FORD EXPLORER 1997 Technical Service Bulletins

FORD EXPLORER 1997 technical service bulletin was issued Oct 18, 1996.FORD EXPLORER 1997 had a failed TIRES. FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 17, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE BELTS AND ASSOCIATED PULLEYS. TENSIONER RATTLE . INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 04, 1996.FORD EXPLORER 1997 had a failed SUSPENSION REAR SPRINGS COIL SPRINGS. THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 04, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION FOR ALL BASE ENGINE CONCERNS OF 4.0L SOHC ENGINES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1996.FORD EXPLORER 1997 had a failed EQUIPMENT OTHER OWNERS/SERVICE/OTHER MANUAL. OWNERS GUIDE ADVISES TO USE A FL-1A OIL FILTER, FL-1A IS INCORRECT. THE CORRECT FILTER IS FL-820. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE BELTS AND ASSOCIATED PULLEYS. CONCERN OF A TENSIONER RATTLE W/ 4.0L SOHC, INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1996.FORD EXPLORER 1997 had a failed TIRES. FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE DRIVESHAFT. VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. COLD ENGINE KNOCK/TICK NOISE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 27, 1996.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. WHEN A REAR HEGO (CMS) CONCERN IS NOTED, PLEASE CHECK THE REAR CMS HEGO FOR WIRE CHAFING/DAMAGE AND LOOSE HEGO WIRE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 13, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VEHICLES MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 08, 1996.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK CONTROL UNIT/MODULE. INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 08, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE DRIVESHAFT. DRIVESHAFT DESIGN MAY CAUSE FLOORPAN VIBRATION WHILE AT HIGHWAY SPEEDS OR WITH THROTTLE WIDE OPEN. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. CONCERN OF BINDING/AXLE WIND-UP AT LOW SPEED. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1996.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. VEHICLE LEAN. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1996.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VEHICLE MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 18, 1996.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 18, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION TORQUE CONVERTER. TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 18, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 21, 1996.FORD EXPLORER 1997 had a failed VISIBILITY WINDSHIELD. WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 21, 1996.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 02, 1996.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 16, 1996.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION TORQUE CONVERTER. TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). TRANSFER CASE BIND OR SHUDDER. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. BINDING/AXLE WIND-UP AT LOW SPEED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. POWER LOCKS CYCLE BY THEMSELVES REMOVE EACH POWER LOCK SWITCH AND MEASURE THE OPEN RESISTANCE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. COLD ENGINE KNOCK/TICK NOISE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). 4.0L OHV/SOHC 4X4 EXPLORERS WITH TRANSFER CASE BIND OR SHUDDER. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). REVISED VENT TUBE FOR VEHICLES WITH WATER INGESTION INTO TRANSFER CASE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed EXTERIOR LIGHTING. LAMP OUTAGE MODULE (LOM) ON THE VEHICLES- PLEASE VERIFY IF THE VEHICLE HAS: 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. TRANSFER CASE- WATER INGESTION THROUGH VENT TUBE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON A VEHICLE PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE. DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION PARK/NEUTRAL START SWITCH. AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT AT TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. WHEN PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM HOSE. 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE DIESEL. SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VARIOUS VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM- TO FIX, REMOVE EXISTING MUFFLER AND REPLACE WITH SAME PART. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE DIESEL. BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed SUSPENSION FRONT SPRINGS AIR SUSPENSION SYSTEM. VEHICLES MAY EXHIBIT REVERSE OPERATING CHARACTERISTICS WHEN SWITCHING THE AIR SUSPENSION SWITCH FROM NORMAL TO OFF ROAD. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM MANIFOLD/HEADER/MUFFLER/TAIL PIPE. EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT A TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM HOSE. 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL. INCREASED THROTTLE EFFORTS MAY BE NOTED ON SOME 4.0L SOHC EQUIPPED VEHICLES DUE TO THROTTLE PLATE ALIGNMENT. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 23, 1997.FORD EXPLORER 1997 had a failed SUSPENSION REAR. FRONT AXLE VENT LEAKS ON 1997 EXSPLORERS BUILT BEFORE 11/1/06. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. DRIVELINE WIND-UP IN 4-AUTO MODE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 03, 1997.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 03, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. REMOTE KEYLESS ENTRY- RKE INOPERATIVE- VEHICLES BUILT THROUGH 10/30/96. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 03, 1997.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 03, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). TRANSFER CASE- BINDING OR SHUDDER- DIAGNOSTICS- VEHICLES WITH 4.0L ENGINE- SERVICE TIP. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 17, 1997.FORD EXPLORER 1997 had a failed STRUCTURE. FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 25, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. REAR CRANKSHAFT SEAL OIL LEAKS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 21, 1997.FORD EXPLORER 1997 had a failed EQUIPMENT OTHER LABELS. INCORRECT OIL VISCOSITY LABEL IN ENGINE COMPARTMENT. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. THE 1997 EXPLORER 4.0L SOHC IS THE ONLY VEHICLE EQUIPPED WITH A NEW STYLE (BLACK PLASTIC) DPFE SENSOR. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 21, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION. OEM SPARK PLUGS MAY EXHIBIT A CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 19, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. 