Car-and-Safety.com

CHEVROLET EXPRESS Service Brakes, Hydraulic

CHEVROLET EXPRESS 2003 Safety Review #10009457

CHEVROLET EXPRESS 2003 car safety problem was reported on Jan 12, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC . THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE WHEN THE BRAKES WERE APPLIED.*JB.Vehicle Identification Number (VIN):FULLFILL. Chevrolet Express 2003 problem was reported in SNOHOMISH, WA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS 2003 Safety Review #10014549

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 27, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC . WHEN THE BRAKES WERE APPLIED, THEY FAILED TO HOLD, WHICH RESULTED IN AN ACCIDENT. *JB ON 3-28-03, THE CONSUMER TOOK THE VEHICLE TO THE DEALER BUT THEY WOULDN'T CHECK THE BRAKES. NINE DAYS LATER, THE CONSUMER PASSED AS A RESULT OF A HEART ATTACK AND HIS WIFE FELT IT WAS THE RESULT OF THE ACCIDENT, BECAUSE HE WAS SCARED TO DRIVE THE VEHICLE WITH THE FAULTY BRAKES. (CONNIE HUART ON BEHALF OF DECEASED HUSBAND, MICHEAL HUART). *PH *JB.Vehicle was involved in a crash. Mileage was 18000 miles. Vehicle Identification Number (VIN):1GCHG39UX31. Chevrolet Express 2003 problem was reported in KETTERING, OH. Accident was reported to Police. Original Owner. Vehicle was purchased on 20021204. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 45 mph. DEALER'S NAME: VOSS CHEVROLET . DEALER'S TELEPHONE NUMBER: 937-433-1444 . DEALER'S CITY: DAYTON . DEALER'S STATE CODE: OH. DEALER'S ZIPCODE: 45459 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring

CHEVROLET EXPRESS 2003 Safety Review #10019088

CHEVROLET EXPRESS 2003 car safety problem was reported on Feb 15, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING . FIRE THAT ORIGINATED IN THE RIGHT REAR BACK DOOR FACTORY WIRING WHERE ARCING AND ELECTRICAL FAULTING WERE PRESENT, SPECIFICALLY THE WIRING TRAVELING TO THE LOCK MOTOR, WHERE A SHORT TO GROUND OCCURRED AND IGNITED WIRING INSULATION INTO OPEN FLAME. *JB.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 3000 miles. Vehicle Identification Number (VIN):1GCFG25X731. Chevrolet Express 2003 problem was reported in HOFFMAN ESTATES, IL. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: WOODFIELD CHEVORLET . DEALER'S CITY: SCHAUMBURG . DEALER'S STATE CODE: IL.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Structure Body Door

CHEVROLET EXPRESS 2003 Safety Review #10026277

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 15, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with STRUCTURE:BODY:DOOR . THE VEHICLE DID NOT COME EQUIPPED WITH A INSIDE DOOR HANDLE ON THE PASSENGER SIDE IN ORDER FOR PASSENGERS TO ENTER OR EXIT THE VEHICLE. *TS *JB.Vehicle Identification Number (VIN):1GNFG15T631. Chevrolet Express 2003 problem was reported in MARIETTA, GA. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: NASH CHEVROLET . DEALER'S TELEPHONE NUMBER: 770-963-9266 . DEALER'S CITY: LAWRENCEVILLE . DEALER'S STATE CODE: GA. DEALER'S ZIPCODE: 30045 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic Foundation Components Disc Rotor

CHEVROLET EXPRESS 2003 Safety Review #10030060

CHEVROLET EXPRESS 2003 car safety problem was reported on May 19, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR . 2003 CHEVROLET EXPRESS EXPERIENCED BRAKE PROBLEMS.* MR. THE BRAKE ROTORS WERE WORN AND RUSTED FROM SITTING. *TS *JB *CB .Mileage was 21024 miles. Vehicle Identification Number (VIN):1GCFG15X231. Chevrolet Express 2003 problem was reported in ZANESVILLE, OH. Vehicle was purchased on 20000521. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: MCLOUGHLIN AUTO SALES . DEALER'S CITY: ZANESVILLE . DEALER'S STATE CODE: OH. DEALER'S ZIPCODE: 43701 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring

