Ford Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve)
Car-and-Safety.com | FORD>FORD Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve)
Ford Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Reports
16 Mar
FORD TEMPO 1989 | Purchase Car Used Had To replace the fuel pump three times and replaced motor mount one time and replaced the starter two times . |
FORD F150 1993 | The Pollution Control Valve Is defective, allowing exhaust gases to escape and be pulled into the truck's interior. *ak |
FORD AEROSTAR 1993 | Egr Valve Failed, Causing rough idle/hesitation upon acceleration. *ak |
FORD F150 1993 | Rear Fuel Tank When Full has a smell/odor, replaced valve. *ak |
FORD EXPLORER 1999 | Automatic Transmission Is Slipping In any gear. it doesn't shift gears correctly when accelerating. transmission only shifts correctly into 1st gear, |
FORD WINDSTAR 2000 | While Consumer Is Driving passenger's side door can come open without any assitence. consumer's child almost fell out of door. |
FORD FOCUS 2001 | While Driving 70 Mph Gas pedal fell to floor. consumer had no control over accelerator, there was a sound like an explosion |
FORD TAURUS 1999 | Egr Valve Malfunctioned. *ak |
FORD EXPEDITION 2000 | While Driving And Applying brakes vehicle continued to accelerate. to gain control engine was completely shut down. vehicle was taken |
FORD ESCORT 1995 | Consumer Has Replaced Ignition switch 3 times within 5 years. vehicle has caught on fire once from ignition, the day after |
FORD EXPLORER 1999 | Whenever Truck Is Driven there is a tapping noise coming from the engine. the explorer was taken to the dealership 3 |
FORD F 150 1998 | Due To Defective Throttle linkage and pcv valve, vehicle suddenly accelerated which may have caused a crash. please provide |
FORD F 150 1997 | Consumer Contacted Dealer In Reference to manufacturer's recall 98r04, concerning pcv system. however, this vehicle was not included in recall |
FORD PICKUP 1990 | Pvc System Was Faulty, causing abnormal temperature and pressure buildup which causes excessive stress on the piston rod and rod bearings. time consumed |
FORD SUPER DUTY 1996 | Received Recall Notice In the mail (#97v209000/97s92). had called or taken vehicle to 3 different dealerships. each one refused to do recall |
FORD ESCORT 1998 | The Defective Fuel Control Valve malfunctioned, causing fuel leakage and fuel smell which may cause a fire. dealer repl.aced valve twice. |
FORD F SUPER DUTY 1996 | Recall # 97v20900/ford/exhaust Gas Leak, owner not able to make contact with manufacturer to correct recall. the 800 number listed on the |
FORD WINDSTAR 1996 | The Defective Design Of The air intake valve located on the driver's side over the wheel well housing, water accumulated and clogged the air |
FORD EXPLORER 1997 | Recall 97v074000. The Dealer has no parts. *ak |
FORD FOCUS 2001 | Key Will Not Turn In ignition. took vehicle to dealer, and they replaced locking mechanism in steering column. *ak the |
FORD FOCUS 2000 | There Is A Very Bad squeaking noise when braking, and when consumer lets off the brake there is a grinding noise. driver |
FORD FOCUS 2000 | When Applying Brake Pedal It would go to the floor, also brakes will grind. rotors had to be turned, and brakes were |
FORD CONTOUR 1999 | Driver Was Traveling At 30 mph when another driver crossed in front of consumer, consumer hit the brakes, and rear |
FORD TAURUS 1993 | Consumer Stated The Head Gaskets are going bad again, vehicle was not running properly and coolant fluid was in the combustion chambers, had |
FORD MUSTANG 2000 | Egr Valve Failed. *yh |
