Car-and-Safety.com

CHEVROLET K2500 Engine And Engine Cooling Engine Gasoline

CHEVROLET K2500 2002 Engine And Engine Cooling Engine Gasoline Report #8022536

CHEVROLET K2500 2002 car safety problem was reported on July 20, 2002.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with ENGINE AND ENGINE COOLING:ENGINE:GASOLINE . WHILE DRIVING THE VEHICLE AT 50MPH ENGINE WILL START LOOSING OR GAINING POWER. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS.Vehicle Identification Number (VIN):1GCHK24U92E. Chevrolet K2500 2002 problem was reported in HILLSBORO, NH. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Vehicle Speed Control

CHEVROLET K2500 2002 Vehicle Speed Control Report #8023176

CHEVROLET K2500 2002 car safety problem was reported on .CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with VEHICLE SPEED CONTROL . TRUCK WILL HAVE ERRATIC OPERATION WITH TRUCK NOT HOLDING SPEED WHEN CRUISE CONTROL IS USED. THE OWNER STATES THAT THE POWER MODULE INTERACTS WITH SPEED WITH SET SPEED 2 MPH SLOWER AFTER TRUCK IS ACCELLED. PLEASE DESCRIBE DETAILS TS.Chevrolet K2500 2002 problem was reported in DALLAS, TX. Vehicle was not using Cruise Control. FUEL TYPE: DIESEL. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 2 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Steering

CHEVROLET K2500 2002 Steering Report #770326

CHEVROLET K2500 2002 car safety problem was reported on Nov 28, 2002.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with STEERING . THE POWER STEERING PUMP FAILED CAUSING THE POWER STEERING AND BRAKE SYSTEMS TO FAIL AT THE SAME TIME. THE GARAGE STATED THAT THE POWER STEERING PUMP SHAFT BROKE. THEY REPLACED THE POWER STEERING PUMP. THE GARAGE SAID THAT THEY HAVE REPAIRED SEVERAL VEHICLES WITH THIS PROBLEM AND ARE STARTING TO SEE MORE OF THESE FAILURES. THE GARAGE DID A FINE JOB ON THE REPAIRS. HOWEVER, THIS COULD BE POTENTIALLY BE A VERY, VERY DANGEROUS SITUATION, ESPECIALLY IN HEAVY TRAFFIC OR AT HIGHER SPEEDS. THOUGHT YOU SHOULD BE MADE AWARE. SINCERELY, WILLIAM D. BOWERS DT.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GCHK29U52E. Chevrolet K2500 2002 problem was reported in HANCOCK, ME. Original Owner. Vehicle was purchased on 20020401. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Chevrolet K2500 2002 drive type:4WD. FUEL TYPE: GAS. VEHICLE SPEED: 20 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Fuel System, Gasoline Storage Tank Assembly

CHEVROLET K2500 2002 Fuel System, Gasoline Storage Tank Assembly Report #10042621

CHEVROLET K2500 2002 car safety problem was reported on .CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY . PROBLEMS WITH FUEL TANK ON 2002 K2500 SUBURBAN.*MR THE FUEL TANK SEAL SEPARATED FROM THE TANK WHICH CAUSED THE TANK TO LEAK. *NLM.Vehicle Identification Number (VIN):3GNGK26U62G. Chevrolet K2500 2002 problem was reported in CAMP PENDLETON, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Structure Body Tailgate

CHEVROLET K2500 2002 Structure Body Tailgate Report #10045812

CHEVROLET K2500 2002 car safety problem was reported on Aug 30, 2003.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with STRUCTURE:BODY:TAILGATE . MY DAUGHTER CLIMBED UP ON THE TAILGATE OF MY 2002 CHEVROLET PICK UP AND WAS STANDING UP WHEN THE CABLES BROKE. THE TAILGATE DROPPED AND SHE FELL TO THE GROUND LANDING ON HER TAIL BONE.SHE WAS NOT SERIOUSLY INJURED BUT WAS VERY STIFF AND SORE AND COULDNT HARDLY WALK FOR 3 DAYS.*AK.1 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GCHK29112E. Chevrolet K2500 2002 problem was reported in PRIOR LAKE, MN. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Turbo. FUEL TYPE: DIESEL. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: BELZERS CHEVROLET . DEALER'S CITY: LAKEVILLE . DEALER'S STATE CODE: MN.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Tires Tread/belt

CHEVROLET K2500 2002 Tires Tread/belt Report #10055092

CHEVROLET K2500 2002 car safety problem was reported on Jan 01, 2004.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with TIRES:TREAD/BELT . BLOWOUT OF BRIDGESTONE DUELLER AT 693, LT285/75R/16, DOT NO.EJLFCCB2501 CAUSING LOSS OF VEHICLE CONTROL AND $4,000.00 DAMAGE TO TRUCK. NEAR TOTAL LOSS OF VEHICLE CONTROL CAUSING VEHICLE TO LEAVE ROADWAY.*AK *MR.Vehicle was involved in a crash. 0 person(s) were injured. 0 person(s) died.Mileage was 22750 miles. Chevrolet K2500 2002 problem was reported in BURBANK, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Chevrolet K2500 2002 drive type:U. VEHICLE SPEED: 60 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Structure Body Tailgate Hinge And Attachments

CHEVROLET K2500 2002 Structure Body Tailgate Hinge And Attachments Report #10058826

CHEVROLET K2500 2002 car safety problem was reported on Oct 15, 2003.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS . THE CABLE ON ONE SIDE OF MY CHEVROLET PICKUP GATE BROKE CAUSING THE GATE TO FALL ONTO THE BUMPER. AFTER PURCHASING A NEW PAIR OF CABLES FROM THE DEALER I NOTICED THAT THE GATE WAS NOT PROPERLY ALIGNED CAUSING THE WEIGHT OF THE GATE TO BE PLACED ALL ON ONE CABLE. I ALERTED THE DEALERSHIP TO THIS PROBLEM WHICH THEY LOOKED AT AND SUGGESTED THAT I COULD MAKE SOME ADJUSTMENTS TO THE TAILGATE TO FIX THE PROBLEM. I TRIED TO MAKE AN ADJUSTMENT BUT COULD NOT GET ANY MOVEMENT IN THE TAILGATE SO I AM STILL DRIVING WITH THE PROBLEM.*AK.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GCHK24U42Z. Chevrolet K2500 2002 problem was reported in PRAIRIE VILLAGE, KS. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Power Train Automatic Transmission