CHEVROLET EXPRESS 2003 Safety Review #10033576

CHEVROLET EXPRESS 2003 car safety problem was reported on .CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING . COSNUMER STATED VEHICLE WAS PARKED OVER NIGHT WHEN IT SUDDENLY CAUGHT ON FIRE. FIRE DEPARTMENT STATED IT WAS AN ELECTRICAL FIRE. *AK.Vehicle was on fire. Chevrolet Express 2003 problem was reported in DANIA BEACH, FL. Accident was reported to Police. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring Front Underhood

CHEVROLET EXPRESS 2003 Safety Review #10044186

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 10, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD . CONSUMER WAS AWAKENED BY A HORN BLASTING IN THE DRIVEWAY OF RESIDENCE. AFTER A FEW MINUTES CONSUMER HEARD A LOUD EXPLOSION. WHEN THE CONSUMER ARRIVED AT THE FRONT DOOR, VEHICLE WAS IN FLAMES. ENGINE WAS TOTALLY CONSUMED BY THE FIRE. THE FIRE DEPARTMENT ARRIVED, AND INFORMED THE CONSUMER THAT FAULTY WIRING CAUSED THE FIRE. *AK *PH *NLM.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 1700 miles. Vehicle Identification Number (VIN):1GCEG15X831. Chevrolet Express 2003 problem was reported in DANIA, FL. Accident was reported to Police. Original Owner. Vehicle was purchased on 20030427. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: DADELAND CHEVROLET . DEALER'S TELEPHONE NUMBER: 305-740-7475 . DEALER'S CITY: MIAMI . DEALER'S STATE CODE: FL. DEALER'S ZIPCODE: 33143 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Communications Horn Assembly

CHEVROLET EXPRESS 2003 Safety Review #10051603

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 13, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with COMMUNICATIONS:HORN ASSEMBLY . THE VEHICLE'S HORN AND WINDSHIELD WIPER EQUIPMENT FAILED INTERMITTENTLY. THE CAUSE HAD NOT BEEN DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB *MR.0 person(s) were injured. 0 person(s) died.Mileage was 36800 miles. Vehicle Identification Number (VIN):1GCFG15XX31. Chevrolet Express 2003 problem was reported in TOPSFIELD, MA. Original Owner. Vehicle was purchased on 20030901. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: DAVID FERRAEZ DANVERS . DEALER'S TELEPHONE NUMBER: 978 774 8255 . DEALER'S CITY: TOPSFIELD . DEALER'S STATE CODE: MA. DEALER'S ZIPCODE: 01983 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Visibility Windshield Wiper/washer

CHEVROLET EXPRESS 2003 Safety Review #10051603

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 13, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with VISIBILITY:WINDSHIELD WIPER/WASHER . THE VEHICLE'S HORN AND WINDSHIELD WIPER EQUIPMENT FAILED INTERMITTENTLY. THE CAUSE HAD NOT BEEN DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB *MR.0 person(s) were injured. 0 person(s) died.Mileage was 36800 miles. Vehicle Identification Number (VIN):1GCFG15XX31. Chevrolet Express 2003 problem was reported in TOPSFIELD, MA. Original Owner. Vehicle was purchased on 20030901. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: DAVID FERRAEZ DANVERS . DEALER'S TELEPHONE NUMBER: 978 774 8255 . DEALER'S CITY: TOPSFIELD . DEALER'S STATE CODE: MA. DEALER'S ZIPCODE: 01983 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Exterior Lighting

CHEVROLET EXPRESS 2003 Safety Review #10055464

CHEVROLET EXPRESS 2003 car safety problem was reported on .CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with EXTERIOR LIGHTING . WHILE DRIVING CONSUMER SMELLED A BURNING ODOR. WITHIN SECONDS THE CABIN WAS IN SMOKE, THEN FLAMES. UPON INSPECTION OF THE VEHICLE BY THE CONSUMER THE FIRE STARTED FROM THE REAR OF THE VAN. CONSUMER FELT IT WAS DUE TO THE REAR LICENSE PLATE LAMP SOCKET, RECALL 03V217000, BUT WAS NOT SURE. THE VAN WILL BE INSPECTED BY A CHEVROLET INSPECTOR.*AK.Vehicle was on fire. Vehicle Identification Number (VIN):1GAHG39U731. Chevrolet Express 2003 problem was reported in CHESTERLAND, OH. Accident was reported to Police. Original Owner. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring Front Underhood