4.0L SHOC ENGINE QUITS WHILE DRIVING AND WILL NOT RESTART. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 19, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. EXPLORERS EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP IN. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL. ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP-IN FROM THE THROTTLE BODY/IAC AREA OF THE ENGINE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLE ENGINE COMPARTMENT DECALS MAY INCORRECTLY LIST 10W30 FOR OIL VISCOSITY. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. VEHICLES WITH REAR CRANKSHAFT SEAL OIL LEAKS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION. 4.0L SOHC ENGINE COMES FROM THE FACTORY WITH SINGLE PLATINUM PLUGS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM RADIATOR ASSEMBLY. RADIATORS MAY EXHIBIT A COOLANT LEAK AT THE END TANK SEALS IN COLD TEMPERATURES. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 07, 1997.FORD EXPLORER 1997 had a failed EXTERIOR LIGHTING HEADLIGHTS. REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A.
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 06, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 06, 1997.FORD EXPLORER 1997 had a failed LATCHES/LOCKS/LINKAGES DOORS LATCH. DOOR LATCH SWITCH IS CAUSING THE DOOR AJAR LIGHT/CHIME NOT TO WORK PROPERLY. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 31, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L SOHC ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 03, 1997.FORD EXPLORER 1997 had a failed SEATS. INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 03, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 03, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 03, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 03, 1997.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 17, 1997.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM. EMISSIONS RECALL 96E57 - CERTAIN 1996 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT ON 11/18/95 AND CERTAIN 1997 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT FROM .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY. VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK OR RATTLE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM EMISSION CONTROL GAS RECIRCULATION VALVE (EGR VALVE). RECALL 97S67 - MODIFICATION OF THE PCV VALVE REQUIRES A SPECIAL TOOL WHICL WILL SENT TO LISTED PARTS MANAGERS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed VISIBILITY WINDSHIELD WIPER/WASHER. VEHICLES BUILT ON OR AFTER 4/14/97 WILL NO LONGER HAVE A REAR WASHER BOTTLE - A REDESIGNED FRONT WASHER BOTTLE WILL SUPPLY THE FLUID TO BOTH WASHERS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN MANUAL TRANSMISSION. NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE FRAME AND MEMBERS. SOME RUNNING BOARD PADS MAY WARPED. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. MAY 1997 GEM SOFTWARE HAS ERRORS - JUNE SOFTWARE IS CORRECT. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. SERVICE FIX FOR VEHICLES WHICH EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 MODE. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE FRAME AND MEMBERS. LIFTGATE LOCK CONCERNS ON VEHICLES BUILT THROUGH 12/96. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. 1997 4.0L SOHC 4X4 EXPLORERS AND 1997 5.0L AWD EXPLORERS/MOUNTAINEERS SHOULD NOT BE EQUIPPED WITH A VIBRATION DAMPER ON THE TRANSFER CASE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. LIFTGATE LOCKS WILL NOT LOCK/UNLOCK WHEN ACTUATED BY THE POWER SWITCHES. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. VEHICLES MAY EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 AUTO MODE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION MODULE. VEHICLES WITH DTC P0402 IN MEMORY ARE UNDER INVESTIGATION BY ENGINEERING DEPARTMENT. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE FRAME AND MEMBERS. SOME RUNNING BOARD PADS MAY BE WARPED. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN CLUTCH ASSEMBLY. UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed VISIBILITY WINDSHIELD WIPER/WASHER. VEHICLES BUILT AFTER 4/14/97 NO LONGER HAVE A REAR WASHER BOTTLE - REDESIGNED FRONT WASHER BOTTLE WILL SERVICE THE FRONT AND REAR WASHERS. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY. VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed SUSPENSION. WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1997.FORD EXPLORER 1997 had a failed STRUCTURE BODY TAILGATE. ENGINEERING IS INVESTIGATING CONCERNS OF BROKEN LIFTGATE GLASS. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 10, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE. CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 02, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM. EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 16, 1998.FORD EXPLORER 1997 had a failed STRUCTURE BODY. REPAIRS TO VINYL COVERED SURFACES. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 16, 1998.FORD EXPLORER 1997 had a failed STRUCTURE BODY. SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 27, 1998.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 18, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS DISC ROTOR. HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 18, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 27, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 27, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC PEDALS AND LINKAGES. SOME CUSTOMERS NOTICE A GRINDING, WHINING, PULSING, OR FLUTTERING AT THE BRAKE PEDAL AT SPEEDS BELOW 19 KM/H (12 MPH). *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 02, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, AIR DISC ROTOR. AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 13, 1998.FORD EXPLORER 1997 had a failed TIRES. INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 16, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE. CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 30, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM. INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 13, 1998.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM. EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK. CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK ABS WARNING LIGHT. CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed CHILD SEAT. CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 21, 1998.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 21, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 21, 1998.FORD EXPLORER 1997 had a failed SEATS. CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 26, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. EXPERIENCING A NOISE AND VIBRATION DURING IDLE. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL. SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 12, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM. EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 12, 1998.FORD EXPLORER 1997 had a failed SEATS FRONT ASSEMBLY POWER ADJUST. CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed STRUCTURE BODY HOOD. AIR INTAKE TUBE CONTACTING HOOD INSULATOR CAUSING INSULATOR WEAR. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM EMISSION CONTROL. MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed VISIBILITY DEFROSTER/DEFOGGER SYSTEM. SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 23, 1998.FORD EXPLORER 1997 had a failed STRUCTURE BODY. INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 07, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM. FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 08, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN. INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 08, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed AIR BAGS. VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS DISC ROTOR. SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed STRUCTURE. SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed EXTERIOR LIGHTING. SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. EXPERIENCING AN AUDIBLE NOISE IN ENGINE. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. SUBJECT REGARDING AN OVERHEATING CONDITION OCCURRING TO THE LAMP OUTAGE MODULE (LOM-2) WITH THE INSTALLATION OF CERTAIN AFTERMARKET TRAILER KITS THAT IMPROPERLY CONNECT TO THE TAIL AND BRAKE LAMPS CIRCUITS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 19, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. SUBJECT REGARDING LAMP OUTAGE MODULE HOUSING AND SURROUNDING PLASTIC COMPONENTS MELTED - EDDIE BAUER AND LIMITED EDITION MODELS EQUIPPED WITH MESSAGE CENTERS AND IMPROPERLY CONNECTED TOW WIRING KITS (VEHICLES BEING TOWED). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1997.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE. EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1999.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL LINKAGES. RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM. SUBJECT REGARDING POSITIVE CRANKCASE VENTILATION (PCV) TUBE MODIFICATION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM EMISSION CONTROL GAS RECIRCULATION VALVE (EGR VALVE). SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 03, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 03, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 03, 1999.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 17, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 14, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 14, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 14, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 28, 1999.FORD EXPLORER 1997 had a failed EXTERIOR LIGHTING BRAKE LIGHTS. CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION COOLING UNIT AND LINES. CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL. CUSTOMER MAY COMPLAIN OF AN INTERMITTENT STUMBLE / BUCK / JERK AT 38 MPH WHILE IN HIGH GEAR AND AT VERY LIGHT THROTTLE APPLICATION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed STRUCTURE BODY. INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1999.FORD EXPLORER 1997 had a failed TIRES. INFORMATION ON MAINTAINING TIRE PRESSURE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1999.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE. SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1998.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS.. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM FUSES AND CIRCUIT BREAKERS. SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 27, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 25, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION REGARDING ENGINES ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 1998.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. COLD ENGINE UPPER KNOCK/TICK. *AK .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. REAR CRANKSHAFT SEAL OIL LEAK. *AK .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 12, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 26, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 26, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed STEERING HYDRAULIC POWER ASSIST POWER STEERING FLUID. EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL LINKAGES. VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 03, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING EXHAUST SYSTEM EMISSION CONTROL. A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 03, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. A VEHICLE VIBRATES DURING A HOT OR COLD IDLE CONDITION. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT MECHANICAL WRECKER AND WHEEL LIFT DEVICES. VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed SUSPENSION REAR SPRINGS COIL SPRINGS. EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK. SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI LOCK BRAKES MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed SUSPENSION. EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 07, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION COOLING UNIT AND LINES. TRANSMISSION FLUID LEAKS AT RADIATOR. YD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 07, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 07, 2000.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 1999.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL CRUISE CONTROL. SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE. SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 1999.FORD EXPLORER 1997 had a failed AIR BAGS. EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 1999.FORD EXPLORER 1997 had a failed AIR BAGS FRONTAL SENSOR/CONTROL MODULE. EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed SUSPENSION FRONT STABILIZER BAR. SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN MANUAL TRANSMISSION. SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK. SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS (PIDS) WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH WHEN VIEWED USING THE NEW GENERATION STAR (NGS) TESTER. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed STEERING HYDRAULIC POWER ASSIST SYSTEM. EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE.