FORD TAURUS 1995 | Egr Sensor Assembly Failed Causing check engine light to coming on. *et |
FORD TAURUS 1995 | Engine Motor Mounts Failed.also front engine main seal leaking/egr valve failed/ right rear disc brake caliper locked up, causing brake pads to wear |
FORD ESCAPE 2001 | Engine Has Stalled Twice While driving 40-50mph. sunroof motor had to be replaced. coolant recorvery jug had to be replaced. sensor |
FORD FOCUS 2001 | Have Had Numerous Problems With the car hesitating and stalling. have taken the car in a total of 7 times. 5 |
FORD CONTOUR 1995 | The Egr Valve, Egr gas regulator valve went bad. the shifting sensor went bad causing it to feel like the transmission was |
FORD FOCUS 2001 | My Vehicle Has Just Been turned into our dealership this morning, for the same repeated problem of engine check light coming on while driving |
FORD TAURUS 2001 | Fuel Odor Coming In Thru vents inside vehicle.odor noticed on start up ,,and after hot soak.cant find any fuel leaks.v-6 |
FORD CROWN VICTORIA 1995 | Headlight Lenses Constantly Turn Yellow and cloudy, power window regulator cables constantly snap, excessive play in steering wheel, horn buttons too small |
FORD ESCAPE 2001 | Engine Check Light Indicated That that egr sensor needed to be replaced. the dealer replaced this sensor and the egr pressure valve. |
FORD ESCORT 1997 | Engine Stalled At 55 Mph. after the repair the check engine light came on, and the dealer couldnt fix the problem with the |
FORD E 150 1998 | Engine Check Illuminates. brought to dealer four times, no problem found the first time, second time oxygen sensor and fuel filter |
FORD EXPLORER 1996 | Returned Vehicle To Dealer Many times complaining about brakes, he replaced one pad on one tire. says it was the only one worn, |
FORD EXPEDITION 1997 | In Idle The Engine Can not hold a smooth idle at 1400 rpm. the dealer service dept. claims it's the egr valve |
FORD EXPLORER 1995 | Firestone 7515 Garners Ferry Rd, cola sc 29209 did following repairs:05/22/00 alternator, 05/01/00 both rear calipers & drums, 02/15/00 eet/eec sensors, |
FORD CROWN VICTORIA 1988 | I Have Replaced The Egr valve ($77.29), tps ($29.89), had a diagnostic ($30.00), cap/rotor/plugs/wires replaced ($72.29), new |
FORD EXPLORER 1994 | Egr Valve Has Heat Rust and the air tube from the valve cracked, both have to be replaced |
FORD TAURUS 1996 | On Automatic Transmission We Were driving and engine check light came on and wouldn't go faster than 45, cam sensor, camshaft, died |
FORD CONTOUR 1997 | Hi, We Have Had so many problems i can't believe that ford dosen't recall the 97 contours.we only had the car 1 month |
FORD TAURUS 1994 | Egr Valve System Is Completly rebuilt, check engine light still comes on |
FORD CROWN VICTORIA 1995 | My Engine Check Light keeps going on. we have changed the pfe sensor, installed new egr sensor, and installed a |
FORD TEMPO 1993 | This Are Safety Recalls By nhtsa that ford motor company refuses to fix putting me and my family in danger! please help this car is |
FORD CONTOUR 1996 | Headlight Switch And Mount Failed/burned up/lights won't turn off/on, needed replacing, dashboard components always run hot; fuel door lever inside car doesn't |
FORD RANGER 1996 | At Least 12 Sets Of brakes put on vehicle"4 in uder 9000 miles, resulting in 2 accidents" 3 times at turning rotors/engine rebuilt |
FORD EXPLORER 1997 | Exhaust Gas Recirculation Valve Tube failed. *yc |
FORD ESCORT 1997 | Erg Connector Failed. Nlm |
FORD E 250 1996 | Egr Valve Failed. |
FORD ESCORT 1996 | Egr Sensor Assembly Failed. |