CHEVROLET EXPRESS 2003 Safety Review #10062712

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 19, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD . THE PANIC ALARM WENT OFF AND COULDN'T BE TURNED OFF INITIALLY. DEALER ADVISED TO BRING VEHICLE IN. ALARM WENT OFF WHEN VEHICLE STARTED FOR SECOND TIME. VEHICLE DRIVEN ABOUT 3 MILES, ENGINE SHUT DOWN WHILE DRIVING. PULLED OVER, SMOKE POURED FROM UNDER HOOD, THEN FLAMES UNTIL VEHICLE ENGULFED IN FLAMES. VEHICLE TOTALLY DESTROYED BY FIRE. *JB.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 18000 miles. Chevrolet Express 2003 problem was reported in FROSTBURG, MD. Accident was reported to Police. Vehicle was purchased on 20030410. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Chevrolet Express 2003 drive type:AWD. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: SHAFFER .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic Pedals And Linkages

CHEVROLET EXPRESS 2003 Safety Review #10066470

CHEVROLET EXPRESS 2003 car safety problem was reported on Apr 01, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES . PURCHASED VEHICLE AND NOTICED BRAKE PEDAL ARM AND FORWARD RIGHT SEAT BOLT ON DRIVER SEAR WERE BOTH RUSTED. DEALER STATED THEY WOULD LOOK AT IT BUT DID NOT REPORT TO WHY A NEW VEHICLE WOULD HAVE RUST ON INTERIOR COMPONENTS. TWB. *AK.0 person(s) were injured. 0 person(s) died.Mileage was 8569 miles. Vehicle Identification Number (VIN):1GCFG25T531. Chevrolet Express 2003 problem was reported in STAFFORD, TX. Vehicle was purchased on 20031130. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:U. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ALLEN SAMUELS CHEVROLET . DEALER'S TELEPHONE NUMBER: 7132723600 . DEALER'S CITY: HOUSTON . DEALER'S STATE CODE: TX. DEALER'S ZIPCODE: 77074 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Seats Front Assembly Recliner

CHEVROLET EXPRESS 2003 Safety Review #10066470

CHEVROLET EXPRESS 2003 car safety problem was reported on Apr 01, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SEATS:FRONT ASSEMBLY:RECLINER . PURCHASED VEHICLE AND NOTICED BRAKE PEDAL ARM AND FORWARD RIGHT SEAT BOLT ON DRIVER SEAR WERE BOTH RUSTED. DEALER STATED THEY WOULD LOOK AT IT BUT DID NOT REPORT TO WHY A NEW VEHICLE WOULD HAVE RUST ON INTERIOR COMPONENTS. TWB. *AK.0 person(s) were injured. 0 person(s) died.Mileage was 8569 miles. Vehicle Identification Number (VIN):1GCFG25T531. Chevrolet Express 2003 problem was reported in STAFFORD, TX. Vehicle was purchased on 20031130. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:U. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ALLEN SAMUELS CHEVROLET . DEALER'S TELEPHONE NUMBER: 7132723600 . DEALER'S CITY: HOUSTON . DEALER'S STATE CODE: TX. DEALER'S ZIPCODE: 77074 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Engine And Engine Cooling

