVE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10491958 VOLVO XC90 2005 car safety problem was reported on Dec 20, 2012.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . this complaint relates to pe10025. i have to replace cem and casing for wiring cost 5500.00. volvo should be responsible for part or all of this repair. it is water seepage into the cem case. water drips down through hood of the car and corrodes the wires. causes major electrical shorts. i consider this to be a manufacturer defect. way to many cars are experiencing this issue and it is extremely costly. i would sincerely wish you to consider making volvo responsible. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 97000 miles. Vehicle Identification Number (VIN):YV1CZ592951. Volvo Xc90 2005 problem was reported in CRANFORD, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10494343 VOLVO XC90 2005 car safety problem was reported on Oct 01, 2009.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . the transmission failed at less than 85,000 miles. then the second transmission's out-put shaft began leaking with less than 40,000 miles on it, because according to the dealer it is "out-of-round/true". the transmission needs to be replaced. this transmission fluid leak is also a fire hazard..Mileage was 84500 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in ROCHESTER, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Volvo Xc90 2005 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Volvo Xc90 2005 Power Train Review #10498317 VOLVO XC90 2005 car safety problem was reported on Feb 14, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . at 111,000 thousand miles the counter balance shaft bearing went inside the motor. i did a little research on line and found out that it is a design problem, that volvo knows about. it could cost any where from $5000.00 to $15000.00. i believe that they should be forced to do a recall for this known problem, and help there customers with the repairs. thank you for your help in this matter. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 111000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in WINCHENDON, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Engine And Engine CoolingVolvo Xc90 2005 Engine And Engine Cooling Review #10498317 VOLVO XC90 2005 car safety problem was reported on Feb 14, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE AND ENGINE COOLING . at 111,000 thousand miles the counter balance shaft bearing went inside the motor. i did a little research on line and found out that it is a design problem, that volvo knows about. it could cost any where from $5000.00 to $15000.00. i believe that they should be forced to do a recall for this known problem, and help there customers with the repairs. thank you for your help in this matter. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 111000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in WINCHENDON, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Engine Review #10499664 VOLVO XC90 2005 car safety problem was reported on Feb 19, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . at 97000 miles the counterbalance shaft broke resulting in engine failure. service at volvo says i need a new engine. 7000-10000 for a used engine. contacted manufacturer, waiting for response. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 97000 miles. Vehicle Identification Number (VIN):YV1CZ852551. Volvo Xc90 2005 problem was reported in NORTH RIDGEVILLE, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Engine And Engine Cooling Review #10502431 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE AND ENGINE COOLING . was driving on free way, as i was accelerating i lost all power and steering.. the engine stalled out and i had to veer off to side so that i wouldn't cause an accident. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 150239 miles. Vehicle Identification Number (VIN):YV1CZ592551. Volvo Xc90 2005 problem was reported in STERLING HEIGHTS, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 Fuel/propulsion SystemVolvo Xc90 2005 Fuel/propulsion System Review #10502431 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL/PROPULSION SYSTEM . was driving on free way, as i was accelerating i lost all power and steering.. the engine stalled out and i had to veer off to side so that i wouldn't cause an accident. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 150239 miles. Vehicle Identification Number (VIN):YV1CZ592551. Volvo Xc90 2005 problem was reported in STERLING HEIGHTS, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 SteeringVolvo Xc90 2005 Steering Review #10502431 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with STEERING . was driving on free way, as i was accelerating i lost all power and steering.. the engine stalled out and i had to veer off to side so that i wouldn't cause an accident. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 150239 miles. Vehicle Identification Number (VIN):YV1CZ592551. Volvo Xc90 2005 problem was reported in STERLING HEIGHTS, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 75 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10502696 VOLVO XC90 2005 car safety problem was reported on June 25, 2010.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . counter balance shaft bearing failure and complete destruction of engine while traveling down a crowded i-95 going into ny city with two children in car. this is such a common problem with the vehicle, that it's criminal to not hold volvo accountable to fix this. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 48000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in LA GRANGE PARK, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Engine Review #10505600 VOLVO XC90 2005 car safety problem was reported on Jan 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . i purchased a 2005 volvo xc90 for $16,000. 6 months later the engine freezes up. that cost $10,000.00 to replace the engine. looked on google, very common for these v8 engines to freeze up. now the headlights are acting up. looked on google and found the headlight issue is very common. this will cost $3,000.00 to repair. this car is going to cost me almost as much to repair it as i paid for it!! volvo is loosing control. i would like you to issue a recall for these engine issues and issue a recall for these headlight issues. please google 2005 volvo xc90 v8 engine and google the same year and model about the headlight issue. you will be astounded by all the pages of complaints about what is supposed to be a great car. these cars where $62,000.00 brand new, what a joke they can sell this car with so many problems. please issue a recall. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr.0 person(s) were injured. 0 person(s) died.Mileage was 107000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10505600 VOLVO XC90 2005 car safety problem was reported on Jan 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . i purchased a 2005 volvo xc90 for $16,000. 6 months later the engine freezes up. that cost $10,000.00 to replace the engine. looked on google, very common for these v8 engines to freeze up. now the headlights are acting up. looked on google and found the headlight issue is very common. this will cost $3,000.00 to repair. this car is going to cost me almost as much to repair it as i paid for it!! volvo is loosing control. i would like you to issue a recall for these engine issues and issue a recall for these headlight issues. please google 2005 volvo xc90 v8 engine and google the same year and model about the headlight issue. you will be astounded by all the pages of complaints about what is supposed to be a great car. these cars where $62,000.00 brand new, what a joke they can sell this car with so many problems. please issue a recall. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr.0 person(s) were injured. 