FORD EXPLORER 1996 | Egr Valve Failed. |
FORD TAURUS 1990 | The Egr Sensor Was Replaced. *slc |
FORD WINDSTAR 1996 | Manifold Gasket And Head Gasket failed causing the vehicle to use excessive amount of coolant and check engine light was illuminated injectors and egr ports |
FORD EXPLORER 1997 | Egr Valve Pipe Has A crack, consumer feels dealer should pay for this repair due to the number of miles on the vehicle. |
FORD WINDSTAR 1995 | Consumer Replaced Engine And Computer due to the manufacturer recall component failure dealing with head gaskets, manufacturer refused to cover this due to vehicle |
FORD MUSTANG 1999 | Egr Tube Replaced. *mjs |
FORD TAURUS 1993 | Egr Valve Failed. nlm |
FORD TAURUS 1991 | Ego Sensor And Mass Air flow sensor failed. nlm |
FORD EXPLORER 1996 | Egr Sensor/control Failed Causing Check engine light to come on. mjs |
FORD F 250 1996 | Egr Valve Replaced Causing Rough idle. mjs |
FORD EXPLORER 1996 | Egr Valve And Sensor Failed. nlm |
FORD TAURUS 1992 | Pcv Hose Ripped. |
FORD EXPLORER 1994 | Egr Sensor/hose Failed. |
FORD TAURUS 1992 | Pcv Valve Failed. |
FORD EXPLORER 1994 | Egr Sensor/hose Failed. |
FORD TEMPO 1992 | Egr Valve Failed. |
FORD F SUPER DUTY 1994 | Engine Failed Due To Failure of the recall component, however owner not notified prior to damage. (97s92). egr tube. (mjs) |
FORD MOTOR HOME 1995 | Egr Tube Recall Work Performed however after work done vehicle makes very loud noise. |
FORD ESCORT 1988 | Pcv Valve Failed. Nlm |
FORD ESCORT 1993 | Pressure Feedback Egr Sensor And egr vacuum reculator missing, never installed on vehicle. |
FORD AEROSTAR 1991 | Oxygen Sensor, Pcv Valve failed. |
FORD TEMPO 1992 | Pcv Recall Repair Not Done due to dealer refusal. |
FORD TAURUS 1994 | Egr Valve Failed, Causing engine ping. |
FORD TAURUS 1992 | Egr Valve Failed. |
FORD F150 1993 | Pcv Valve Failed. |
FORD FORD 9999 | Egr Valve Failed. |
FORD MUSTANG 1991 | Egr Plate Replaced. |
FORD F150 1989 | Egr Sensor Failed, Causing vehicle to stall. |
FORD MUSTANG 1991 | Check Engine Light Illuminated Until system is updated with new egr. |
FORD AEROSTAR 1989 | Replaced Emission Control Valve (pcv). *ak |
FORD CROWN VICTORIA 1991 | Egr Valve Replaced Due To malfunction. *sd |
FORD AEROSTAR 1986 | Egr Valve To Exhaust Mainfold bent, causing exhaust leak. (other vehicle on 479628) *skd |
FORD CROWN VICTORIA 1992 | Leak At Egr Valve. |
FORD CROWN VICTORIA 1990 | Intermittent Stalling Due To Egr valve failure (other vehicle from 486389). *ak |
FORD F 350 SD 2008 | 2008 Ford F350 Super Duty. attorney representing consumer writes in regards to engine problems, egr valves and high pressure fuel pumps failure |
FORD E 350 2006 | Tl* The Contact Owns A 2006 ford f-350. the contact stated that the egr valves malfunctioned and as a result, radiator fluid leaked |
FORD FREESTAR 2004 | 2004 Ford Freestar. Consumer states vehicles drives rough, stating vehicle accelerates and decelerates on its own *tgw the consumer stated the vehicle |
FORD F250 2004 | 2004 Ford F250. Consumer states faulty icp sensor or faulty egr valve *tgw the reverse planet gear in the transmission was replaced. |
FORD F 250 SD 2004 | 2004 Ford F-250 Sd. consumer requests assistance in helping obtain satisfactory attention and results related to recalls and repairs *tgw the consumer stated |
FORD F 250 SD 2004 | Tl* The Contact Owns A 2004 ford f-250 super duty. the contact stated while driving at an unknown speed, the vehicle stalled without |
FORD F 250 SD 2004 | Tl* The Contact Owns A 2004 ford f-250 super duty. the contact stated that the turbo component of the diesel engine failed. the |