CHEVROLET K2500 2002 Power Train Automatic Transmission Report #10073183

CHEVROLET K2500 2002 car safety problem was reported on Jan 19, 2004.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . VEHICLE CLUNKS WHEN SHIFTING BETWEEN GEARS AND WILL JUMP BETWEEN GEARS. WILL NOT SHIFT INTO OVERDRIVE UNTIL 65MPH OR A DISTANCE OF APPROXIMATELY 12 MILES. LOSS OF REVERSE. HAS BEEN TO DEALER UNDER WARRANTY TWICE AT MILEAGE OF 25,000 MILES..Mileage was 22198 miles. Vehicle Identification Number (VIN):1GCHK29UX2E. Chevrolet K2500 2002 problem was reported in BUTLER, PA. Original Owner. Vehicle was purchased on 20020729. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: TROY ALLEN . DEALER'S TELEPHONE NUMBER: 724 794 2240 . DEALER'S CITY: SLIPPERY ROCK . DEALER'S STATE CODE: PA. DEALER'S ZIPCODE: 16057 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Wheels Cap/cover/hub

CHEVROLET K2500 2002 Wheels Cap/cover/hub Report #10096104

CHEVROLET K2500 2002 car safety problem was reported on Oct 20, 2004.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with WHEELS:CAP/COVER/HUB . I DROVE MY TRUCK UNDER NORMAL DRIVING CONDITIONS; PRIMARILY COMMUTING TO AND FROM WORK (HIGHWAY MILES). AT ~ 66,000 MILES, FRONT LEFT HUB ASSEMBLY STARTED MAKING INTERMITTENT NOISE AND NOTICEABLE VIBRATION IN STEERING WHEEL. THE HUB/TIRE/WHEEL ASSEMBLY HAD NOTICEABLE AMOUNT OF PLAY WHEN I INSPECTED IT DURING A RECENT TIRE CHANGEOUT. ULTIMATELY, THE HUB ASSEMBLY INTERNALS FAILED AND THE LUBRICATION ESCAPED FROM THE SEAL. IT IS MY OPINION THAT IF LEFT UNCHECKED, THE HUB COULD LOSE ALL LUBRICATION AND EITHER FREEZE UP, FALL APART OR CATCH FIRE. IT IS NOT NORMAL FOR A HUB TO FAIL AFTER ONLY 68,000 MILES. DEALER CONFIRMS THIS BY TELLING ME THAT THEY'VE NOT SEEN MANY IF ANY 3/4 TON TRUCKS COME THROUGH WITH THIS TYPE OF PROBLEM. I SUSPECT THAT THE PART WAS DEFECTIVE FROM THE MANUFACTURER, BUT CANNOT PROVE THIS. I WOULD BE HAPPY TO LET THE NHTSA TAKE IT APART AND INSPECT IT AND HEAR OF THEIR CONCLUSION. I AM ALREADY OUT THE $400+ DOLLARS TO FIX THIS PROBLEM. CHEVROLET CUSTOMER "DIS-SERVICE" WOULD NOT ADMIT TO ANY RESPONSIBILITY WHEN I OFFERED TO MEET THEM "HALF-WAY" AND PAY FOR THE LABOR IF THEY WOULD PAY FOR THE PART. IF THE NHTSA WOULD LIKE TO INSPECT THE PART, PLEASE FEEL FREE TO CONTACT ME. THANK YOU FOR YOUR WEBSITE. I HOPE NO ONE ELSE HAS THE SAME PROBLEM AS I'VE HAD (WITH MY TRUCK AND GM). THANKS FOR YOUR TIME AND FEEDBACK! .Mileage was 66000 miles. Vehicle Identification Number (VIN):1GCHK23162F. Chevrolet K2500 2002 problem was reported in KNOXVILLE, TN. Original Owner. Vehicle was purchased on 20020715. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: DIESEL. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 65 mph. DEALER'S NAME: BEATY CHEVROLET . DEALER'S TELEPHONE NUMBER: 865-693-1952 . DEALER'S CITY: KNOXVILLE . DEALER'S STATE CODE: TN. DEALER'S ZIPCODE: 37922 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic Antilock

CHEVROLET K2500 2002 Service Brakes, Hydraulic Antilock Report #10105676

CHEVROLET K2500 2002 car safety problem was reported on June 22, 2003.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:ANTILOCK . BRAKES FAILED TO STOP THE TRUCK (BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR IN AN EMERGENCY SITUATION) I TOOK THE TRUCK BACK TO THE DEALER AND THEY FOUND THE HYDRO BOOST TO THE BRAKES TO BE LEAKING FLIUD. THEY REPLACED THE PART, IT HELPED THE BRAKES SOME BUT DID NOT TAKE CARE OF THE PROBLEM. THE PROBLEM IS WHEN YOU ARE ON A POTHOLE OR WASHBOARD ROAD AND USE THE BRAKES THE PEDAL WILL GO ALL THE WAY TO THE FLOOR AND WILL NOT STOP THE TRUCK AT ALL. WHEN YOU STOP ON A SMOOTH ROAD THE BRAKES SEEM TO WORK FINE. TTHE ONLY OTHER THING THAT IS A REAL CONCERN TO ME IS WHEN YOU ARE JUST SITTING IN THE TRUCK WETHER IT IS RUNNING OR NOT YOU CAN PUSH ON THE BRAKE PEDAL WITH LITTLE EFFORT AND IT WILL GO ALL THE WAY TO THE FLOOR. I HAVE TAKEN THE TRUCK TO TWO DIFFERENT DEALERS TO TRY AND GET MY PROBLEM SOLVED. THE MECHANICS AGREE THAT IT SHOULDN'T DO WHAT ITS DOING BUT CAN'T FIND THE PROBLEM. THERE ARE TIMES WHEN IT IS DARGEROUS TO DRIVE THE TRUCK . *AK.Vehicle was involved in a crash. 1 person(s) were injured. 0 person(s) died.Mileage was 35500 miles. Vehicle Identification Number (VIN):1GCHK24U92E. Chevrolet K2500 2002 problem was reported in ODESSA, NY. Vehicle was purchased on 20030607. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 30 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Visibility Defroster/defogger System Windshield Controls/wiring