CHEVROLET EXPRESS 2003 Safety Review #10070592

CHEVROLET EXPRESS 2003 car safety problem was reported on May 15, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ENGINE AND ENGINE COOLING . I PURCHASED BRAND NEW CHEVROLET CONVERSION VAN ON APRIL 30 2003 FROM BILL HEARD CHEVROLET.I AM HAVING PROBLEM WITH AC AND THE DEALER SHIP FAILED TO FIX IT. 1. PROBLEM-AC NOT WORKING DATE-5-14-03 MILAGE-769 CORRECTIVE ACTION-DEALERSHIP FOUND LOW ON FREON 2. PROBLEM-AC NOT WORKING DATE-5-15-2003 MILAGE-821 COMMENTS-DEALER SHIP FOUND LAEK 3. PROBLEM-AC NOT WORKING DATE-5-23-2003 MILAGE-1304 COMMENTS-DEALERSHIP KEPT THE VAN FOR 5 DAYS.ON 29 THEY CALL AND SAID THE VAN IS FIXED.THE DEALER SHIP SAID THEY CANT FIND THE PROBLEM 4. PROBLEM-AC NOT WORKING JUNE 11-2003 MILAGE-2200 COMMENTS-THE AC IS BLOWING WARM AIR.TOOK IT BACK TO DEALERSHIP AND TALKED WITH KELLY BURNETT(DIRECTOR OF CUSTOMER RELATIONS)SHE PROMISED THAT SHE PERSONALLY TAKE CARE THE PROBLEM AND THE VAN WILL BE READY ON JUNE 13.I CALLED AND THEY SAID ,ICAN PICK IT UP ON JUNE 14@11.I ARRIVED AT THE DEALERSHIP 10.30AM AND FOUND OUT NOTHING HAS DONE TO MY VAN.I HAD TO TAKE THE VAN BECAUSE I HAVE TO DRIVE TO NEWJERSY FROM ATLANTA ON JUNE 14. I TOLD KELLY ABOUT MY TRIP BEFORE THIS APPOINTMENT. AT THIS TIME I UNDER STAND BILLHEARD DONT WANT TO TAKE CARE MY PROBLEM.AND I CALLED G.M OFFICE.I TALKED WITH KELLY BLANKERSHIP .AFTER SEVERAL ATTEMPTS KELLY BLANKS CALL ME AND AS PER HER ADVISE I TOOK IT TO AN ANOTHER DEALERSHIP. 5. PROBLEM-AC NOT WORKING DATE-JULY-03 MILAGE-4797 COMMENTS-SOUTHTOWNE DEALER SHIP FOUND LOW SIDE PRESSURE HIGH.HIGH ORFICE TUBE WAS CLOGGED UP WITH METAL. THEY REPLACED IT.IT WAS RUNNING GOOD FOR THREE DAYS AND AC START BLOWING WARM AIR AGAIN.SOUTHTOWN DEALERSHIP ADVISED TO CARRY VAN BACK TO BILL HEARD. .Mileage was 350 miles. Vehicle Identification Number (VIN):1GBFG15TX31. Chevrolet Express 2003 problem was reported in SHARPSBURG, MS. Vehicle was not using Cruise Control. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Air Bags Frontal

CHEVROLET EXPRESS 2003 Safety Review #10029386

CHEVROLET EXPRESS 2003 car safety problem was reported on Jan 01, 1901.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with AIR BAGS:FRONTAL . FAX EMAIL FM DALE BROWN(MI) REQUEST ASSISTANCE IN GETTING GM TO INSTALL MISSING PASSENGER SIDE AIR BAG IN THEIR 2003 GM EXPRESS CARGO VAN.*MR TRANSFERRED TO OVSC-NVS-220. *CB.Vehicle Identification Number (VIN):9999. Chevrolet Express 2003 problem was reported in MIDLAND, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: DRAPER CHEVROLET . DEALER'S CITY: SAGINAW . DEALER'S STATE CODE: MI.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic Foundation Components Hoses, Lines/piping, And Fittings

CHEVROLET EXPRESS 2003 Safety Review #10091980

CHEVROLET EXPRESS 2003 car safety problem was reported on Sept 13, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS . BOTH FRONT BRAKE HOSES ERUPTED ON TWO SEPARATED OCCASIONS WHILE DRIVING. DEALER WAS NOTIFIED.*AK.0 person(s) were injured. 0 person(s) died.Mileage was 43196 miles. Vehicle Identification Number (VIN):1GCGG25VX31. Chevrolet Express 2003 problem was reported in PARKERSBURG, WV. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring Interior/under Dash

CHEVROLET EXPRESS 2003 Safety Review #10097944

CHEVROLET EXPRESS 2003 car safety problem was reported on Oct 15, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH . FIRE IN THE LEFT DASH OF A 2003 CHEVROLET EXPRESS VAN G3. *AK.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Chevrolet Express 2003 problem was reported in COLLINSVILLE, IL. Accident was reported to Police. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel System, Other Storage Fuel Gauge System