FORD F 250 2005 | 2005 Ford F-250. Consumer states vehicle overheated and blew out white smoke while driving *tgw the consumer stated upon doing research, she |
FORD FREESTYLE 2006 | Tl*the Contact Owns A 2006 ford freestyle. the contact was driving approximately 5 mph in reverse into a residential garage. as the contact |
FORD F 250 SD 2004 | Tl*the Contact Owns A 2004 ford f-250 super duty. the contact stated that while driving 10 mph white smoke began to come from the |
FORD ESCORT 2001 | Tl* The Contact Owns A 2001 ford escort purchased april 2002. the rear coil springs, struts, and egr valve were placed at |
FORD FREESTYLE 2006 | Tl*the Contact Owns A 2006 ford freestyle. while backing out of the driveway, the vehicle accelerated when the brake pedal was depressed. |
FORD F 250 SD 2004 | Tl*the Contact Owns A 2004 ford f250 super duty. the contact stated that the egr cooler needed to be replaced three times. |
FORD F350 2004 | Tl*the Contact Owns A 2004 ford f350. the contact stated that smoke appeared from the egr cooler tube. she also smelled |
FORD F350 2004 | On 01-06-2008 I Started To have significant problems with my 2004 ford f-350. it has just over 41,000 miles on it. |
FORD F350 2004 | Tl*the Contact Owns A 2004 ford f350. while at a stop light, the engine would rev. depending on the contact's |
FORD FOCUS 2001 | Tl*the Contact Owns A 2001 ford focus. while driving 5 mph, the contact heard a popping noise coming from under the hood. |
FORD EXPLORER 2002 | My 2002 Ford Explorer Had a failed tube mounted "differential pressue feedback from egr" (dpfe) sensor after 30k miles. ford created a technical |
FORD ESCORT 1997 | 1997 Ford Escort Fuel Evaporative emission control system. purge control valve circuit malfunctioned. *jb |
FORD MUSTANG 2001 | 2001 Mustang 3.8 V6 (54,000 miles) was leaking exhaust from the passenger side of engine under hood causing exhaust fumes to come in |
FORD F350 2004 | Vehicle Had A Stalling Problem on accelleration. vehicle idled fine, but frequently on acceleration from a stop after vehicle started to roll. |
FORD E 350 2005 | 6.0 Power Stroke, many problems since new . purchased in aug, 05 *jb |
FORD EXPLORER 2002 | There Is Ford Tsb 02m01 and ntsb 10007207 for replacement of the egr sensor on 2002 ford explorers. the explorer needed that sensor |
FORD FOCUS 2002 | Exhaust Gas Return (egr) Line failed at exhaust manifold mounting flang . this failure allows carbon monoxide and carbon dioxide to seep |
FORD MUSTANG 2005 | 2005 Ford Mustang Fuel system, replaced due to system failure when filling car with gas, it broke again ford will not or |
FORD E 350 2005 | The Agency For Community Transit provides services for madison county mass transit district who is responsible for public transportation services in the madison county, |
FORD ESCAPE 2004 | 2004 Ford Escape, Consumer would like reimbursement for the catalytic converter. *kb front and rear catalytic converters plugged. the dealer |
FORD E 150 1995 | The Exhaust Gas Recirculation (egr) tube broke at the flexible section of the tube on my 1995 ford e-150 van with a 5.8l engine. |
FORD ESCAPE 2001 | I See More And More people are having problems of replacing the egr valve on their 2001 ford escape. i replaced mine twice |
FORD E 350 2004 | Oil Leaking From 2004 F-350 6.0l diesel engine. egr failure causing truck to shut off on road. *jb |
FORD MUSTANG CONVERTIBLE 2001 | I Have A 2001 Ford mustang v6 convertible. ford has a defect on their dpfe sensor for their emission egr flow. this is |