CHEVROLET K2500 2002 Visibility Defroster/defogger System Windshield Controls/wiring Report #10106109

CHEVROLET K2500 2002 car safety problem was reported on Oct 01, 2003.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:CONTROLS/WIRING . THE DEFROSTER KICKES ON IN THE MIDDLE OF DRIVING, SINCE I GOT THIS TRUCK. I WILL BE DRIVING DOWN THE RD, AND ALL OF THE SUDDEN MY WINDSHIELD FOGGES UP VERY RAPIDLY. LAST TIME, A SEMI WAS BEHIND US AND MY WIFE AND SON WERE WITH ME. WE WERE ALMOST KILLED!!!MY WARRANTY WAS VERY SHORT LIVED SINCE THIS WAS USED WHEN I BOUGH IT. MY WIFE, AND SON ALSO DRIVE CHEVYS & GMC.I HAVE TAKEN IT TO DEALERS BUT THEY SAY I HAVE TO PAY 100'S OF DOLLARS TO REPAIR IT, THEN IT MAY NOT BE REPAIRABLE THAT IT IS AUTOMATIC. WE WILL NEVER BUY GMC OR CHEVY AGAIN. IT ISNT EVEN SAFE TO DRIVE IN THIS VEHICLE!IT HAPPENS ALL THE TIME!*AK.0 person(s) were injured. 0 person(s) died.Mileage was 31000 miles. Vehicle Identification Number (VIN):1GCHK29U52E. Chevrolet K2500 2002 problem was reported in DECATUR, MI. Vehicle was purchased on 20030609. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 20 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Tires Tread/belt

CHEVROLET K2500 2002 Tires Tread/belt Report #10115835

CHEVROLET K2500 2002 car safety problem was reported on Mar 01, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with TIRES:TREAD/BELT . CHEVROLET K2500 2002, BRIDGESTONE DUELLER A/T TIRE DAMAGED THE VEHICLE. *BF *JB.Vehicle Identification Number (VIN):1GCHK23492F. Chevrolet K2500 2002 problem was reported in FRIENDSWOOD, TX. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Power Train

CHEVROLET K2500 2002 Power Train Report #10129475

CHEVROLET K2500 2002 car safety problem was reported on Jan 14, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN . SOME TIMES WHEN I START MY 2500 HD CHEVROLET SILVERODO 4WD EXTENDED CAB TRUCK THE SERVICE 4WD INDICATER COMES ON AND WHEN I GO TO THE DEALER THEY TELL ME THEY DONT KNOW WHAT IT IS. IM THINKIN THAT ITS FALTY WIRING. IT ALSO MAKES AN AWFULE TICKING SOUND RIGHT WHEN I START IT TOO. ALL THE TIME..Chevrolet K2500 2002 problem was reported in PLEASANT HILL, MO. Vehicle was purchased on 20041116. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: DON KAHAN CHEVROLET . DEALER'S CITY: LEE'S SUMMIT . DEALER'S STATE CODE: MO.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Parking Brake

CHEVROLET K2500 2002 Parking Brake Report #10132114

CHEVROLET K2500 2002 car safety problem was reported on Aug 08, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with PARKING BRAKE . I OWN A 2002 CHEV K2500HD. I HAVE HAD SEVERAL PROBLEMS, BUT WAS UNAWARE OF THIS SITE TO REPORT THESE PROBLEMS UNTIL NOW. FIRST, THE DRYER SWITCH ON THE AC WENT BAD @ 34K. SECOND,@ 65K I HAD TO REPLACE THE FRONT LEFT WHEEL HUB ASSEMBLY AS TALKED ABOUT IN ONE OF THE OTHER COMPLAINTS I READ. THIRD, @ 95K MY TRANSFER CASE DEVELOPED A LEAK AND I LOST ALL THE FLUID. A CHEVROLET MECHANIC SHOWED ME A TRANSFER CASE THAT HAD GONE BAD DUE TO THE SAME PROBLEM AND HAD BEEN USED IN 4WD W/OUT FLUID IN IT. ANOTHER CHEVROLET MECHANIC TOLD ME HE HAD SEEN SEVERAL OF THESE AND THAT "JB WELD IS YOUR FRIEND". SO I PATCHED THE HOLE, AND 10K LATER IT DEVELOPED A SECOND LEAK IN A SIMILAR LOCATION AND ALSO ABOUT THIS SAME TIME AN ELECTRICAL PART (ABOUT $550) WENT OUT FOR MY 4WD. NOW AT 130K IT HAS DEVELOPED A THIRD LEAK! ALSO STARTING @ APPROXIMATELY 50K, MY REAR DIFFERENTIAL HAS LOCKED UP ON ME SEVERAL TIMES AND I HAVE HAD TO REPLACE 4 CABLES ON MY TAILGATE. AFTER BEING A CHEVY MAN ALL MY LIFE I THINK I WILL LOOK AT TOYOTA. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 34000 miles. Vehicle Identification Number (VIN):1GCHK23U42F. Chevrolet K2500 2002 problem was reported in MARKHAM, TX. Original Owner. Vehicle was purchased on 20021014. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: BAY CITY CHEVROLET . DEALER'S CITY: BAY CITY . DEALER'S STATE CODE: TX.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Power Train Transfer Case (4-wheel Drive)

