Car-and-Safety.com

Ford F-550 2004 Electrical System Wiring

Ford F-550 2004 Electrical System Wiring Review #10132084

FORD F-550 2004 car safety problem was reported on July 01, 2004.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with ELECTRICAL SYSTEM:WIRING . dt: the vehicle surged and accelerated on its own. this happened this has happened a t least 50 times or more. while driving 43 mph vehicle shut down. had to slam on the emergency brake and pull it to the curb. also, while driving at 38 mph or 1100 rpms there was vibration coming from the engine. it felt like it was coming right from consumer's feet. it felt like transmission disengaged. then, after 10-15 seconds it felt like it kicked back in. there was a loud pop when this happened. the vehicle was burning more fuel than it did when first purchased it. sometimes the water and fuel lights came on. the dealer told him that when this happened he should pull over. but when he does there is no water in the fuel. the fuel gauge will completely go to low then come back up after about 10-15 miles. also, the air bag light will come on. when he takes vehicle to the dealer they usually go through the whole vehicle, specifically the electrical systems. the dealership tried but failed to fix these problems. had taken the vehicle to a variety of dealerships multiple times. the turbo, transmission and wiring was replaced. the dealer told the consumer that the vehicle had not been coded when he purchased it. *ak.0 person(s) were injured. 0 person(s) died.Mileage was 525 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in SANLEANDRO, CA. Original Owner. Vehicle was purchased on May 01, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:RWD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SOUTH SAN FRANCISCO FORD . DEALER'S CITY: SOUTH SAN FRANCISCO . DEALER'S STATE CODE: CA.

Ford F-550 2004 Power Train Automatic Transmission

Ford F-550 2004 Power Train Automatic Transmission Review #10132084

FORD F-550 2004 car safety problem was reported on July 01, 2004.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . dt: the vehicle surged and accelerated on its own. this happened this has happened a t least 50 times or more. while driving 43 mph vehicle shut down. had to slam on the emergency brake and pull it to the curb. also, while driving at 38 mph or 1100 rpms there was vibration coming from the engine. it felt like it was coming right from consumer's feet. it felt like transmission disengaged. then, after 10-15 seconds it felt like it kicked back in. there was a loud pop when this happened. the vehicle was burning more fuel than it did when first purchased it. sometimes the water and fuel lights came on. the dealer told him that when this happened he should pull over. but when he does there is no water in the fuel. the fuel gauge will completely go to low then come back up after about 10-15 miles. also, the air bag light will come on. when he takes vehicle to the dealer they usually go through the whole vehicle, specifically the electrical systems. the dealership tried but failed to fix these problems. had taken the vehicle to a variety of dealerships multiple times. the turbo, transmission and wiring was replaced. the dealer told the consumer that the vehicle had not been coded when he purchased it. *ak.0 person(s) were injured. 0 person(s) died.Mileage was 525 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in SANLEANDRO, CA. Original Owner. Vehicle was purchased on May 01, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:RWD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SOUTH SAN FRANCISCO FORD . DEALER'S CITY: SOUTH SAN FRANCISCO . DEALER'S STATE CODE: CA.

Ford F-550 2004 Vehicle Speed Control

Ford F-550 2004 Vehicle Speed Control Review #10132084

FORD F-550 2004 car safety problem was reported on July 01, 2004.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with VEHICLE SPEED CONTROL . dt: the vehicle surged and accelerated on its own. this happened this has happened a t least 50 times or more. while driving 43 mph vehicle shut down. had to slam on the emergency brake and pull it to the curb. also, while driving at 38 mph or 1100 rpms there was vibration coming from the engine. it felt like it was coming right from consumer's feet. it felt like transmission disengaged. then, after 10-15 seconds it felt like it kicked back in. there was a loud pop when this happened. the vehicle was burning more fuel than it did when first purchased it. sometimes the water and fuel lights came on. the dealer told him that when this happened he should pull over. but when he does there is no water in the fuel. the fuel gauge will completely go to low then come back up after about 10-15 miles. also, the air bag light will come on. when he takes vehicle to the dealer they usually go through the whole vehicle, specifically the electrical systems. the dealership tried but failed to fix these problems. had taken the vehicle to a variety of dealerships multiple times. the turbo, transmission and wiring was replaced. the dealer told the consumer that the vehicle had not been coded when he purchased it. *ak.0 person(s) were injured. 0 person(s) died.Mileage was 525 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in SANLEANDRO, CA. Original Owner. Vehicle was purchased on May 01, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:RWD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SOUTH SAN FRANCISCO FORD . DEALER'S CITY: SOUTH SAN FRANCISCO . DEALER'S STATE CODE: CA.