FORD F 250 SD 2004 | Consumer Had Egr Sensor Replaced. check engine light came on making vehicle feel like it was going to die. *ts the egr |
FORD F 150 2002 | Normal Every Day Use. service engine soon light turns on dpfe sensor and or egr valve has failed. from what i've researched in |
FORD EXPLORER 1999 | Dt: The Contact Owns A 1999 ford explorer. the contact called about the current nhtsa investigation dp05005 concerning the engine and |
FORD F250 2004 | Dt: The Consumer Stated that 2004 ford f250 intermittently on the road. this has happened about 20 times. the dealer |
FORD FOCUS 2001 | Dt: Contact Stated Car would not go over 60 mph. she took vehicle to a dealer, and they told |
FORD FOCUS 2001 | Dt: The Consumer's Daughter drove to austin texas, when she entered the vehicle the ignition would not turn. the consumer had |
FORD FORD 1999 | The Egr Vacuum Sensors And switches on the engine have had to be replaced twice on my 1999 ford explorer - once in 2002 and |
FORD F 250 SD 2004 | We Purchased A 2004 F250 turbo diesel from mike brown ford on may 29, 2004 and the nightmare began. the first problem the |
FORD TAURUS 2001 | Excessive Acceleration. I was going up a hill in dc traffic and could not stop accelerating. i had to put the |
FORD ESCAPE 2001 | Ford Escape 2001, Egr sensor failure. *bf the consumer wanted to know if the service bulletin applied to him, |
FORD FOCUS 2001 | After Starting The Vehicle Consumer smelled exhaust fumes inside/outside the vehicle. dealership repaired the gas recirculation valve (egr) valve. *ak |
FORD ESCAPE 2002 | The Engine Light In The consumer's 2002 ford escape illuminated. *nm the error code read p0401. ford released |
FORD ESCAPE 2001 | There Were Numerous Problems. the egr sensor (dpfe) was replaced along with the sop driver side outer belt molding, fuel pump, |
FORD F350 1993 | Exhaust Fumes Were Leaking into the cab of the vehicle. consumer contacted the dealer, who didn't think that this problem was important, |
FORD F250 SUPER DUTY 9999 | The Consumer Smelled Exhaust Fumes in the cab of the vehicle..the mechanic noticed the smell as well, however they stated it was |
FORD FOCUS 2000 | While Driving Vehicle Hesitated. dealership informed consumer that the problem was pertained to the failure of the egr valve. *ak |
FORD EXPLORER SPORT TRAC 2001 | Drove Home, Garbage Pick-up missed our house. grab the can ,and put in back of ford sport trac..tried to catch |
FORD FOCUS 2001 | Consumer Stated That Vehicle Surged/hesitated and stalled. she took the vehicle to the dealer, and they did not see any problem. |
FORD F 350 SD 2003 | Pickup Has Loss Of Power and surging mostly when warm. the first trip to freedom ford they replaced the egr valve. the second |
FORD TAURUS 2001 | I Own A 2001 Ford taurus the car won't shift into gear is this problem going to be recalled? 23,000 miles |
FORD ESCAPE 2002 | When Accelerating Or Decelerating vehicle hesitated and or stalled. recall 94v165000 was issued. however, vehicle's mileage prevented vehicle |
FORD TAURUS 1999 | When Applying Gas The Car shakes. and when you start the engine the car jumps.*ak |
FORD FOCUS 2001 | My 2001 Ford Focus Engine light came on a week or so ago, so i took it to autozone and had them check out |
FORD F350 2004 | While Driving, T He vehicle stalled several times. the consumer would restart the vehicle while in motion. the brakes would |
FORD FOCUS 2002 | Heat Shield Dropped While Driving on west ridge road causing sparks. it ruptured the fuel line which caused the fuel to spew all over |
FORD F 150 2001 | While Driving Vehicle stopped in the middle of traffic, and consumer could not restart it. the traffic was |