CHEVROLET K2500 2002 Power Train Transfer Case (4-wheel Drive) Report #10132114

CHEVROLET K2500 2002 car safety problem was reported on Aug 08, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . I OWN A 2002 CHEV K2500HD. I HAVE HAD SEVERAL PROBLEMS, BUT WAS UNAWARE OF THIS SITE TO REPORT THESE PROBLEMS UNTIL NOW. FIRST, THE DRYER SWITCH ON THE AC WENT BAD @ 34K. SECOND,@ 65K I HAD TO REPLACE THE FRONT LEFT WHEEL HUB ASSEMBLY AS TALKED ABOUT IN ONE OF THE OTHER COMPLAINTS I READ. THIRD, @ 95K MY TRANSFER CASE DEVELOPED A LEAK AND I LOST ALL THE FLUID. A CHEVROLET MECHANIC SHOWED ME A TRANSFER CASE THAT HAD GONE BAD DUE TO THE SAME PROBLEM AND HAD BEEN USED IN 4WD W/OUT FLUID IN IT. ANOTHER CHEVROLET MECHANIC TOLD ME HE HAD SEEN SEVERAL OF THESE AND THAT "JB WELD IS YOUR FRIEND". SO I PATCHED THE HOLE, AND 10K LATER IT DEVELOPED A SECOND LEAK IN A SIMILAR LOCATION AND ALSO ABOUT THIS SAME TIME AN ELECTRICAL PART (ABOUT $550) WENT OUT FOR MY 4WD. NOW AT 130K IT HAS DEVELOPED A THIRD LEAK! ALSO STARTING @ APPROXIMATELY 50K, MY REAR DIFFERENTIAL HAS LOCKED UP ON ME SEVERAL TIMES AND I HAVE HAD TO REPLACE 4 CABLES ON MY TAILGATE. AFTER BEING A CHEVY MAN ALL MY LIFE I THINK I WILL LOOK AT TOYOTA. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 34000 miles. Vehicle Identification Number (VIN):1GCHK23U42F. Chevrolet K2500 2002 problem was reported in MARKHAM, TX. Original Owner. Vehicle was purchased on 20021014. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: BAY CITY CHEVROLET . DEALER'S CITY: BAY CITY . DEALER'S STATE CODE: TX.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Latches/locks/linkages Tailgate Latch

CHEVROLET K2500 2002 Latches/locks/linkages Tailgate Latch Report #10132114

CHEVROLET K2500 2002 car safety problem was reported on Aug 08, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH . I OWN A 2002 CHEV K2500HD. I HAVE HAD SEVERAL PROBLEMS, BUT WAS UNAWARE OF THIS SITE TO REPORT THESE PROBLEMS UNTIL NOW. FIRST, THE DRYER SWITCH ON THE AC WENT BAD @ 34K. SECOND,@ 65K I HAD TO REPLACE THE FRONT LEFT WHEEL HUB ASSEMBLY AS TALKED ABOUT IN ONE OF THE OTHER COMPLAINTS I READ. THIRD, @ 95K MY TRANSFER CASE DEVELOPED A LEAK AND I LOST ALL THE FLUID. A CHEVROLET MECHANIC SHOWED ME A TRANSFER CASE THAT HAD GONE BAD DUE TO THE SAME PROBLEM AND HAD BEEN USED IN 4WD W/OUT FLUID IN IT. ANOTHER CHEVROLET MECHANIC TOLD ME HE HAD SEEN SEVERAL OF THESE AND THAT "JB WELD IS YOUR FRIEND". SO I PATCHED THE HOLE, AND 10K LATER IT DEVELOPED A SECOND LEAK IN A SIMILAR LOCATION AND ALSO ABOUT THIS SAME TIME AN ELECTRICAL PART (ABOUT $550) WENT OUT FOR MY 4WD. NOW AT 130K IT HAS DEVELOPED A THIRD LEAK! ALSO STARTING @ APPROXIMATELY 50K, MY REAR DIFFERENTIAL HAS LOCKED UP ON ME SEVERAL TIMES AND I HAVE HAD TO REPLACE 4 CABLES ON MY TAILGATE. AFTER BEING A CHEVY MAN ALL MY LIFE I THINK I WILL LOOK AT TOYOTA. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 34000 miles. Vehicle Identification Number (VIN):1GCHK23U42F. Chevrolet K2500 2002 problem was reported in MARKHAM, TX. Original Owner. Vehicle was purchased on 20021014. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: BAY CITY CHEVROLET . DEALER'S CITY: BAY CITY . DEALER'S STATE CODE: TX.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Fuel System, Gasoline Fuel Injection System Injectors

CHEVROLET K2500 2002 Fuel System, Gasoline Fuel Injection System Injectors Report #10132114

CHEVROLET K2500 2002 car safety problem was reported on Aug 08, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS . I OWN A 2002 CHEV K2500HD. I HAVE HAD SEVERAL PROBLEMS, BUT WAS UNAWARE OF THIS SITE TO REPORT THESE PROBLEMS UNTIL NOW. FIRST, THE DRYER SWITCH ON THE AC WENT BAD @ 34K. SECOND,@ 65K I HAD TO REPLACE THE FRONT LEFT WHEEL HUB ASSEMBLY AS TALKED ABOUT IN ONE OF THE OTHER COMPLAINTS I READ. THIRD, @ 95K MY TRANSFER CASE DEVELOPED A LEAK AND I LOST ALL THE FLUID. A CHEVROLET MECHANIC SHOWED ME A TRANSFER CASE THAT HAD GONE BAD DUE TO THE SAME PROBLEM AND HAD BEEN USED IN 4WD W/OUT FLUID IN IT. ANOTHER CHEVROLET MECHANIC TOLD ME HE HAD SEEN SEVERAL OF THESE AND THAT "JB WELD IS YOUR FRIEND". SO I PATCHED THE HOLE, AND 10K LATER IT DEVELOPED A SECOND LEAK IN A SIMILAR LOCATION AND ALSO ABOUT THIS SAME TIME AN ELECTRICAL PART (ABOUT $550) WENT OUT FOR MY 4WD. NOW AT 130K IT HAS DEVELOPED A THIRD LEAK! ALSO STARTING @ APPROXIMATELY 50K, MY REAR DIFFERENTIAL HAS LOCKED UP ON ME SEVERAL TIMES AND I HAVE HAD TO REPLACE 4 CABLES ON MY TAILGATE. AFTER BEING A CHEVY MAN ALL MY LIFE I THINK I WILL LOOK AT TOYOTA. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 34000 miles. Vehicle Identification Number (VIN):1GCHK23U42F. Chevrolet K2500 2002 problem was reported in MARKHAM, TX. Original Owner. Vehicle was purchased on 20021014. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: BAY CITY CHEVROLET . DEALER'S CITY: BAY CITY . DEALER'S STATE CODE: TX.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Power Train Driveline Differential Unit