Ford F-550 2004 Fuel System, Other

Ford F-550 2004 Fuel System, Other Review #10132084

FORD F-550 2004 car safety problem was reported on July 01, 2004.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, OTHER . dt: the vehicle surged and accelerated on its own. this happened this has happened a t least 50 times or more. while driving 43 mph vehicle shut down. had to slam on the emergency brake and pull it to the curb. also, while driving at 38 mph or 1100 rpms there was vibration coming from the engine. it felt like it was coming right from consumer's feet. it felt like transmission disengaged. then, after 10-15 seconds it felt like it kicked back in. there was a loud pop when this happened. the vehicle was burning more fuel than it did when first purchased it. sometimes the water and fuel lights came on. the dealer told him that when this happened he should pull over. but when he does there is no water in the fuel. the fuel gauge will completely go to low then come back up after about 10-15 miles. also, the air bag light will come on. when he takes vehicle to the dealer they usually go through the whole vehicle, specifically the electrical systems. the dealership tried but failed to fix these problems. had taken the vehicle to a variety of dealerships multiple times. the turbo, transmission and wiring was replaced. the dealer told the consumer that the vehicle had not been coded when he purchased it. *ak.0 person(s) were injured. 0 person(s) died.Mileage was 525 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in SANLEANDRO, CA. Original Owner. Vehicle was purchased on May 01, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:RWD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SOUTH SAN FRANCISCO FORD . DEALER'S CITY: SOUTH SAN FRANCISCO . DEALER'S STATE CODE: CA.

Ford F-550 2004 Air Bags Frontal Sensor/control Module

Ford F-550 2004 Air Bags Frontal Sensor/control Module Review #10132084

FORD F-550 2004 car safety problem was reported on July 01, 2004.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE . dt: the vehicle surged and accelerated on its own. this happened this has happened a t least 50 times or more. while driving 43 mph vehicle shut down. had to slam on the emergency brake and pull it to the curb. also, while driving at 38 mph or 1100 rpms there was vibration coming from the engine. it felt like it was coming right from consumer's feet. it felt like transmission disengaged. then, after 10-15 seconds it felt like it kicked back in. there was a loud pop when this happened. the vehicle was burning more fuel than it did when first purchased it. sometimes the water and fuel lights came on. the dealer told him that when this happened he should pull over. but when he does there is no water in the fuel. the fuel gauge will completely go to low then come back up after about 10-15 miles. also, the air bag light will come on. when he takes vehicle to the dealer they usually go through the whole vehicle, specifically the electrical systems. the dealership tried but failed to fix these problems. had taken the vehicle to a variety of dealerships multiple times. the turbo, transmission and wiring was replaced. the dealer told the consumer that the vehicle had not been coded when he purchased it. *ak.0 person(s) were injured. 0 person(s) died.Mileage was 525 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in SANLEANDRO, CA. Original Owner. Vehicle was purchased on May 01, 2004. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:RWD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SOUTH SAN FRANCISCO FORD . DEALER'S CITY: SOUTH SAN FRANCISCO . DEALER'S STATE CODE: CA.

Ford F-550 2004 Suspension Front

Ford F-550 2004 Suspension Front Review #10216260

FORD F-550 2004 car safety problem was reported on Jan 28, 2008.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with SUSPENSION:FRONT . 1. driver complained of noise in front end and poor handling of vehicle. after inspection it was found that the track bar mount on the spring pad was broken. 2. track bar mount broken. poor handling (wandering) of vehicle. 3. track bar mount was welded and boxed for added support. *cn.0 person(s) were injured. 0 person(s) died.Mileage was 25665 miles. Vehicle Identification Number (VIN):1FDAF57P04E. Ford F-550 2004 problem was reported in BETHEL, CT. Original Owner. Vehicle was purchased on Jan 20, 2004. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Ford F-550 2004 drive type:4WD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Ford F-550 2004 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 35 mph.