FORD WINDSTAR 1999 | I Bought This Car Used and from the day i drove it off the lot i have put a few thousand dollars in it. |
FORD F350 1993 | When The Vehicle Idled consumer smelled and heard exhaust leaking. dealer examined the vehicle, and found that the exhaust |
FORD EXPLORER 1997 | Egr Valve Failed At Cost of over $250. this is part of the emissions system and is covered by an extended warranty. |
FORD CONTOUR 1996 | I Don't Know If Any one there can help me, but i just want some one just hear my complaint. i purchase a |
FORD FOCUS 2000 | I Have Had Problems Ever since i bought my 2000 ford focus with all the recalls - i have had my brakes redone and here |
FORD F350 2003 | While Driving Vehicle Stalled. dealership indicated that this was due to a malfunction in the fuel injectors. the fuel injectors were |
FORD CONTOUR 1997 | I Believe All 1997 Ford contours should be recalled, over the past 3 years i have replaced the clutch, waterpump, blower motor, |
FORD EXPLORER SPORT TRAC 2001 | While Traveling From Williamsburg/new Port news, va my engine light came on and i pulled off the road to have the problem looked at. |
FORD FOCUS 2001 | Tire Problem, Possible Rear bearing problem, possible alignment problem, egr replaced- engine misfiring is beginning to reappear |
FORD WINDSTAR 1995 | Brake Light Come On Frequently. door ajar light stays on occasionally causing interior lights to remain on even when all doors are shut. |
FORD TAURUS 2002 | Auto: Ford Taurus 2002 With the ("ffe") "fuel flex engine" installed problem: car experiences "classic miss under load" or "hesitation" at constant speed |
FORD TAURUS 1997 | The "service Engine Soon" Light came on and was diagnosed at a local auto parts store with code 402 that showed excessive flow in the |
FORD FOCUS 2001 | On Several Occasions While Driving would feel nauseous and begin vomiting. manufacturer diagnosed problem with egr pressure sensor causing exhaust fumes to enter |
FORD MUSTANG 1994 | Gasket Blew On The Vehicle causing the engine to smoke. ph |
FORD F 150 2001 | The Egr System Warning Light appeared 2,000 miles outside of the warranty. scc |
FORD E 250 2001 | Consumer Purchased Vehicle New On 04/30/01. while driving on a daily basis, consumer would experience nausea, burning eyes, severe headaches |
FORD FOCUS 2000 | Throttle Is Sticky. Warranty is covering the problem. ts |
FORD F 150 2003 | We Purchased A 2003 Ford f150 supercrew fx4 in october of 2002. on december 2,2002 this vehicle lost control of it's brakes and |
FORD F 150 1997 | Consumer Called Complaining About Having problems with the head gaskets. also stated that went out to turn on the vehicle and white smoke came |
On This Page
- Select and View Ford Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Problems
- Discuss Ford Engine And Engine Cooling Exhaust System Emission Control Gas Recirculation Valve (egr Valve) Problems
my 95 ford exploere engine surges when turn my air conditioner on what would cause a 2000 ford expedition to roll after putting it in park with engine off. Any answers would greatly be appreciated. why does my rpm on my 1992 go high and low and why does my engine die when i stop i have a 1985 ford f150, i get warm air from the heater when the truck sits at an idle, but as soon as i start driving it goes ice cold changed out the heater core, thermostat, and did a back flush of system ANY IDEAS ? it's a 4 speed standard tra When I let up on the gas pedal the engine does not slow down on my 1999 ford taurus. What would the problem be.