CHEVROLET EXPRESS 2003 Safety Review #10100109

CHEVROLET EXPRESS 2003 car safety problem was reported on Nov 13, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM . MAIN LINE PARTY RENTALS HAS PURCHASED 2 OF THE 2003 CHEVROLET EXPRESS VANS. THIS HAS BEEN ABOUT 12 TO 18 MONTHS AGO. BOTH OF THESE VEHICLES HAVE NEEDED THE FUEL TANKS REMOVED TO REPLACE A COMPONENT TO CORRECT NON FUNCTIONING FUEL GAGUES.*AK.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GCFG29T431. Chevrolet Express 2003 problem was reported in KING OF PRUSSIA, PA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. DEALER'S NAME: PENSKE . DEALER'S CITY: KING OF PRUSSIA . DEALER'S STATE CODE: PA. DEALER'S ZIPCODE: 19406 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Steering Linkages Arm Idler And Attachment

CHEVROLET EXPRESS 2003 Safety Review #10108300

CHEVROLET EXPRESS 2003 car safety problem was reported on Jan 31, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT . FRONT WHEELS OFF THE GROUND, STEERING WHEEL CENTERED, HELD FIRMLY IN PLACE, THERE IS NO PLAY, LOOSENESS IN STEERING SYSTEM. WHEELS TURNED 10-15', EITHER DIRECTION THERE IS APPROXMATELY 1" OF PLAY BETWEEN WHEELS AND STEERING WHEEL. CONDITION IS THE SAME BY MOVEING EITHER FRONT WHEELS. BOTH WHEELS REACT TO EACH OTHER BUT NOT TO THE STEERING WHEEL. THERE SEEMS TO BE A DESIGN DEFECIENTLY IN STEERING LINKAGE OR TURBO-BOOST PUMP.ANOTHER 2003 2500CHEV VAN, 28000 MILES HAS THE SAME PROBLEM, MINE HAS 13,338 MILES 2003.*AK.0 person(s) were injured. 0 person(s) died.Vehicle Identification Number (VIN):1GAGG25U631. Chevrolet Express 2003 problem was reported in ROBINSON, IL. Original Owner. Vehicle was purchased on 20030820. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Air Disc Rotor

CHEVROLET EXPRESS 2003 Safety Review #10120247

CHEVROLET EXPRESS 2003 car safety problem was reported on Apr 25, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, AIR:DISC:ROTOR . REAR BRAKE ROTOR BRAKING SURFACE AREA HAS FALLEN OFF. I REPLACED ROTORS WITH SAME CASTING NUMBER. PARTS HAVE BEEN DISCARDED. VEHICLE WAS UNABLE TO STOP TO MANUFACTURES DESIGN FLAW. (SUPPLIER PROBLEM) VEHICLE HAS ONLY 24,700 MILES ON IT. DEALERSHIP WONT WARRANTY THIS TYPE OF PROBLEM- THIS IS A NORMAL MAINTENANCE ISSUE..0 person(s) were injured. 0 person(s) died.Mileage was 18000 miles. Vehicle Identification Number (VIN):1GNFH15T431. Chevrolet Express 2003 problem was reported in ROYAL OAK, MI. Original Owner. Vehicle was purchased on 20030525. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Air Bags Frontal

CHEVROLET EXPRESS 2003 Safety Review #10122300

CHEVROLET EXPRESS 2003 car safety problem was reported on May 24, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with AIR BAGS:FRONTAL . ON THE 2003 CHEVY EXPRESS VAN (BOX VAN), THE PASSENGER SIDE AIR BAG BLEW UP WITHOUT THE VEHICLE BEING IN MOTION. IT BLEW UP ON THE CONSUMER'S DAUGHTER WHO IS 5 YEARS OLD. *TT THE PROBLEM OCCURRED WHEN THE CONSUMER'S DAUGHTER CLOSED THE DOOR. THE CONSUMERS DAUGHTER RECEIVED NUMEROUS BURNS AND LACERATIONS ON HER ARMS AND CHEST. *SC *JB.1 person(s) were injured. Mileage was 57000 miles. Vehicle Identification Number (VIN):1GCFG15X731. Chevrolet Express 2003 problem was reported in SANTA MARIA, CA. Vehicle was purchased on 20040515. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: HOME MOTORS . DEALER'S TELEPHONE NUMBER: 805-928-7744 . DEALER'S CITY: SANTA MARIA . DEALER'S STATE CODE: CA. DEALER'S ZIPCODE: 93454 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Power Train Axle Hubs