CHEVROLET K2500 2002 Power Train Driveline Differential Unit Report #10132114

CHEVROLET K2500 2002 car safety problem was reported on Aug 08, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT . I OWN A 2002 CHEV K2500HD. I HAVE HAD SEVERAL PROBLEMS, BUT WAS UNAWARE OF THIS SITE TO REPORT THESE PROBLEMS UNTIL NOW. FIRST, THE DRYER SWITCH ON THE AC WENT BAD @ 34K. SECOND,@ 65K I HAD TO REPLACE THE FRONT LEFT WHEEL HUB ASSEMBLY AS TALKED ABOUT IN ONE OF THE OTHER COMPLAINTS I READ. THIRD, @ 95K MY TRANSFER CASE DEVELOPED A LEAK AND I LOST ALL THE FLUID. A CHEVROLET MECHANIC SHOWED ME A TRANSFER CASE THAT HAD GONE BAD DUE TO THE SAME PROBLEM AND HAD BEEN USED IN 4WD W/OUT FLUID IN IT. ANOTHER CHEVROLET MECHANIC TOLD ME HE HAD SEEN SEVERAL OF THESE AND THAT "JB WELD IS YOUR FRIEND". SO I PATCHED THE HOLE, AND 10K LATER IT DEVELOPED A SECOND LEAK IN A SIMILAR LOCATION AND ALSO ABOUT THIS SAME TIME AN ELECTRICAL PART (ABOUT $550) WENT OUT FOR MY 4WD. NOW AT 130K IT HAS DEVELOPED A THIRD LEAK! ALSO STARTING @ APPROXIMATELY 50K, MY REAR DIFFERENTIAL HAS LOCKED UP ON ME SEVERAL TIMES AND I HAVE HAD TO REPLACE 4 CABLES ON MY TAILGATE. AFTER BEING A CHEVY MAN ALL MY LIFE I THINK I WILL LOOK AT TOYOTA. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 34000 miles. Vehicle Identification Number (VIN):1GCHK23U42F. Chevrolet K2500 2002 problem was reported in MARKHAM, TX. Original Owner. Vehicle was purchased on 20021014. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: BAY CITY CHEVROLET . DEALER'S CITY: BAY CITY . DEALER'S STATE CODE: TX.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic Foundation Components Disc Rotor

CHEVROLET K2500 2002 Service Brakes, Hydraulic Foundation Components Disc Rotor Report #10132789

CHEVROLET K2500 2002 car safety problem was reported on Aug 02, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR . I HAVE A 2002 CHEVROLET 2500 4X4. I NOTICED THE REAR BRAKES WERE GETTING VERY HOT. I PULLED THE REAR WHEELS AND NOTICED THE ROTORS HAD RUST PITS IN THEM WHICH I BELIEVE CAUSED THE BRAKE PADS TO WEAR PREMATURELY. THE FRONT PADS AND ROTORS ARE FINE. I HAD THE REAR ROTORS MACHINED AND REPLACED THE BRAKE PADS. *NM.0 person(s) were injured. 0 person(s) died.Mileage was 64000 miles. Vehicle Identification Number (VIN):1GCHK24U92E. Chevrolet K2500 2002 problem was reported in GUILDERLAND CENTER, NY. Original Owner. Vehicle was purchased on 20020515. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: DENOOYER CHEVROLET . DEALER'S CITY: ALBANY . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 12208 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Electrical System Ignition

CHEVROLET K2500 2002 Electrical System Ignition Report #10135343

CHEVROLET K2500 2002 car safety problem was reported on Aug 22, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:IGNITION . 2002 CHEVROLET 2500HD W/ 8.1L GASOLINE ENGINE: THE FAILURE OF THE CRANKSHAFT POSITION SENSOR ON THESE ENGINES APPEARS TO BE A VERY COMMON PROBLEM. THIS SENSOR FAILED ON MY TRUCK AT ONLY 30K MILES! I KNOW OF TWO OTHER '02 TRUCKS W/ THIS ENGINE THAT ALSO HAD THE SENSOR FAIL AND MANY OTHERS HAVE BEEN DISCOVERED WHILE DOING RESEARCH ON THIS PROBLEM! THE SERIOUSNESS OF THE PROBLEM LIES IN THE FACT THAT THE TRUCK SUDDENLY STOPS RUNNING FOR NO REASON AND YOU LOSE ALL POWER FOR THE BRAKES AND STEERING. AT TIMES IT WILL RESTART WITHOUT ANY PROBLEMS ONCE YOU SHIFT TO NEUTRAL, BUT OTHER TIMES IT MAY NOT RESTART FOR A DAY OR MORE. THIS WAS A HUGE SAFETY ISSUE FOR ME SINCE I TOW A 10K LBS. FIFTH-WHEEL WITH THE TRUCK! MY TRUCK STOPPED RUNNING FOUR TIMES OVER THE COURSE OF TWO WEEKS AS A RESULT OF THIS PROBLEM. EVERYTIME WAS WHILE TRAVELING IN TRAFFIC, WITH ONLY ONE OF THE TIMES WHILE BEING STOPPED AT A LIGHT! MY TRUCK IS NO LONGER UNDER WARRANTY DUE TO THE TIME LIMIT OF 36 MONTHS EXPIRING. TO HAVE SUCH A PART FAIL WITH ONLY 30K MILES ON THE ENGINE IS OUTRAGEOUS. ONE OF THE OTHER TRUCKS I KNOW OF HAD THE SENSOR FAIL AROUND 55K MILES. SAME PROBLEM, IT WOULD JUST STOP IN TRAFFIC OR WHEN PULLING OUT OF A LIGHT OR STOPPED TURN. AGAIN, A HUGE SAFETY ISSUE!!! THE COSTS TO ME TO REPAIR MY TRUCK FOLLOW: AC DELCO REPLACEMENT CRANKSHAFT SENSOR - $69.26 TOW CHARGES TO TOW TO JOSEPH CHEVROLET, CINCINNATI, OH - $58.85 LABOR DUE TO THE ORIGINAL SENSOR BREAKING IN THE BLOCK! - $336.54 TOTAL COST TO REPLACE THE SENSOR AFTER ONLY 30K MILES! = $464.65 AGAIN, I HAVE TO REPEAT HOW LARGE A SAFETY ISSUE THIS IS ON THESE TRUCKS!!! THE ENGINE JUST STOPS FOR NO REASON AT ANY TIME, HIGHWAY, SLOW MOVING, STOPPED, ETC. IT MAY RESTART, BUT THEN AGAIN IT MAY NOT FOR MANY HOURS! THE TRUCKS WITH THESE ENGINES IN THEM ARE GENERALLY TOWING LARGE TRAILERS BEHIND THEM. THIS COMPOUNDS THE SAFETY ASPECT OF THE PROBLEM. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 30889 miles. Vehicle Identification Number (VIN):1GCHK23G82F. Chevrolet K2500 2002 problem was reported in CINCINNATI, OH. Vehicle was purchased on 20031021. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 35 mph. DEALER'S NAME: JOSEPH CHEVROLET . DEALER'S TELEPHONE NUMBER: 5137416700 . DEALER'S CITY: CINCINNATI . DEALER'S STATE CODE: OH. DEALER'S ZIPCODE: 45251 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Engine And Engine Cooling