0 person(s) died.Mileage was 107000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in GLENVIEW, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 25 mph. Volvo Xc90 2005 Exterior Lighting Review #10509963 VOLVO XC90 2005 car safety problem was reported on Apr 21, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . 2006 volvo xc90 t6 awd april 21, 2013 approx 8:30 pm driving at approx 8:30 pm, traveling at about 55 miles per hour, remote 2-lane highway (us191, eastern arizona) on twisty mountainous road, switched from high-beam to low-beams to accommodate oncoming vehicle approaching around a bend. a moment or two after switching to low beams, the volvo's headlights lights flickered and went out all-together. error message reading something to the effect of "low beam bulb failure" appeared on message screen. high-beams didn't appear to be operable either. i activated fog lamps and proceeded cautiously to destination (approx 25 miles away). approx 15 miles from that point, i was pulled over by dps patrol advising i had no headlights...and that my license plate light was also not operating. the next morning, investigated further, discovered there were no issues with the headlight bulbs (low beam and high beam) or with license plate bulbs specifically (they were not burnt out), nor were there any issues with any blown fuses related to those exterior lights. i did discover that the drl (daytime running lights) were still operating as normal (which utilize the same bulb as the low headlights) confirming that there were no issues with those bulbs. all research since this event is pointing me to conclusion that this monumentally unsafe condition was caused by a bad/faulty cem design by volvo (online research, speaking with volvo mechanics and reviewing similar nhtsa complaints). there is no preventative maintenance that i could have done to prevent this from happening. this is not an owner maintenance issue, this is a design or materials issue. volvo should be required to recall & repair to prevent this safety issue. i request nhtsa open (re-open?) investigation into this issue, as this very dangerous safety issue that needs addressing before much worse consequences result. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 117000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in MORENCI, AZ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10509963 VOLVO XC90 2005 car safety problem was reported on Apr 21, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . 2006 volvo xc90 t6 awd april 21, 2013 approx 8:30 pm driving at approx 8:30 pm, traveling at about 55 miles per hour, remote 2-lane highway (us191, eastern arizona) on twisty mountainous road, switched from high-beam to low-beams to accommodate oncoming vehicle approaching around a bend. a moment or two after switching to low beams, the volvo's headlights lights flickered and went out all-together. error message reading something to the effect of "low beam bulb failure" appeared on message screen. high-beams didn't appear to be operable either. i activated fog lamps and proceeded cautiously to destination (approx 25 miles away). approx 15 miles from that point, i was pulled over by dps patrol advising i had no headlights...and that my license plate light was also not operating. the next morning, investigated further, discovered there were no issues with the headlight bulbs (low beam and high beam) or with license plate bulbs specifically (they were not burnt out), nor were there any issues with any blown fuses related to those exterior lights. i did discover that the drl (daytime running lights) were still operating as normal (which utilize the same bulb as the low headlights) confirming that there were no issues with those bulbs. all research since this event is pointing me to conclusion that this monumentally unsafe condition was caused by a bad/faulty cem design by volvo (online research, speaking with volvo mechanics and reviewing similar nhtsa complaints). there is no preventative maintenance that i could have done to prevent this from happening. this is not an owner maintenance issue, this is a design or materials issue. volvo should be required to recall & repair to prevent this safety issue. i request nhtsa open (re-open?) investigation into this issue, as this very dangerous safety issue that needs addressing before much worse consequences result. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 117000 miles. Vehicle Identification Number (VIN):YV1CZ911051. Volvo Xc90 2005 problem was reported in MORENCI, AZ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Electrical System Review #10512858 VOLVO XC90 2005 car safety problem was reported on May 06, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . tl* the contact owns a 2005 volvo xc90.the contact stated that while driving approximately 57 mph, all of the dashboard warning lights failed. the vehicle was taken to a private mechanic where it was diagnosed that the central control module needed to be replaced. the manufacturer was not made aware of the failure. the vehicle was not repaired. the approximate failure and current mileage was 106,000. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 106000 miles. Vehicle Identification Number (VIN):YV1CZ592451. Volvo Xc90 2005 problem was reported in MILFORD, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 57 mph. Volvo Xc90 2005 Unknown Or OtherVolvo Xc90 2005 Unknown Or Other Review #10514955 VOLVO XC90 2005 car safety problem was reported on June 04, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with UNKNOWN OR OTHER . just purchased this car and found that there were recalls. i would like to find out if my car has had them fixed. thank you. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 108000 miles. Vehicle Identification Number (VIN):YV1CZ911751. Volvo Xc90 2005 problem was reported in STOCKTON, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10537349 VOLVO XC90 2005 car safety problem was reported on Aug 13, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . i own a 2005 v8 xc90. like so many others i am a recent member to the cb failure club. yep. it's a club. the counter balance shaft failure club. this is a design defect that volvo is aware of and does nothing to remedy the poor saps who own a 2005 with the first 6883 engines produced by yamaha for volvo. after 6883 volvo made changes to the design of the counter balance shaft, by drilling a weep hole to let moisture out. unfortunately, my engine was in the 4000s. i live in southern california. about the driest climate you can get, but yet rust has destroyed my counter balance and thus destroyed my engine with only 80000 miles on it.btw, i have had my engine serviced regularly. but the counter balance shaft is something that can not be serviced without tearing the engine apart. it lies in the valley of the v8. in my case, and in all the other cases i am reading about, the bearings rusted and the shaft rusted and it tore apart my engine block. had i been driving on a freeway with my children and lost power it could have been fatal. how is it that this design flaw which causes catastrophic engine failure can be allowed not to be recalled? in fact, thanks to a overcharged alternator, i had just put a new $1400 computer in the car. yet, the computer never read check engine. why? because the computer is not monitoring the lubrication in a sealed bearing. and it is impossible without tearing the engine down for 10 hours (1200.00 in labor) to get to the counter balance shaft to see the condition of it. please, for the sake of others who might be unfortunate enough to drive this car and find themselves on a freeway when the engine blows due to cheap rusted bearings -- issue a recall!!! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 80560 miles. Vehicle Identification Number (VIN):YV1CZ852951. Volvo Xc90 2005 problem was reported in GLENDALE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10543169 VOLVO XC90 2005 car safety problem was reported on Sept 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . while driving back from work the passenger low beam went out. i bought a new bulb and the light still did not work l then checked. the wiring going into the headlight and there was no power for the low beam how does this happen it was bad enough i had to replace the whole transmission just 3months ago and now this i also read nonlinear they had problems with the trannys. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 146342 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in GREEN BAY, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10543169 VOLVO XC90 2005 car safety problem was reported on Sept 03, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . while driving back from work the passenger low beam went out. i bought a new bulb and the light still did not work l then checked. the wiring going into the headlight and there was no power for the low beam how does this happen it was bad enough i had to replace the whole transmission just 3months ago and now this i also read nonlinear they had problems with the trannys. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 146342 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in GREEN BAY, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10544906 VOLVO XC90 2005 car safety problem was reported on Sept 22, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . 2005 volvo xc90 v8 - engine number 6163 - counter balance shaft failure due to engine design defect. no recall by volvo despite very high volume of incidents and the safety risk to drivers and passengers of their vehicles. no check engine lights. volvo knows about this issue and chooses to ignore it, authorities are a aware of it and chose not to enforce safety standards on volvo- "volvo for life"...i think not..0 person(s) were injured. 0 person(s) died.Mileage was 111000 miles. Vehicle Identification Number (VIN):YV1CZ852151. Volvo Xc90 2005 problem was reported in NORWALK, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Engine Review #10549471 VOLVO XC90 2005 car safety problem was reported on Oct 14, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . the counterbalance shaft broke resulting in engine failure. volvo estimates repair at $5,0000. ridiculous. why doesn't volvo fix this well known issue for loyal customers. i have had 5 volvos in my life starting back in the 1980's and love the cars but this lack of care for customer welfare is just wrong. it may be my last volvo if this is how they treat customers now days. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 150000 miles. Volvo Xc90 2005 problem was reported in ST. LOUIS, MO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Air BagsVolvo Xc90 2005 Air Bags Review #10558552 VOLVO XC90 2005 car safety problem was reported on Dec 18, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with AIR BAGS . the central electronic module (cem) will not perform as intended. as a result, audio system, parking assist, and passenger airbag does not work. audio system turns on sporadically by itself and runs continuously(i have to pull over, turn the engine off, then wait 3+ minutes to stop it). as a result, the front windshield wipers might run continuously when the ignition is on. also, the turn signals, high beams, and headlight switch might not work. this issue was recall 2014 volvo s60, s80, xc60 and xc70. 2005 xc90 but it should be included in this recall because malfunctioning electronic system (passenger airbags, head lamps, and/or turn signals) increase the risk of a crash. it's not fair, when same problem is accepted as reason for recall for 2014 models(xc60, s60, s80, xc70) but not 2005 xc90s. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 102000 miles. Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in LANSING, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10558552 VOLVO XC90 2005 car safety problem was reported on Dec 18, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . the central electronic module (cem) will not perform as intended. as a result, audio system, parking assist, and passenger airbag does not work. audio system turns on sporadically by itself and runs continuously(i have to pull over, turn the engine off, then wait 3+ minutes to stop it). as a result, the front windshield wipers might run continuously when the ignition is on. also, the turn signals, high beams, and headlight switch might not work. this issue was recall 2014 volvo s60, s80, xc60 and xc70. 2005 xc90 but it should be included in this recall because malfunctioning electronic system (passenger airbags, head lamps, and/or turn signals) increase the risk of a crash. it's not fair, when same problem is accepted as reason for recall for 2014 models(xc60, s60, s80, xc70) but not 2005 xc90s. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 102000 miles. Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in LANSING, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10561371 VOLVO XC90 2005 car safety problem was reported on Dec 26, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . known transmission defect with this model has manifested itself in my vehicle. car began lurching when accelerating and transitioning into the next gear while attempting to merge onto a busy interstate highway. dealer diagnosed the problem and states that the transmission needs to be replaced. apparently volvo has acknowledged this defect with the power-train and in 2012 agreed to settle a class action lawsuit with regards to this problem. this fact however only impacts those who previously paid to have this problem fixed. still no recall regarding this potentially hazardous issue for those currently impacted. all vehicles equipped with their original transmissions need to be recalled (2003, 2004 and 2005). *tr.0 person(s) were injured. 0 person(s) died.Mileage was 102000 miles. Vehicle Identification Number (VIN):YV1CZ592951. Volvo Xc90 2005 problem was reported in HAMILTON, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 65 mph. Volvo Xc90 2005 Visibility/wiperVolvo Xc90 2005 Visibility/wiper Review #10562081 VOLVO XC90 2005 car safety problem was reported on Jan 23, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with VISIBILITY/WIPER . tl* the contact owns a 2005 volvo xc90. the contact stated while driving approximately 35 mph the windshield wipers became inoperable. the vehicle was taken to an independent mechanic where the mechanic diagnosed that the central electronic module needed to be replaced. the vehicle was not repaired. the manufacturer was made aware of the failure. the contact was informed by the manufacturer that his vehicle was not covered under nhtsa campaign number: 06v144000 (visibility). the approximate failure mileage was 128,000. .0 person(s) were injured. 0 person(s) died.Mileage was 128000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in HARRISBURG, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Electronic Stability ControlVolvo Xc90 2005 Electronic Stability Control Review #10562413 VOLVO XC90 2005 car safety problem was reported on Dec 04, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRONIC STABILITY CONTROL . volvo is aware of the balancer shaft defect that causing a very pricey and serious problem. the fix was to drill a hole but not to repair any damage caused by the design flaw. i was informed by the volvo dealership that this is a design flaw in the 2005 cx90 and the cost would be around $4000 to fix the damage done to the balance shaft because of the design flaw. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 99000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in CHANDLER, AZ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10562413 VOLVO XC90 2005 car safety problem was reported on Dec 04, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . volvo is aware of the balancer shaft defect that causing a very pricey and serious problem. the fix was to drill a hole but not to repair any damage caused by the design flaw. i was informed by the volvo dealership that this is a design flaw in the 2005 cx90 and the cost would be around $4000 to fix the damage done to the balance shaft because of the design flaw. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 99000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in CHANDLER, AZ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Fuel/propulsion SystemVolvo Xc90 2005 Fuel/propulsion System Review #10563531 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL/PROPULSION SYSTEM . this car has been a constant problem - i am the original owner and the cost to repair is extremely high.. i am a recent widow and a single mother of 3 children on a fixed income... i am so tired of this car being so unreliable and the repair costs are bankrupting me. i have no where to turn this car has been a lemon from day one and the manufacturer and dealer could care less. *tr.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):WILL SUPPLY. Volvo Xc90 2005 problem was reported in GLEN MILLS, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10563531 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . this car has been a constant problem - i am the original owner and the cost to repair is extremely high.. i am a recent widow and a single mother of 3 children on a fixed income... i am so tired of this car being so unreliable and the repair costs are bankrupting me. i have no where to turn this car has been a lemon from day one and the manufacturer and dealer could care less. *tr.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):WILL SUPPLY. Volvo Xc90 2005 problem was reported in GLEN MILLS, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10563531 VOLVO XC90 2005 car safety problem was reported on Feb 03, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . this car has been a constant problem - i am the original owner and the cost to repair is extremely high.. i am a recent widow and a single mother of 3 children on a fixed income... i am so tired of this car being so unreliable and the repair costs are bankrupting me. i have no where to turn this car has been a lemon from day one and the manufacturer and dealer could care less. *tr.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):WILL SUPPLY. Volvo Xc90 2005 problem was reported in GLEN MILLS, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine Review #10563765 VOLVO XC90 2005 car safety problem was reported on Jan 15, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . the motor failed on my 2005 volvo xc90 as a result of the counterbalance shaft bearings failing due to moisture in the motor. i was not aware this motor was subject to failure at less than or even around 100k miles. volvo dealership said this was the cause of the motor failure and they said there was no recall done. after this happened i went to some volvo websites(swedespeed) only to find this same exact motor failure has happened to very many of these 2005 volvo xc90's because of the counterbalance shaft bearings failing. in face there's a forum category titled "v8 counterbalance shaft failure thread" where people talk about this exact problem happening over and over and volvo knows about this engine problem but will not do a recall. something has to be done where volvo back their products, especially the engine in a vehicle. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 99000 miles. Vehicle Identification Number (VIN):YV1CZ852851. Volvo Xc90 2005 problem was reported in NORTH PROVIDENCE, RI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 SteeringVolvo Xc90 2005 Steering Review #10564127 VOLVO XC90 2005 car safety problem was reported on Dec 12, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with STEERING . i bought this car at 12/12/2013 when i test drove the car the dealer had the radio on and i never suspected any noise at the time.after i bought the car i kept hearing this knocking noise at first i thought is was the ski rack making the noise then when my husband drove it he said it was coming from the tires so i took the car to my mechanic and he check it a out and found multiple problems the suspension,inner tie rods,axles,sway bar, steering,bushings etc his reply was how did this car pass inspection with all the problems available take the car back and ask the dealer to fix the problems.i took the car back and ask the dealer to comply they would not i told them they had received a faulty inspections on the car so i took it to another mechanic same response. i then called the safety inspectors and they came out to check out the car and found nothing. i then took it to another dealer and they reported the same problems and added a cracked engine mount. i then asked the inspector to come and look at all the things that volvo found that the safety inspectors missed he agreed and saw but only wrote a report i still have a broke car that was faulty inspected. i want the dealer to fix my problem and they have refused i could sue them for getting a faulty inspection and selling a lemon but i fell like i am stuck i need to know what to do from here i have already paid for several things the rack and pinion is the most important i have to fix but expensive and the bushings and tie rods are going to be the next thing i repair i really don't have the money to fix them i am paying 7000.00 for a used car and i fell that the dealer and the inspectors are crooks and used a faulty inspection to sell a broke car please help. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 11700 miles. Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in MANASSAS, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 SuspensionVolvo Xc90 2005 Suspension Review #10564127 VOLVO XC90 2005 car safety problem was reported on Dec 12, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with SUSPENSION . i bought this car at 12/12/2013 when i test drove the car the dealer had the radio on and i never suspected any noise at the time.after i bought the car i kept hearing this knocking noise at first i thought is was the ski rack making the noise then when my husband drove it he said it was coming from the tires so i took the car to my mechanic and he check it a out and found multiple problems the suspension,inner tie rods,axles,sway bar, steering,bushings etc his reply was how did this car pass inspection with all the problems available take the car back and ask the dealer to fix the problems.i took the car back and ask the dealer to comply they would not i told them they had received a faulty inspections on the car so i took it to another mechanic same response. i then called the safety inspectors and they came out to check out the car and found nothing. i then took it to another dealer and they reported the same problems and added a cracked engine mount. i then asked the inspector to come and look at all the things that volvo found that the safety inspectors missed he agreed and saw but only wrote a report i still have a broke car that was faulty inspected. i want the dealer to fix my problem and they have refused i could sue them for getting a faulty inspection and selling a lemon but i fell like i am stuck i need to know what to do from here i have already paid for several things the rack and pinion is the most important i have to fix but expensive and the bushings and tie rods are going to be the next thing i repair i really don't have the money to fix them i am paying 7000.00 for a used car and i fell that the dealer and the inspectors are crooks and used a faulty inspection to sell a broke car please help. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 11700 miles. Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in MANASSAS, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Unknown Or OtherVolvo Xc90 2005 Unknown Or Other Review #10564127 VOLVO XC90 2005 car safety problem was reported on Dec 12, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with UNKNOWN OR OTHER . i bought this car at 12/12/2013 when i test drove the car the dealer had the radio on and i never suspected any noise at the time.after i bought the car i kept hearing this knocking noise at first i thought is was the ski rack making the noise then when my husband drove it he said it was coming from the tires so i took the car to my mechanic and he check it a out and found multiple problems the suspension,inner tie rods,axles,sway bar, steering,bushings etc his reply was how did this car pass inspection with all the problems available take the car back and ask the dealer to fix the problems.i took the car back and ask the dealer to comply they would not i told them they had received a faulty inspections on the car so i took it to another mechanic same response. i then called the safety inspectors and they came out to check out the car and found nothing. i then took it to another dealer and they reported the same problems and added a cracked engine mount. i then asked the inspector to come and look at all the things that volvo found that the safety inspectors missed he agreed and saw but only wrote a report i still have a broke car that was faulty inspected. i want the dealer to fix my problem and they have refused i could sue them for getting a faulty inspection and selling a lemon but i fell like i am stuck i need to know what to do from here i have already paid for several things the rack and pinion is the most important i have to fix but expensive and the bushings and tie rods are going to be the next thing i repair i really don't have the money to fix them i am paying 7000.00 for a used car and i fell that the dealer and the inspectors are crooks and used a faulty inspection to sell a broke car please help. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 11700 miles. Vehicle Identification Number (VIN):YV1CZ911151. Volvo Xc90 2005 problem was reported in MANASSAS, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Visibility Sun Roof AssemblyVolvo Xc90 2005 Visibility Sun Roof Assembly Review #10565772 VOLVO XC90 2005 car safety problem was reported on Feb 25, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with VISIBILITY:SUN ROOF ASSEMBLY . tl* the contact owns a 2005 volvo xc90. the contact stated that water leaked into the vehicle through the sun roof. the water caused damaged to the headliner and floorboard carpet. the failure also caused the seats to move independently and a growth of mold and mildew inside the vehicle. the contact also stated that there were several water bugs and other types of insects infesting the vehicle due to the water accumulation. the contact suffered from medical distress as a result of the failure. the contact took the vehicle to the dealer for diagnosis but was not repaired. the manufacturer was made aware of the failure and declined to repair the vehicle. the contact took the vehicle to two independent mechanics but they were unable to drain the several gallons of water that could be heard from the vehicle. the vehicle was not repaired. the approximate failure mileage was 122,000. the current vehicle mileage was 130,000. the vin was not available. .1 person(s) were injured. 0 person(s) died.Mileage was 122000 miles. Volvo Xc90 2005 problem was reported in LYNN HAVEN, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Structure BodyVolvo Xc90 2005 Structure Body Review #10565772 VOLVO XC90 2005 car safety problem was reported on Feb 25, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with STRUCTURE:BODY . tl* the contact owns a 2005 volvo xc90. the contact stated that water leaked into the vehicle through the sun roof. the water caused damaged to the headliner and floorboard carpet. the failure also caused the seats to move independently and a growth of mold and mildew inside the vehicle. the contact also stated that there were several water bugs and other types of insects infesting the vehicle due to the water accumulation. the contact suffered from medical distress as a result of the failure. the contact took the vehicle to the dealer for diagnosis but was not repaired. the manufacturer was made aware of the failure and declined to repair the vehicle. the contact took the vehicle to two independent mechanics but they were unable to drain the several gallons of water that could be heard from the vehicle. the vehicle was not repaired. the approximate failure mileage was 122,000. the current vehicle mileage was 130,000. the vin was not available. .1 person(s) were injured. 0 person(s) died.Mileage was 122000 miles. Volvo Xc90 2005 problem was reported in LYNN HAVEN, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10565947 VOLVO XC90 2005 car safety problem was reported on Sept 18, 2008.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . tl- the contact owns a 2005 volvo xc90. the contact stated while driving 55 mph the vehicle stalled without warning. the vehicle was taken to the dealer for inspection but they could not diagnose the cause of failure. the vehicle was not repaired. the manufacturer was notified of the failure. the vin was unavailable. the failure mileage was 45,000. rk .0 person(s) were injured. 0 person(s) died.Mileage was 45000 miles. Volvo Xc90 2005 problem was reported in COLLIERVILLE, TN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Vehicle Speed ControlVolvo Xc90 2005 Vehicle Speed Control Review #10572870 VOLVO XC90 2005 car safety problem was reported on Mar 15, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with VEHICLE SPEED CONTROL . was starting to accelerate after a red traffic light when the engine suddenly died and car stopped right in the middle of traffic. car would not start again. battery was good, started worked good but it sounded like no gas was getting to the engine. being stuck in the middle of traffic, i was pushed by the car behind me to a safe location out of traffic. towed car to shop and still investigating the failure. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 120000 miles. Vehicle Identification Number (VIN):YV1CZ592151. Volvo Xc90 2005 problem was reported in LITTLETON, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 10 mph. Volvo Xc90 2005 Fuel System, GasolineVolvo Xc90 2005 Fuel System, Gasoline Review #10572870 VOLVO XC90 2005 car safety problem was reported on Mar 15, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL SYSTEM, GASOLINE . was starting to accelerate after a red traffic light when the engine suddenly died and car stopped right in the middle of traffic. car would not start again. battery was good, started worked good but it sounded like no gas was getting to the engine. being stuck in the middle of traffic, i was pushed by the car behind me to a safe location out of traffic. towed car to shop and still investigating the failure. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 120000 miles. Vehicle Identification Number (VIN):YV1CZ592151. Volvo Xc90 2005 problem was reported in LITTLETON, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 10 mph. Volvo Xc90 2005 SteeringVolvo Xc90 2005 Steering Review #10574506 VOLVO XC90 2005 car safety problem was reported on Mar 19, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with STEERING . tl* the contact owns a 2005 volvo xc90. the contact stated that while driving various speeds, the vehicle would jerk and the turning signals failed. the contact stated that the electronic power steering system, srs air bag service, anti-skid, and the immobilizer warning lights illuminated. the vehicle was taken to a dealer where it was diagnosed that the central electronic module, rack and pinion nut, and pinion shaft needed to be replaced. the manufacturer was notified of the failure. the vehicle was not repaired. the approximate failure and current mileage was 139,419. .0 person(s) were injured. 