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 10, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 2000.FORD EXPLORER 1997 had a failed INTERIOR LIGHTING. SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT MECHANICAL WRECKER AND WHEEL LIFT DEVICES. SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT. INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN DRIVELINE DIFFERENTIAL UNIT. FRONT AXLE PINION LIL SEAL LEAKS. .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 2000.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN. SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed SUSPENSION FRONT. REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed TIRES. INFORMATION REGARDING THE TIRE INFLATION PRESSURE FOR ALL MODELS DURING PREDELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING. INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM IGNITION ANTI-THEFT CONTROLLER. SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. REPEAT MESSAGE REGARDING ENGINE STALLING *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1998.FORD EXPLORER 1997 had a failed TIRES. INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 17, 2000.FORD EXPLORER 1997 had a failed SUSPENSION REAR. SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 17, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2000.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 1998.FORD EXPLORER 1997 had a failed VISIBILITY DEFROSTER/DEFOGGER SYSTEM WINDSHIELD BLOWER. ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed SUSPENSION. STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed SEATS FRONT ASSEMBLY RECLINER. SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed WHEELS. SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed SEATS. SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1998.FORD EXPLORER 1997 had a failed WHEELS. SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION LEVER AND LINKAGE COLUMN SHIFT. SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL CRUISE CONTROL. SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed SUSPENSION. INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM. FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC ANTILOCK. ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 1998.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 2000.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 13, 2000.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION COOLING UNIT AND LINES. SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 27, 2000.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL ACCELERATOR PEDAL. ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELER.
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT. SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 01, 2000.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM RADIATOR ASSEMBLY. CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM RADIATOR ASSEMBLY. SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 05, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY ON CERTAIN VEHICLES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT OTHER LABELS. SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 2000.FORD EXPLORER 1997 had a failed SUSPENSION REAR. SUBJECT REGARDING ADDITIONAL COVERAGE PROGRAM FOR SWAY BAR LINKS. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 02, 2000.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE DELIVERY FUEL PUMP. SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 16, 2000.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 2000.FORD EXPLORER 1997 had a failed SUSPENSION. SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 01, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 30, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR BREAK AND CAUSE EXCESSIVE CAM CHAIN NOISE THAT DOES NOT GO AWAY AFTER FIVE MINUTES OF ENGINE OPERATION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 02, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 2001.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 26, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 2001.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM. INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2000.FORD EXPLORER 1997 had a failed VEHICLE SPEED CONTROL. SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME EXPLORER / SPORT / SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE CONDITION FROM THE LEFT FRONT OF THE ENGINE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 27, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 06, 2001.FORD EXPLORER 1997 had a failed VISIBILITY DEFROSTER/DEFOGGER SYSTEM WINDSHIELD HEATER CORE. SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 06, 2001.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 2001.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 17, 2001.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION PARK/NEUTRAL START SWITCH. BRAKE SHIFT INTERLOCK.*JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 2000.FORD EXPLORER 1997 had a failed SUSPENSION FRONT SPRINGS TORSION BAR. INFORMATION REGARDING FRONT SWAY BAR LINK . *YH .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 15, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 2001.FORD EXPLORER 1997 had a failed TIRES. OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 21, 2002.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2002.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE DELIVERY HOSES, LINES/PIPING, AND FITTINGS. INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2002.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 10, 2001.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Feb 18, 2002.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 10, 2003.FORD EXPLORER 1997 had a failed POWER TRAIN MANUAL TRANSMISSION. LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 04, 2002.