Ford F-550 2004 Fuel System, Diesel

Ford F-550 2004 Fuel System, Diesel Review #10250420

FORD F-550 2004 car safety problem was reported on Dec 01, 2008.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . currently own a 2004 ford f550 dump truck with the fuel tank delaminating. ford is not willing to accept responsibility for this failure. help !!! *tr.0 person(s) were injured. 0 person(s) died.Mileage was 35843 miles. Vehicle Identification Number (VIN):1FDAF56P94E. Ford F-550 2004 problem was reported in GILLETTE, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph.

Ford F-550 2004 Fuel System, Diesel Review #10254343

FORD F-550 2004 car safety problem was reported on Nov 17, 2008.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . november 2008, our ford truck broke down due to fuel problems. truck was towed in and fuel filter was checked. tiny silver flakes clogged the filter. mechanic alerted us that ford is having a problem with their fuel tank liners separating, and that they are not taking claim on it. truck filter was changed and it ran fine for about a month.. we pulled the fuel filter again only to find "flakes" in the filter again. searched on the internet showed countless people having the same problem, and having to dish out thousands in repair costs only to have it happen again to them. no replacement available on the market that will solve the problem for good, everyone is forced to buy fords replacement. also no one knows if this will result in failure of the fuel filter and injectors down the road after the warranty on these items runs out. *tr.0 person(s) were injured. 0 person(s) died.Mileage was 67000 miles. Vehicle Identification Number (VIN):1FDAF56P44E. Ford F-550 2004 problem was reported in FREDERICK, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Ford F-550 2004 Fuel System, Diesel Review #10259143

FORD F-550 2004 car safety problem was reported on Dec 12, 2008.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . i own two 2004 ford f-550 and one 2003 f-550 superduty trucks. interior fuel tank coating is de-laminating and rusting at around 100,000 miles. vehicles stop without any warning. silvery material in water separator and fuel filters. i know of several vehicle owners that have this same problem and ford will do nothing. my vehicles stop suddenly in heavy traffic and we were lucky no one was injured. i have replaced the 2003 and one 2004 tank assembly. other 2004 is showing silvery residue also. i know of a dealer in st louis mo., that has replaced many tanks for customers with the same problem. this is a defective tank coating and ford should be held responsible. it is my understanding they (ford) have known of this issue since 2005 and will do nothing. do people need to be hurt/killed before action is taken? is ford still making these tanks with the defective coating, if so they should be stopped asap before someone gets killed because a vehicle stalls without warning. there is a tsb on the fuel tank vent, my vehicles have been to ford dealers and this was never brought to my attention. do i have to always ask if there is a recall, tsb or whatever or am i at ford's mercy. smacks of a cover up and willful negligence. *tr.Mileage was 125000 miles. Vehicle Identification Number (VIN):1FDAF56FX3E. Ford F-550 2004 problem was reported in FT COLLINS, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph.

Ford F-550 2004 Engine And Engine Cooling

Ford F-550 2004 Engine And Engine Cooling Review #10285295

FORD F-550 2004 car safety problem was reported on Sept 24, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with ENGINE AND ENGINE COOLING . discovered my f550 superduty 6.0 diesel at 94000 miles with 8 months over its warranty had an exhaust leak coming from both sides of its 6.0 liter diesel engine exhaust manifolds. these fumes were coming into the passenger compartment at idle. at the same mileage, dealer discovered that engine had oil in coolant and that its entire passenger side injectors were malfunctioning along with the fuel pump and its regulator. excessive fuel in engine, running very lean could cause engine to cease while driving. dealer advised that oil in coolant is common for these engines and that this causes a other malfunctions such as head gaskets to go. the exhaust manifolds were repaired at approx. $1172. the other engine work was not repaired as of yet due to it costing approx. $4240. the head gasket work would cost another $6000. ford said it would not cover the repairs because i was the second owner. bbb complaint filed and in search for class action law suit to cover repairs only. *tr.Mileage was 94000 miles. Vehicle Identification Number (VIN):1FDAX57P84E. Ford F-550 2004 problem was reported in NEW FREEDOM, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph.