CHEVROLET K2500 2002 Engine And Engine Cooling Report #10135343

CHEVROLET K2500 2002 car safety problem was reported on Aug 22, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with ENGINE AND ENGINE COOLING . 2002 CHEVROLET 2500HD W/ 8.1L GASOLINE ENGINE: THE FAILURE OF THE CRANKSHAFT POSITION SENSOR ON THESE ENGINES APPEARS TO BE A VERY COMMON PROBLEM. THIS SENSOR FAILED ON MY TRUCK AT ONLY 30K MILES! I KNOW OF TWO OTHER '02 TRUCKS W/ THIS ENGINE THAT ALSO HAD THE SENSOR FAIL AND MANY OTHERS HAVE BEEN DISCOVERED WHILE DOING RESEARCH ON THIS PROBLEM! THE SERIOUSNESS OF THE PROBLEM LIES IN THE FACT THAT THE TRUCK SUDDENLY STOPS RUNNING FOR NO REASON AND YOU LOSE ALL POWER FOR THE BRAKES AND STEERING. AT TIMES IT WILL RESTART WITHOUT ANY PROBLEMS ONCE YOU SHIFT TO NEUTRAL, BUT OTHER TIMES IT MAY NOT RESTART FOR A DAY OR MORE. THIS WAS A HUGE SAFETY ISSUE FOR ME SINCE I TOW A 10K LBS. FIFTH-WHEEL WITH THE TRUCK! MY TRUCK STOPPED RUNNING FOUR TIMES OVER THE COURSE OF TWO WEEKS AS A RESULT OF THIS PROBLEM. EVERYTIME WAS WHILE TRAVELING IN TRAFFIC, WITH ONLY ONE OF THE TIMES WHILE BEING STOPPED AT A LIGHT! MY TRUCK IS NO LONGER UNDER WARRANTY DUE TO THE TIME LIMIT OF 36 MONTHS EXPIRING. TO HAVE SUCH A PART FAIL WITH ONLY 30K MILES ON THE ENGINE IS OUTRAGEOUS. ONE OF THE OTHER TRUCKS I KNOW OF HAD THE SENSOR FAIL AROUND 55K MILES. SAME PROBLEM, IT WOULD JUST STOP IN TRAFFIC OR WHEN PULLING OUT OF A LIGHT OR STOPPED TURN. AGAIN, A HUGE SAFETY ISSUE!!! THE COSTS TO ME TO REPAIR MY TRUCK FOLLOW: AC DELCO REPLACEMENT CRANKSHAFT SENSOR - $69.26 TOW CHARGES TO TOW TO JOSEPH CHEVROLET, CINCINNATI, OH - $58.85 LABOR DUE TO THE ORIGINAL SENSOR BREAKING IN THE BLOCK! - $336.54 TOTAL COST TO REPLACE THE SENSOR AFTER ONLY 30K MILES! = $464.65 AGAIN, I HAVE TO REPEAT HOW LARGE A SAFETY ISSUE THIS IS ON THESE TRUCKS!!! THE ENGINE JUST STOPS FOR NO REASON AT ANY TIME, HIGHWAY, SLOW MOVING, STOPPED, ETC. IT MAY RESTART, BUT THEN AGAIN IT MAY NOT FOR MANY HOURS! THE TRUCKS WITH THESE ENGINES IN THEM ARE GENERALLY TOWING LARGE TRAILERS BEHIND THEM. THIS COMPOUNDS THE SAFETY ASPECT OF THE PROBLEM. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 30889 miles. Vehicle Identification Number (VIN):1GCHK23G82F. Chevrolet K2500 2002 problem was reported in CINCINNATI, OH. Vehicle was purchased on 20031021. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 35 mph. DEALER'S NAME: JOSEPH CHEVROLET . DEALER'S TELEPHONE NUMBER: 5137416700 . DEALER'S CITY: CINCINNATI . DEALER'S STATE CODE: OH. DEALER'S ZIPCODE: 45251 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Steering Hydraulic Power Assist Pump

CHEVROLET K2500 2002 Steering Hydraulic Power Assist Pump Report #10137597

CHEVROLET K2500 2002 car safety problem was reported on Sept 25, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with STEERING:HYDRAULIC POWER ASSIST:PUMP . DT: WHILE DRIVING AT ABOUT 60 MPH AND THE CONSUMER STOPPED TO PERFORM A TURN. AFTER COMPLETING THE TURN THERE WAS A LOSS OF BRAKES AND POWER STEERING. THE CONSUMER WAS ABLE TO DRIVE HOME. THIS HAPPENED WITHOUT WARNING, NO PREVIOUS OCCURRENCES. THE CONSUMER SELF DIAGNOSED THE ISSUE AS WITH THE POWER STEERING PUMP. THE CONSUMER TOOK APART THE POWER STEERING PUMP, AND THE DRIVESHAFT OF THE POWER STEERING PUMP WAS BROKEN . THE CONSUMER FELT THIS MAY BE DUE TO POOR CASTING OR UNDERSIZED IN DESIGN. THE CONSUMER HAS NOT REPLACED THIS AT THIS TIME. THE CONSUMER CONTACTED BOTH THE GM DEALER AND MANUFACTURER. THEY WERE NOT WILLING TO PAY FOR ANY REPAIRS. NO REPAIRS OR CORRECTIONS HAVE BEEN MADE AT THIS TIME. *AK THE CONSUMER REPAIRED THE VEHICLE HIMSELF. *NM.Mileage was 60334 miles. Vehicle Identification Number (VIN):1GCHK29G32E. Chevrolet K2500 2002 problem was reported in STEVENSVILLE, MT. Vehicle was purchased on 20031205. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 60 mph. DEALER'S NAME: REEDS AUTO MART . DEALER'S TELEPHONE NUMBER: 406-777-5040 . DEALER'S CITY: STEVENSVILLE . DEALER'S STATE CODE: MT. DEALER'S ZIPCODE: 59870 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic Antilock