0 person(s) died.Mileage was 139419 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in TACOMA, WA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10574506 VOLVO XC90 2005 car safety problem was reported on Mar 19, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . tl* the contact owns a 2005 volvo xc90. the contact stated that while driving various speeds, the vehicle would jerk and the turning signals failed. the contact stated that the electronic power steering system, srs air bag service, anti-skid, and the immobilizer warning lights illuminated. the vehicle was taken to a dealer where it was diagnosed that the central electronic module, rack and pinion nut, and pinion shaft needed to be replaced. the manufacturer was notified of the failure. the vehicle was not repaired. the approximate failure and current mileage was 139,419. .0 person(s) were injured. 0 person(s) died.Mileage was 139419 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in TACOMA, WA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10578331 VOLVO XC90 2005 car safety problem was reported on Mar 20, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . we purchased this 2005 volvo xc90 used in october 2011 and since that time have had to replace the headlamp module 3 times. the left headlights would sometimes work and other times not. each time we took it in for diagnosis, we were told that the headlamp module needed to be replace. this is a $460 part, one that has a long history of failure. my wife is afraid to drive this vehicle at night, for fear that the headlights will go out. i can understand if the module failed once, or maybe even twice, but three times in only 2.5 years and less than 20,000 miles. it appears that this is a recurring problem with other volvo owners as well, yet volvo has not taken steps to remedy the issue. i consider this to be a significant safety issue, one that need to be addressed. i am very disappointed with volvo's lack of action to correct this problem. checking online, i see that many other volvo xc90 owners have been experiencing the same problem. any assistance will be greatly appreciated. thank you. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 119150 miles. Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in EAU CLAIRE, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 35 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10579490 VOLVO XC90 2005 car safety problem was reported on Mar 17, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . complete instrument panel failure while driving - no ability to let the windows up or down, no speedometer visibility, no gas reading . there was no ability for defogging window, no ability to turn on heat or air. this is really dangerous when driving. the panel goes completely blank. *js.0 person(s) were injured. 0 person(s) died.Mileage was 112655 miles. Vehicle Identification Number (VIN):YV1CM592651. Volvo Xc90 2005 problem was reported in LILBURN, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 5 CYLINDERS. Volvo Xc90 2005 drive type:AWD. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10585891 VOLVO XC90 2005 car safety problem was reported on May 01, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . 2005 volvo xc90. consumer writes in regards to engine breakdown. *smd an initial independent mechanic believed the problem was due to a declared design flaw by volvo in their 2005 models. the mechanic advised the consumer, to have the vehicle towed to the dealer. the dealer had the vehicle for 3 weeks and determined the cause of the engine break down was in fact a design flaw. corporate volvo stated the issue was not problematic enough for them to issue a recall, as problems were evaluated on a case-by-case basis. volvo informed the dealer to re-build the engine, instead of replacing it. *jb.Volvo Xc90 2005 problem was reported in ACWORTH, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: JIM ELLIS VOLVO . DEALER'S TELEPHONE NUMBER: 866-950-7386 . DEALER'S CITY: MARIETTA . DEALER'S STATE CODE: GA. DEALER'S ZIPCODE: 30060 . Volvo Xc90 2005 Engine Review #10595522 VOLVO XC90 2005 car safety problem was reported on Apr 17, 2013.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . good morning, i purchase a 2005 volvo xc90 from drive time on march 29, 2013, prior to purchasing this vehicle it was my dream automobile, on april 17, 2013 my check engine light came on, i was late for work because i went to drive time to find out where to take it since i did purchase the drive care package. i called the claim department and because of miles i travel daily the warranty mileage had expire, which was confusing because on the sale slip on the car it stated 30 day warranty, i was told to take it a volvo dealer for service, i took it to mooers volvo in richmond, va and the diagnostic test indicate there were misfire in the spark plugs ($500) later, they also stated they were the original plugs and needed to be changed and my drive care package didn't cover maintenance. four days later the check engine light was back on, indicating the same problem (misfire in plugs 6 &8) again missing time from work to have this checked out because i don'¿¿t want to be broke down on the highway. this time they change the fuel filter and put a gas treatment in my car ($154) later, stating that it was something to do w/fuel tank. i have spent a little over $1000, in repairs and car rental and my car was two months old at that time. i got my car serviced on time and still my check engine is still on.i went to a shop recently because of the (a year later) check engine light is still on. they suggest i look up the recall safety because now one side b1 has a misfire reading. no one seems to know how to fix the problem and i travel an hour each way to work and would hate for something terrible to happen. i'm hoping you would guide me in the right direction to have my car repaired or who i need to direct my concerns to. thank you in advance for any assistance. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 103000 miles. Vehicle Identification Number (VIN):YV1CZ852351. Volvo Xc90 2005 problem was reported in N. CHESTERFIELD, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10619092 VOLVO XC90 2005 car safety problem was reported on July 31, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . tl* the contact owns a 2005 volvo xc90. while driving approximately 55 mph, the vehicle stalled without warning. the contact stated that the transmission failed and the instrument panel dimmed temporarily. the contact disconnected the battery cable to reset the vehicle and managed to restart the vehicle. the failure occurred multiple times. an independent mechanic stated that the central electric module malfunctioned which prevents the vehicle from draining water properly during rainy conditions. the vehicle was not repaired. the vin was unavailable. the approximate failure mileage was 165,000. .0 person(s) were injured. 0 person(s) died.Mileage was 165000 miles. Volvo Xc90 2005 problem was reported in BILOXI, MS. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10619092 VOLVO XC90 2005 car safety problem was reported on July 31, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . tl* the contact owns a 2005 volvo xc90. while driving approximately 55 mph, the vehicle stalled without warning. the contact stated that the transmission failed and the instrument panel dimmed temporarily. the contact disconnected the battery cable to reset the vehicle and managed to restart the vehicle. the failure occurred multiple times. an independent mechanic stated that the central electric module malfunctioned which prevents the vehicle from draining water properly during rainy conditions. the vehicle was not repaired. the vin was unavailable. the approximate failure mileage was 165,000. .0 person(s) were injured. 0 person(s) died.Mileage was 165000 miles. Volvo Xc90 2005 problem was reported in BILOXI, MS. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10629144 VOLVO XC90 2005 car safety problem was reported on Apr 08, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . i purchase a used 2005 volvo on april 19, 2013 from c& m auto sales corporation. in december of 2013 i received a recall notice from volvo. they notified me that all 2004-2005 volvo xc90- were recalled. i was informed to take it to a volvo dealer. i drove the vehicle to white plains, n y. dealer there i was told they took care of the problem. upon returning home i noticed all lights were on the dashboard & return the vehicle to the dealer. there were many issues claimed by the dealers and was told to pick it up which i did ever since then vehicle has been parked and not driven. .0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):YV1CZ911251. Volvo Xc90 2005 problem was reported in BRONX, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 Power TrainVolvo Xc90 2005 Power Train Review #10641999 VOLVO XC90 2005 car safety problem was reported on Sept 01, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with POWER TRAIN . transmission completely failed. this was the 2nd transmission, as the first one failed at 45000 miles. i had to replace the transmission at a cost of $6000. rebuilding failed trans was slightly cheaper but not worth it. i understand there is a class action lawsuit, but was settled before my transmission failed. .0 person(s) were injured. 0 person(s) died.Mileage was 155000 miles. Vehicle Identification Number (VIN):YV1CZ911X51. Volvo Xc90 2005 problem was reported in COLTS NECK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10649735 VOLVO XC90 2005 car safety problem was reported on Sept 26, 2011.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . this is a 2005 volvo that has a history of transmission failure in all cars of this model and year. if one googles the model and make of this car one will find forum after forum of people who have had to replace these failed transmissions before or shortly after warranty is up. the dealers and services have largely put this item which should have been a recall issue on to the customer. my transmission failed when trying to accelerate on to a freeway. i was nearly in a likely fatal collision due to the transmission failing to go out of 2nd gear. there was a class action suit surrounding this issue in this model , but few volvo owners were notified of it. please help us and demand that volvo recall these cars, repay for failed transmissions and lost value of the cars......one cannot even give them away no and these were 45k$ cars!!!!!!!!!!furious..0 person(s) were injured. 0 person(s) died.Mileage was 45 miles. Volvo Xc90 2005 problem was reported in MENLO PARK, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph. Volvo Xc90 2005 Vehicle Speed ControlVolvo Xc90 2005 Vehicle Speed Control Review #10649780 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with VEHICLE SPEED CONTROL . while driving vehicle at 55-60 mph all dashboard lights came on and car lost power. this caused a frightening and extremely dangerous situation. without headlights or tail lights i could not be seen by other drivers. i tried to cross 2 lanes and get onto the shoulder with no power steering or engine power. while i was very fortunate i was not in or did not cause a serious accident i had an extremely close calls. i changed lanes and almost collided with another vehicle traveling at 55. once in the lane another driver who was unable to see my vehicle (no lights) came up behind me at a high rate of speed. only a last minute swerve avoided a rear end collision that no doubt would have caused a terrible accident with very serious if not tragic results. additionally other drivers had to swerve to avoid the vehicle-causing a very dangerous, chaotic situation. the loss of power and loss of lights came close to causing a major multi-vehicle accident. many are aware of this problem. please do not wait until people are killed to reopen the investigation and re-consider a safety recall. .0 person(s) were injured. 0 person(s) died.Mileage was 170000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Exterior LightingVolvo Xc90 2005 Exterior Lighting Review #10649780 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with EXTERIOR LIGHTING . while driving vehicle at 55-60 mph all dashboard lights came on and car lost power. this caused a frightening and extremely dangerous situation. without headlights or tail lights i could not be seen by other drivers. i tried to cross 2 lanes and get onto the shoulder with no power steering or engine power. while i was very fortunate i was not in or did not cause a serious accident i had an extremely close calls. i changed lanes and almost collided with another vehicle traveling at 55. once in the lane another driver who was unable to see my vehicle (no lights) came up behind me at a high rate of speed. only a last minute swerve avoided a rear end collision that no doubt would have caused a terrible accident with very serious if not tragic results. additionally other drivers had to swerve to avoid the vehicle-causing a very dangerous, chaotic situation. the loss of power and loss of lights came close to causing a major multi-vehicle accident. many are aware of this problem. please do not wait until people are killed to reopen the investigation and re-consider a safety recall. .0 person(s) were injured. 0 person(s) died.Mileage was 170000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10649780 VOLVO XC90 2005 car safety problem was reported on Aug 20, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . while driving vehicle at 55-60 mph all dashboard lights came on and car lost power. this caused a frightening and extremely dangerous situation. without headlights or tail lights i could not be seen by other drivers. i tried to cross 2 lanes and get onto the shoulder with no power steering or engine power. while i was very fortunate i was not in or did not cause a serious accident i had an extremely close calls. i changed lanes and almost collided with another vehicle traveling at 55. once in the lane another driver who was unable to see my vehicle (no lights) came up behind me at a high rate of speed. only a last minute swerve avoided a rear end collision that no doubt would have caused a terrible accident with very serious if not tragic results. additionally other drivers had to swerve to avoid the vehicle-causing a very dangerous, chaotic situation. the loss of power and loss of lights came close to causing a major multi-vehicle accident. many are aware of this problem. please do not wait until people are killed to reopen the investigation and re-consider a safety recall. .0 person(s) were injured. 0 person(s) died.Mileage was 170000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in MIDLOTHIAN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10652117 VOLVO XC90 2005 car safety problem was reported on Oct 21, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . i was just driving along at 30 mph or less when i heard a pretty load noise and then felt a vibration on the floor board. i was just a block away from my destination and when i got there the noise continued. i originally thought the noise was coming from under the car but after further investigation later in the day after letting the car sit for awhile i realized the noise was coming from the engine. i had the car originally towed to my mechanic who informed me that the engine was blown. i could not believe this i had the car a little under one year and the previous owner always had the car serviced through a volvo dealership from day one to 60,200. i took over the car and at the time of the incident my car had a little over 85,000 miles. engines are not suppose to fail at under 100,000 miles. there is something seriously wrong with these engines. the internet is full of these stories just like mine and volvo is doing nothing about it! they do not care, they do not stand behind their cars. something has to be done about this a lot of innocent people are being hurt financially by volvo. a recall on these car should be issued...volvo needs to be held accountable for this! volvo made the determination not to help me...without even seeing the car and the service records. action needs to happen and they need to be forced to help me and the hundreds if not thousands of people that have been affected by this. .0 person(s) were injured. 