Ford F-550 2004 Fuel System, Diesel

Ford F-550 2004 Fuel System, Diesel Review #10285295

FORD F-550 2004 car safety problem was reported on Sept 24, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . discovered my f550 superduty 6.0 diesel at 94000 miles with 8 months over its warranty had an exhaust leak coming from both sides of its 6.0 liter diesel engine exhaust manifolds. these fumes were coming into the passenger compartment at idle. at the same mileage, dealer discovered that engine had oil in coolant and that its entire passenger side injectors were malfunctioning along with the fuel pump and its regulator. excessive fuel in engine, running very lean could cause engine to cease while driving. dealer advised that oil in coolant is common for these engines and that this causes a other malfunctions such as head gaskets to go. the exhaust manifolds were repaired at approx. $1172. the other engine work was not repaired as of yet due to it costing approx. $4240. the head gasket work would cost another $6000. ford said it would not cover the repairs because i was the second owner. bbb complaint filed and in search for class action law suit to cover repairs only. *tr.Mileage was 94000 miles. Vehicle Identification Number (VIN):1FDAX57P84E. Ford F-550 2004 problem was reported in NEW FREEDOM, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph.

Ford F-550 2004 Fuel System, Diesel Review #10329666

FORD F-550 2004 car safety problem was reported on May 07, 2010.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . we own a fleet of ford diesel engine trucks which continue to experience fuel delivery problems. the problem is engine cut-off and surging and hard starting. ford says not their problem and charges us. i don't think we have the only ones. toyota is not the only company not dealing with this problem. think only the government will make them fix it. *tr.Mileage was 74145 miles. Vehicle Identification Number (VIN):1FDAF56PX4E. Ford F-550 2004 problem was reported in DALLAS, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

Ford F-550 2004 Fuel System, Diesel Review #10347608

FORD F-550 2004 car safety problem was reported on Dec 15, 2007.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . tl* the contact owns a 2004 ford f-550 sd. the contact stated the vehicle would intermittently lose power when driving at various speeds. on one occasion that the failure occurred, the contact shut off the engine and when restarting, he was able to drive a very short distance before the failure recurred. the vehicle would not accelerate past 5 mph. the vehicle was taken to an authorized dealer where the contact was informed that the fuel pump, filters, fuel tank and eight fuel injectors would need to be replaced because the fuel tank was rusted. the manufacturer advised the failure occurred because the contact failed to keep the fuel tank full. the vehicle was not repaired. the failure mileage was 27,120 and the current mileage was approximately 46,000. .Mileage was 27120 miles. Vehicle Identification Number (VIN):1FDAF57P64E. Ford F-550 2004 problem was reported in BERLIN, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Ford F-550 2004 Power Train Driveline

Ford F-550 2004 Power Train Driveline Review #10374870

FORD F-550 2004 car safety problem was reported on Aug 17, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with POWER TRAIN:DRIVELINE . 04 ford f550 sd dump truck was bought new on 12/04.. in april 2005 transmission leaked fluid while in park and truck was towed to dealer. the dealer claimed cause of problem was due to loose bolts on trans case. transmission continued to slip but dealer could not find problem. february 2006, approximately 16,000 miles on truck, transmission completely fails. truck towed to dealership and new transmission installed. on june 2008 (approximately 56,000 miles) while driving on major highway, truck begins to lose power and black smoke pours out of muffler. the truck was driven to local dealership and diagnosed with a blown turbo. ford did not cover cost of repair. i paid $4,500.00 out of pocket to replace turbo. august 2009 (approximately 68,000 miles) again while driving on major highway, truck loses power and stalls. truck was towed to ford dealership and diagnosed with clogged injectors due to deteriorating gas tank. dealer advised me that all 8 injectors would have to be replaced and new fuel pump installed. the total cost of repairs would be $4,300.00 and it would not be covered by ford. i was incensed to say the least...after getting a second opinion, i paid an additional $475.00 and had the truck towed to another ford dealership which made the repairs without any cost to me. the fuel tank was not replaced even though it was the cause of the problem. i replaced the tank and paid $750.00 out of pocket...december 27, 2010 (96,000 miles) without warning, transmission begins to slip. i contacted the ford dealership that made the last repairs. i was told the transmission was out of warranty and would not be covered by ford. it would cost $4,200.00 to replace. i took truck to a local transmission repair shop and paid $3,000.00 to rebuild transmission. its obvious that ford does not back up their product. i will never buy another ford again!!!! *tr.Mileage was 68000 miles. Vehicle Identification Number (VIN):1FDAX56P94E. Ford F-550 2004 problem was reported in NEW BRUNSWICK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Ford F-550 2004 drive type:RWD. VEHICLE SPEED: 60 mph.