CHEVROLET K2500 2002 Service Brakes, Hydraulic Antilock Report #10149965

CHEVROLET K2500 2002 car safety problem was reported on Feb 10, 2005.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:ANTILOCK . GM WANTS ME TO PAY FOR A RECALL REPAIR ON MY VEHICLE. *NM.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GCHK29GX2E. Chevrolet K2500 2002 problem was reported in BUFFALO, NY. Vehicle was purchased on 20040728. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. DEALER'S NAME: GLEN CAMPBELL .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Power Train Transfer Case (4-wheel Drive)

CHEVROLET K2500 2002 Power Train Transfer Case (4-wheel Drive) Report #10151286

CHEVROLET K2500 2002 car safety problem was reported on Feb 13, 2006.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) . ROUTINE MAINTENANCE REVEALED A LEAK IN THE TRANSFER CASE. THIS LEAD TO DISCOVER A SMALL HOLE IN THE CASE. THIS IS CAUSED BY A PART DEFECT THAT BREAKS OVER TIME. USUALLY AROUND 85,000 TO 105,000 MILES. THE PART IS AN "ANTI-RATTLE CLIP" THAT PREVENTS THE INNER PUMP FROM OF COURSE RATTLING. WHEN THIS PART BREAKS, THE PUMP THEN RUBS A HOLE FROM THE INSIDE OUT. IF THIS IS NOT CAUGHT IN TIME, THE LUBRICATING OIL WOULD RUN DRY AND THIS WOULD LEAD TO A DRIVETRAIN MALFUNCTION. I WILL BE ORDERING A REPLACEMENT TRANSFER CASE. YES OLD PART WILL BE AVAILABLE. NOTE: AS OF YET, THE REPLACEMENT PART FOR THIS HAS NO MODIFICATIONS TO PREVENT THIS FROM HAPPENING AGAIN. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 92000 miles. Vehicle Identification Number (VIN):1GCHK23192F. Chevrolet K2500 2002 problem was reported in FREMONT, UT. Vehicle was purchased on 20021216. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL SYSTEM:Fuel injection. FUEL TYPE: DIESEL. Chevrolet K2500 2002 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: HIGH COUNTRY AUTO . DEALER'S TELEPHONE NUMBER: 4358965486 . DEALER'S CITY: RICHFIELD . DEALER'S STATE CODE: UT. DEALER'S ZIPCODE: 84071 .
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic

CHEVROLET K2500 2002 Service Brakes, Hydraulic Report #10247415

CHEVROLET K2500 2002 car safety problem was reported on Oct 29, 2008.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC . UPON BRAKING PEDAL WENT TO FLOOR. RUSTED, PITTED MAIN BRAKE LINE FROM MASTER CYLINDER TO ABS PUMP. NO BRAKES. LINE REPAIRED. WHEN BLEEDING BRAKES ANOTHER LINE BURST. ALL LINES VERY RUSTED AND PITTED. ALL REPLACED. *TR.0 person(s) were injured. 0 person(s) died.Mileage was 96000 miles. Vehicle Identification Number (VIN):1GCHK29U62E. Chevrolet K2500 2002 problem was reported in CANTON, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 50 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Suspension Front

CHEVROLET K2500 2002 Suspension Front Report #10267913

CHEVROLET K2500 2002 car safety problem was reported on Dec 24, 2008.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SUSPENSION:FRONT . WHILE DRIVING FRONT LEFT WHEEL ASSY. SEPARATED FROM TRUCK CAUSING ME TO CRASH. TRUCK WAS A TOTAL LOSS. *TR.Vehicle was involved in a crash. Mileage was 150000 miles. Vehicle Identification Number (VIN):1GCHK29U72E. Chevrolet K2500 2002 problem was reported in MARLIN, TX. Accident was reported to Police. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 65 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic

CHEVROLET K2500 2002 Service Brakes, Hydraulic Report #10296644

CHEVROLET K2500 2002 car safety problem was reported on Oct 20, 2009.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC . ABS SLOW STOP ACTIVATION, A COMMON COMPLAINT WITH CHEVROLET TRUCKS AND SUV,S, CHEVROLET HAS REFUSED TO FIX THE PROBLEM ALTHOUGH IT IS WELL DOCUMENTED AND SOME MODELS RECALLED FOR THE SAME DEFECT. *TR.Mileage was 75100 miles. Vehicle Identification Number (VIN):1GCHK23U62F. Chevrolet K2500 2002 problem was reported in CINCINNATI, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 10 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 2002 Service Brakes, Hydraulic Report #10380864

CHEVROLET K2500 2002 car safety problem was reported on Sept 01, 2010.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS LLC had a problem with SERVICE BRAKES, HYDRAULIC . I OWN A 2002 CHEVY SILVERADO 2500 HD 4X4. IN THE PAST COUPLE OF MONTHS MY ABS HAS BEEN ACTIVATING AT LOW SPEEDS FOR NO REASON (CONDITIONS DRY WITH NO WATER AND ICE). IT CAUSES ME TO SLOW EARLIER THAN NORMAL TO PREVENT STOPPING TOO LATE. I HAVE BEEN RESEARCHING THIS AND IT APPEARS THAT IT MAY BE COVERED BY A RECALL (PE05020). I LIVE IN MARYLAND AND AM NOT YET SURE IF MY STATE IS COVERED. I BOUGHT MY VEHICLE SECOND HAND FROM A CHEVY DEALER 6/29/04 AND HAVE NOT RECEIVED A RECALL NOTICE (I HAVE RECEIVED OTHERS IN THE PAST). FILING THIS AND CONTACTING MY DEALER IN CASE NHTSA THINKS MD SHOULD NOT BE COVERED. THE FAILURE OCCURS DAILY AND CAUSES LONGER STOPPING DISTANCE. *TR.Mileage was 59400 miles. Vehicle Identification Number (VIN):1GCHK23U22F. Chevrolet K2500 2002 problem was reported in SYKESVILLE, MD. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 5 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Parking Brake Driveline Hydraulic Hoses, Lines/piping, And Fittings

CHEVROLET K2500 2002 Parking Brake Driveline Hydraulic Hoses, Lines/piping, And Fittings Report #10426357