0 person(s) died.Mileage was 85000 miles. Vehicle Identification Number (VIN):YV1CZ852651. Volvo Xc90 2005 problem was reported in MAHOPAC, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10658892 VOLVO XC90 2005 car safety problem was reported on Nov 17, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . after parking at restaurant, we walked to our parked volvo and when i turned the key, it would only go from 0 to the 1 position ( i.e.lights, radio would come on) but it would not turn any further to the start position had to have it towed to the dealer and was told this has happened before to this model and it is an ignition lock failure. they need to order the part from sweden and have it match our keys. $850 !!. this is a safety issue in my mind has we could have been stranded anywhere and if this is not the first time this has happened, why are they not recalling this part? .0 person(s) were injured. 0 person(s) died.Mileage was 156000 miles. Vehicle Identification Number (VIN):YV1CZ911951. Volvo Xc90 2005 problem was reported in LAFAYETTE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Electrical System Review #10660192 VOLVO XC90 2005 car safety problem was reported on Oct 30, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . driving at approximately 40 mph, the check engine and oil warning lights appeared. the car completely died while i was on the road. the steering wheel and brakes froze up and the speed decreased to barely nothing. i could get the car to just make it off the road safely because i could not turn the wheel or use the brakes well. thought it was my oil so i was able to get someone to add oil to it while on side of busy road. started car up fine and drove for 5 more days until it happened again. got it towed to mechanic who changed the fuel pump. other electrical problems arouse while mechanic had it so brought to volvo who says i need a new control electric module in my car. .0 person(s) were injured. 0 person(s) died.Mileage was 115000 miles. Vehicle Identification Number (VIN):YV1CZ592051. Volvo Xc90 2005 problem was reported in RAYNHAM, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Fuel/propulsion SystemVolvo Xc90 2005 Fuel/propulsion System Review #10660192 VOLVO XC90 2005 car safety problem was reported on Oct 30, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL/PROPULSION SYSTEM . driving at approximately 40 mph, the check engine and oil warning lights appeared. the car completely died while i was on the road. the steering wheel and brakes froze up and the speed decreased to barely nothing. i could get the car to just make it off the road safely because i could not turn the wheel or use the brakes well. thought it was my oil so i was able to get someone to add oil to it while on side of busy road. started car up fine and drove for 5 more days until it happened again. got it towed to mechanic who changed the fuel pump. other electrical problems arouse while mechanic had it so brought to volvo who says i need a new control electric module in my car. .0 person(s) were injured. 0 person(s) died.Mileage was 115000 miles. Vehicle Identification Number (VIN):YV1CZ592051. Volvo Xc90 2005 problem was reported in RAYNHAM, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 40 mph. Volvo Xc90 2005 Electrical SystemVolvo Xc90 2005 Electrical System Review #10668406 VOLVO XC90 2005 car safety problem was reported on June 16, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ELECTRICAL SYSTEM . 2005 xc90 v8 stalled in traffic. would not restart, but starter would crank. fuel pump controller was found to be internally corroded and filled with dried salt. this controller is mounted forward of the right rear wheel well. many instances of this controller failing due to salt / moisture ingress have been reported by other owners. the controller was relocated to the inside of the vehicle some model years later. .0 person(s) were injured. 0 person(s) died.Mileage was 90000 miles. Volvo Xc90 2005 problem was reported in ANN ARBOR, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 Fuel/propulsion SystemVolvo Xc90 2005 Fuel/propulsion System Review #10668406 VOLVO XC90 2005 car safety problem was reported on June 16, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with FUEL/PROPULSION SYSTEM . 2005 xc90 v8 stalled in traffic. would not restart, but starter would crank. fuel pump controller was found to be internally corroded and filled with dried salt. this controller is mounted forward of the right rear wheel well. many instances of this controller failing due to salt / moisture ingress have been reported by other owners. the controller was relocated to the inside of the vehicle some model years later. .0 person(s) were injured. 0 person(s) died.Mileage was 90000 miles. Volvo Xc90 2005 problem was reported in ANN ARBOR, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 20 mph. Volvo Xc90 2005 EngineVolvo Xc90 2005 Engine Review #10671814 VOLVO XC90 2005 car safety problem was reported on Dec 23, 2014.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . the bearing for the counter balance shaft has failed on my vehicle, causing over $3,000 in repairs needed. volvo has admitted that this is a known issue with older 2005 xc90's with the v8, but are not willing to cover my repairs costs. i feel there should be a recall. if this bearing fails while driving the engine could seize causing an accident. .0 person(s) were injured. 0 person(s) died.Mileage was 129300 miles. Vehicle Identification Number (VIN):YV1CZ852251. Volvo Xc90 2005 problem was reported in FRANKLIN, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph. Volvo Xc90 2005 Engine Review #10673038 VOLVO XC90 2005 car safety problem was reported on Jan 15, 2015.VOLVO XC90 2005, manufactured by Volvo Cars of N.A., LLC had a problem with ENGINE . tl-the contact owns a 2005 volvo xc90. the contact stated that while driving at approximately 45 mph, the vehicle emitted an abnormal noise and stalled. in addition, the check engine warning light illuminated. the vehicle was taken to an independent mechanic where it was diagnosed that the wire cem needed to be replaced. the vehicle was not repaired. the manufacturer was made aware of the failure. the failure mileage was 120,000. djr .0 person(s) were injured. 0 person(s) died.Mileage was 120000 miles. Vehicle Identification Number (VIN):YV1CZ852751. Volvo Xc90 2005 problem was reported in SOPHIA, NC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 45 mph. |
-
Volvo Xc90 2005 Forum
Discuss and Report Volvo Xc90 Problems -
Service Bulletins
View Recent Volvo Xc90 2005 repair guidance -
Recalls
Latest recall and safety Volvo Xc90 2005 information
Volvo Xc90 2005 Systems
Search 1000s of Car Reviews, Recalls and Technical Bulletins
Start by entering a car model, system, manufacturer or any combination of keywords.
Volvo Xc90 2005 Reports
Having fuel delivery issues, car will not maintain idle and pedal does not work. I have replaced both fuel pumps, coil, wires, cap and rotor, plugs, throttle position sensor. Just ordered mass air flow sensor. Whats next fuel injectors? can the hydraulic clutch on a 2007 vn610 be adjusted? My vovlo s70 1998 lost power going 40mph and then will start right back up. I just bought a 2001 Volvo C70 convertible 113,000 miles - no warranty - it started bucking a bit - I took it for an oil change and they wouldn't do it because the dipstick top came right off and the dipstick is stuck inside so he said he couldn't a/c compressor runs for about 30n seconds after start up then shuts down . 2002 volvo vhd Is it good to buy the Volvo CX60? The passenger seat belt is stuck and will not extend. I have an 2004 xc70. What is the fix? I have fooled with it but no luck. how to install crankshaft gear We keep getting "tire pressure system service required" warnings on our 2007 volvo V70 2.5t. There was a recall on this is for the 2007-2010 v80. start of fuel deliver at the Bosch injetion pump hi want is the correct price for s40 2000 steering rack and pinion and do need the boot and filter
Anyone else seeing this?