Ford F-550 2004 Fuel System, Diesel

Ford F-550 2004 Fuel System, Diesel Review #10374870

FORD F-550 2004 car safety problem was reported on Aug 17, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . 04 ford f550 sd dump truck was bought new on 12/04.. in april 2005 transmission leaked fluid while in park and truck was towed to dealer. the dealer claimed cause of problem was due to loose bolts on trans case. transmission continued to slip but dealer could not find problem. february 2006, approximately 16,000 miles on truck, transmission completely fails. truck towed to dealership and new transmission installed. on june 2008 (approximately 56,000 miles) while driving on major highway, truck begins to lose power and black smoke pours out of muffler. the truck was driven to local dealership and diagnosed with a blown turbo. ford did not cover cost of repair. i paid $4,500.00 out of pocket to replace turbo. august 2009 (approximately 68,000 miles) again while driving on major highway, truck loses power and stalls. truck was towed to ford dealership and diagnosed with clogged injectors due to deteriorating gas tank. dealer advised me that all 8 injectors would have to be replaced and new fuel pump installed. the total cost of repairs would be $4,300.00 and it would not be covered by ford. i was incensed to say the least...after getting a second opinion, i paid an additional $475.00 and had the truck towed to another ford dealership which made the repairs without any cost to me. the fuel tank was not replaced even though it was the cause of the problem. i replaced the tank and paid $750.00 out of pocket...december 27, 2010 (96,000 miles) without warning, transmission begins to slip. i contacted the ford dealership that made the last repairs. i was told the transmission was out of warranty and would not be covered by ford. it would cost $4,200.00 to replace. i took truck to a local transmission repair shop and paid $3,000.00 to rebuild transmission. its obvious that ford does not back up their product. i will never buy another ford again!!!! *tr.Mileage was 68000 miles. Vehicle Identification Number (VIN):1FDAX56P94E. Ford F-550 2004 problem was reported in NEW BRUNSWICK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Ford F-550 2004 drive type:RWD. VEHICLE SPEED: 60 mph.

Ford F-550 2004 Power Train Automatic Transmission

Ford F-550 2004 Power Train Automatic Transmission Review #10374870

FORD F-550 2004 car safety problem was reported on Aug 17, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . 04 ford f550 sd dump truck was bought new on 12/04.. in april 2005 transmission leaked fluid while in park and truck was towed to dealer. the dealer claimed cause of problem was due to loose bolts on trans case. transmission continued to slip but dealer could not find problem. february 2006, approximately 16,000 miles on truck, transmission completely fails. truck towed to dealership and new transmission installed. on june 2008 (approximately 56,000 miles) while driving on major highway, truck begins to lose power and black smoke pours out of muffler. the truck was driven to local dealership and diagnosed with a blown turbo. ford did not cover cost of repair. i paid $4,500.00 out of pocket to replace turbo. august 2009 (approximately 68,000 miles) again while driving on major highway, truck loses power and stalls. truck was towed to ford dealership and diagnosed with clogged injectors due to deteriorating gas tank. dealer advised me that all 8 injectors would have to be replaced and new fuel pump installed. the total cost of repairs would be $4,300.00 and it would not be covered by ford. i was incensed to say the least...after getting a second opinion, i paid an additional $475.00 and had the truck towed to another ford dealership which made the repairs without any cost to me. the fuel tank was not replaced even though it was the cause of the problem. i replaced the tank and paid $750.00 out of pocket...december 27, 2010 (96,000 miles) without warning, transmission begins to slip. i contacted the ford dealership that made the last repairs. i was told the transmission was out of warranty and would not be covered by ford. it would cost $4,200.00 to replace. i took truck to a local transmission repair shop and paid $3,000.00 to rebuild transmission. its obvious that ford does not back up their product. i will never buy another ford again!!!! *tr.Mileage was 68000 miles. Vehicle Identification Number (VIN):1FDAX56P94E. Ford F-550 2004 problem was reported in NEW BRUNSWICK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Ford F-550 2004 drive type:RWD. VEHICLE SPEED: 60 mph.