CHEVROLET K2500 2002 car safety problem was reported on Sept 18, 2011.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS LLC had a problem with PARKING BRAKE:DRIVELINE:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS . COMPLETE LOSS OF FRONT BRAKE SYSTEM WHILE DRIVING. I NOTED A SOFT PEDAL WHILE SITTING AT A TRAFFIC LIGHT AND ON THE NEXT BRAKE APPLY THERE WAS LITTLE OR NO DECELERATION UNTIL THE PEDAL WAS NEAR THE FLOOR. THE REAR WHEELS LOCKED UP MOMENTARILY WHILE SLOWING THE VEHICLE AT THE EXTENT OF PEDAL TRAVEL. AFTER STOPPING THE VEHICLE, I NOTED A STEADY STREAM OF BRAKE FLUID COMING FROM THE LINE WHEN THE BRAKE WAS APPLIED. THE BRAKE LINE RUNNING TO THE ABS UNIT UNDER THE DRIVER SIDE DOOR HAD A LARGE LEAK IN AN AREA OF HEAVY CORROSION. UPON FURTHER INSPECTION I FOUND THAT MOST OF THE BRAKE LINES HAD HEAVY CORROSION ON THE VEHICLE ALTHOUGH NO OTHER LEAKS WERE NOTED. *KB.Mileage was 54688 miles. Vehicle Identification Number (VIN):1GCGK29U52Z. Chevrolet K2500 2002 problem was reported in CARMEL, IN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 Service Brakes, Hydraulic

CHEVROLET K2500 2002 Service Brakes, Hydraulic Report #10426357

CHEVROLET K2500 2002 car safety problem was reported on Sept 18, 2011.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS LLC had a problem with SERVICE BRAKES, HYDRAULIC . COMPLETE LOSS OF FRONT BRAKE SYSTEM WHILE DRIVING. I NOTED A SOFT PEDAL WHILE SITTING AT A TRAFFIC LIGHT AND ON THE NEXT BRAKE APPLY THERE WAS LITTLE OR NO DECELERATION UNTIL THE PEDAL WAS NEAR THE FLOOR. THE REAR WHEELS LOCKED UP MOMENTARILY WHILE SLOWING THE VEHICLE AT THE EXTENT OF PEDAL TRAVEL. AFTER STOPPING THE VEHICLE, I NOTED A STEADY STREAM OF BRAKE FLUID COMING FROM THE LINE WHEN THE BRAKE WAS APPLIED. THE BRAKE LINE RUNNING TO THE ABS UNIT UNDER THE DRIVER SIDE DOOR HAD A LARGE LEAK IN AN AREA OF HEAVY CORROSION. UPON FURTHER INSPECTION I FOUND THAT MOST OF THE BRAKE LINES HAD HEAVY CORROSION ON THE VEHICLE ALTHOUGH NO OTHER LEAKS WERE NOTED. *KB.Mileage was 54688 miles. Vehicle Identification Number (VIN):1GCGK29U52Z. Chevrolet K2500 2002 problem was reported in CARMEL, IN. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL TYPE: GAS. VEHICLE SPEED: 30 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 2002 Service Brakes, Hydraulic Report #10434734

CHEVROLET K2500 2002 car safety problem was reported on Nov 06, 2011.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS LLC had a problem with SERVICE BRAKES, HYDRAULIC . BRAKE LINE FAILURE NEAR ABS MODULE INSIDE FRAME RAIL UNDER DRIVERS DOOR; FAILED IN OWNERS DRIVEWAY; USED EMERGENCY BRAKE TO STOP; INSPECTION OF BRAKE LINES INDICATES SEVERE RUSTING OF ALL LINES IN THAT AREA. *TR.Mileage was 53000 miles. Vehicle Identification Number (VIN):1GCHK29G82E. Chevrolet K2500 2002 problem was reported in MONTGOMERY, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet K2500 2002 drive type:4WD. FUEL TYPE: GAS. VEHICLE SPEED: 10 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 2002 Service Brakes Report #10459761

CHEVROLET K2500 2002 car safety problem was reported on May 26, 2012.CHEVROLET K2500 2002, manufactured by GENERAL MOTORS LLC had a problem with SERVICE BRAKES . PUSHED BRAKES AND THE PEDAL WENT TO THE FLOOR. I HAD TO USE PARK BRAKE TO STOP. THE BRAKE LINES ARE RUSTED WITH LARGE HOLE IN THEM. *TR.0 person(s) were injured. 0 person(s) died.Mileage was 38850 miles. Vehicle Identification Number (VIN):1GCHK29U22E. Chevrolet K2500 2002 problem was reported in COEBURN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 5 mph.
     Report Your Car Problem      Go Top

CHEVROLET K2500 2002 Service Brakes Report #10633014

CHEVROLET K2500 2002 car safety problem was reported on Sept 13, 2014.CHEVROLET K2500 2002, manufactured by General Motors LLC had a problem with SERVICE BRAKES . WAS BACKING OUT OF THE DRIVEWAY AND WHEN I TRIED TO STOP THE BRAKE PEDAL WENT ALL THE WAY DOWN AND I HAD NO BRAKES. THERE WAS NO WARNING WHATSOEVER THAT I HAD A BRAKING PROBLEM. WHEN I LOOKED UNDERNEATH THE TRUCK I COULD SEE THAT THE BRAKE LINES ARE VERY CORRODED AND ONE IS LEAKING. IT LOOKS LIKE THEY WILL ALL NEED TO BE REPLACED AND THE TRUCK WILL PROBABLY NEED TO BE TOWED IN TO HAVE THIS DONE. IT SOUNDS LIKE THIS WILL BE A VERY COSTLY FIX. I BOUGHT THIS TRUCK NEW AND IT HAS ALWAYS BEEN GARAGED AND WELL TAKEN CARE OF..0 person(s) were injured. 0 person(s) died.Mileage was 91929 miles. Vehicle Identification Number (VIN):1GCHK29U42E. Chevrolet K2500 2002 problem was reported in ATHENS, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 5 mph.
     Report Your Car Problem      Go Top

Share, Email, Print

	Excellent
	Good
	OK
	Bad
	Terrible

View Results

	Great, love it!
	Yes, a very good ride
	It is OK...
	No, Don't like it
	Definitely Not, Terrible

View Results

No comments have been provided.

VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE S...

CHEVROLET K2500 2002