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 2002.FORD EXPLORER 1997 had a failed STEERING. EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 2002.FORD EXPLORER 1997 had a failed SUSPENSION. SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 2002.FORD EXPLORER 1997 had a failed POWER TRAIN. SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 2002.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 29, 2002.FORD EXPLORER 1997 had a failed POWER TRAIN. SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 04, 1999.FORD EXPLORER 1997 had a failed STRUCTURE BODY BUMPERS. INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 04, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 18, 1999.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM WIRING. SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 18, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 06, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 20, 1999.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 20, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 15, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 15, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING COOLING SYSTEM. A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed SEATS. INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT MECHANICAL WRECKER AND WHEEL LIFT DEVICES. INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed SEATS. INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT MECHANICAL WRECKER AND WHEEL LIFT DEVICES. INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 17, 1998.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. LOCKS FAILED. YD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 01, 1999.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE STORAGE TANK ASSEMBLY. SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN MANUAL TRANSMISSION. BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed EQUIPMENT ELECTRICAL RADIO/TAPE DECK/CD ETC.. CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 01, 1999.FORD EXPLORER 1997 had a failed AIR BAGS FRONTAL SENSOR/CONTROL MODULE. SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed STEERING RACK AND PINION RACK. EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Aug 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued June 01, 1999.FORD EXPLORER 1997 had a failed STRUCTURE BODY. USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 01, 1999.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY AXLE SHAFT SEAL. SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 22, 2002.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Mar 17, 2003.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2003.FORD EXPLORER 1997 had a failed SUSPENSION REAR. VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 12, 2003.FORD EXPLORER 1997 had a failed FUEL SYSTEM, OTHER. MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 21, 2003.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION COOLING UNIT AND LINES. NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued July 01, 2003.FORD EXPLORER 1997 had a failed POWER TRAIN. AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 15, 2003.FORD EXPLORER 1997 had a failed ELECTRICAL SYSTEM. REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 05, 2003.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION. NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 11, 2002.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE. ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 01, 2002.FORD EXPLORER 1997 had a failed SUSPENSION FRONT SPRINGS AIR SUSPENSION SYSTEM. AIR RIDE CONTROL LAMP ON AFTER SHOCK ABSORBER REPLACEMENT / CONTACT REQUEST. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Dec 13, 2004.FORD EXPLORER 1997 had a failed POWER TRAIN AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM). GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Apr 01, 2005.FORD EXPLORER 1997 had a failed POWER TRAIN AXLE ASSEMBLY. FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 01, 2001.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC FOUNDATION COMPONENTS. CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 01, 2002.FORD EXPLORER 1997 had a failed UNKNOWN OR OTHER. INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Nov 15, 1999.FORD EXPLORER 1997 had a failed STRUCTURE BODY DOOR. INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued May 03, 1999.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING ENGINE GASOLINE. FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 21, 1996.FORD EXPLORER 1997 had a failed FUEL SYSTEM, GASOLINE CARBURETOR SYSTEM. MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Oct 21, 1996.FORD EXPLORER 1997 had a failed EQUIPMENT AIR CONDITIONER. AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed EXTERIOR LIGHTING TAIL LIGHTS. WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON THE ABOVE VEHICLES PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN TRANSFER CASE (4-WHEEL DRIVE). REVISED VENT TUBE FOR 1995-97 EXPLORERS & MOUNTAINEERS WITH WATER INGESTION INTO TRANSFER CASE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed POWER TRAIN CLUTCH ASSEMBLY PEDAL/LINKAGE. PROCEDURE TO PURGE POTENTIAL WATER CONTAMINATION FROM TRANSFER CASE. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Jan 02, 1997.FORD EXPLORER 1997 had a failed ENGINE AND ENGINE COOLING. VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEMP GAUGE SYSTEM PARTS. *JD .
Post Your Comment Go Top

FORD EXPLORER 1997 technical service bulletin was issued Sept 02, 2002.FORD EXPLORER 1997 had a failed SERVICE BRAKES, HYDRAULIC SWITCHES BRAKE LIGHT. LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ .
Post Your Comment Go Top