Ford F-550 2004 Engine And Engine Cooling Cooling System

Ford F-550 2004 Engine And Engine Cooling Cooling System Review #10374870

FORD F-550 2004 car safety problem was reported on Aug 17, 2009.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM . 04 ford f550 sd dump truck was bought new on 12/04.. in april 2005 transmission leaked fluid while in park and truck was towed to dealer. the dealer claimed cause of problem was due to loose bolts on trans case. transmission continued to slip but dealer could not find problem. february 2006, approximately 16,000 miles on truck, transmission completely fails. truck towed to dealership and new transmission installed. on june 2008 (approximately 56,000 miles) while driving on major highway, truck begins to lose power and black smoke pours out of muffler. the truck was driven to local dealership and diagnosed with a blown turbo. ford did not cover cost of repair. i paid $4,500.00 out of pocket to replace turbo. august 2009 (approximately 68,000 miles) again while driving on major highway, truck loses power and stalls. truck was towed to ford dealership and diagnosed with clogged injectors due to deteriorating gas tank. dealer advised me that all 8 injectors would have to be replaced and new fuel pump installed. the total cost of repairs would be $4,300.00 and it would not be covered by ford. i was incensed to say the least...after getting a second opinion, i paid an additional $475.00 and had the truck towed to another ford dealership which made the repairs without any cost to me. the fuel tank was not replaced even though it was the cause of the problem. i replaced the tank and paid $750.00 out of pocket...december 27, 2010 (96,000 miles) without warning, transmission begins to slip. i contacted the ford dealership that made the last repairs. i was told the transmission was out of warranty and would not be covered by ford. it would cost $4,200.00 to replace. i took truck to a local transmission repair shop and paid $3,000.00 to rebuild transmission. its obvious that ford does not back up their product. i will never buy another ford again!!!! *tr.Mileage was 68000 miles. Vehicle Identification Number (VIN):1FDAX56P94E. Ford F-550 2004 problem was reported in NEW BRUNSWICK, NJ. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Ford F-550 2004 drive type:RWD. VEHICLE SPEED: 60 mph.

Ford F-550 2004 Fuel System, Diesel

Ford F-550 2004 Fuel System, Diesel Review #10405893

FORD F-550 2004 car safety problem was reported on June 01, 2011.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with FUEL SYSTEM, DIESEL . tl*the contact owns a 1997 ford f-550 super duty. the contact stated the vehicle would stall while driving at various speeds. the vehicle was taken to an authorized dealer where the contact was informed the vehicle was stalling due to delamination of the fuel tank. the vehicle was not repaired. the failure mileage was unknown and the current mileage was 144,250..Vehicle Identification Number (VIN):1FDLE40F7VH. Ford F-550 2004 problem was reported in SAN ANTONIO, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Ford F-550 2004 Electrical System

Ford F-550 2004 Electrical System Review #10417113

FORD F-550 2004 car safety problem was reported on June 16, 2011.FORD F-550 2004, manufactured by FORD MOTOR COMPANY had a problem with ELECTRICAL SYSTEM . tl* the contact owns a 2004 ford f-550. the contact stated that the vehicle would not start. the dealer diagnosed that the fuel injector wire was melting on the engine. the vehicle was repaired and recurred. the manufacturer was notified, but denied any assistance with repairs. the failure mileage was 116,000 and the current mileage was 121,164. .Vehicle was on fire. Mileage was 116000 miles. Vehicle Identification Number (VIN):1FDAF57P74E. Ford F-550 2004 problem was reported in STAUNTON, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Air Bags Frontal Sensor/control Module 1 Review(s)

Electrical System 1 Review(s)

Electrical System Wiring 1 Review(s)

Engine And Engine Cooling 1 Review(s)

Engine And Engine Cooling Cooling System 1 Review(s)

Fuel System, Diesel 8 Review(s)

Fuel System, Other 1 Review(s)

Power Train Automatic Transmission 2 Review(s)

Power Train Driveline 1 Review(s)

Suspension Front 1 Review(s)

Vehicle Speed Control 1 Review(s)