CHEVROLET EXPRESS 2003 Safety Review #10124627

CHEVROLET EXPRESS 2003 car safety problem was reported on Feb 15, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:AXLE HUBS . LEFT FRONT WHEEL BEARING HUB ASSEMBLY SEPARATED CAUSING THUMPING AND GRINDING NOISE. IMMEDIATELY DROVE TO DEALER FOR REPAIRS. UPON INSPECTION, IT WAS FOUND THAT THE RIGHT FRONT HUB ASSEMBLY HAD BEGIUN TO SEPARATE AS WELL. BOTH FRONT HUB ASSEMBLIES REPLACED UNDER EXTENDED WARRANTY..0 person(s) were injured. 0 person(s) died.Mileage was 36900 miles. Vehicle Identification Number (VIN):1GAGG25U131. Chevrolet Express 2003 problem was reported in LUSBY, MD. Original Owner. Vehicle was purchased on 20021230. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 55 mph. DEALER'S NAME: BAYSIDE CHEVROLET .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic Foundation Components Disc Rotor

CHEVROLET EXPRESS 2003 Safety Review #10131623

CHEVROLET EXPRESS 2003 car safety problem was reported on June 04, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR . DT: CONSUMER WAS DRIVING AT 50 MPH AND THE BRAKES STARTED VIBRATING. THE PROBLEM FIRST STARTED AROUND 6-4-05, AND HAS GRADUALLY GOTTEN WORSE. THE CONSUMER TOOK VEHICLE IT TO THE DEALERSHIP TWICE. THERE WAS NOTHING DONE TO FIX THE VEHICLE BECAUSE IT WAS NOT COVERED UNDER THE WARRANTY. THE CONSUMER CONTACTED THE MANUFACTURER, THEY HAD HIM TO MAKE A SECOND APPOINTMENT WITH THE DEALERSHIP. WHEN THE CONSUMER TOOK IT TO DEALER, THEY TOOK THE TIRES OFF, AND INSPECTED THE BRAKE PADS AND ROTORS. THEY TOLD CONSUMER THAT THE METAL HAD DELAMINATED OFF THE ROTORS. THE BRAKE PADS WERE OKAY. THEY REPORTED IT TO THE MANUFACTURER, WHO SAID IT WAS NOT COVERED UNDER WARRANTY. THE CONSUMER FELT IT WAS A MANUFACTURING DEFECT. CONSUMER KNEW SOMEONE ELSE WITH THE SAME PROBLEM BUT, WITH A TRUCK. THERE WAS A RECALL ON THE TRUCK. THERE WERE NO OTHER KNOWN PROBLEMS WITH THE VEHICLE AT THIS TIME. *AK.0 person(s) were injured. 0 person(s) died.Mileage was 30000 miles. Vehicle Identification Number (VIN):1GCFH25T931. Chevrolet Express 2003 problem was reported in WINDSOR, NH. Original Owner. Vehicle was purchased on 20030401. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 50 mph. DEALER'S NAME: DOBLES CHEVORLET . DEALER'S TELEPHONE NUMBER: 603-669-2450 . DEALER'S CITY: MANCHESTER . DEALER'S STATE CODE: NH. DEALER'S ZIPCODE: 03103 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Power Train Automatic Transmission

CHEVROLET EXPRESS 2003 Safety Review #10134945

CHEVROLET EXPRESS 2003 car safety problem was reported on July 20, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . DT: CONTACT OWNS 2003 CHEVROLET EXPRESS G3500 PASSENGER VAN. THE VAN WILL ACCELERATE ON ITS OWN SPORADICALLY. THIS STARTED AROUND 7-20-05. IT DOES IT WHILE STOPPING AT STOP LIGHT AND IT WILL ALSO DO IT WHILE DRIVING ON THE HIGHWAY. THE IDLE SPEED CONTROL MOTOR, THROTTLE POSITION SENSOR, COOLING SENSOR, ECM, AND THE PROM HAVE ALL BEEN CHANGED WITHIN 5-6 WEEKS. HE SAYS IT DID IT AT ANY SPEED SPORADICALLY. HE MADE AN APPOINTMENT TO BRING THE CAR IN AGAIN FOR A POSSIBLE REPAIR. THE CHECK ENGINE LIGHT WILL USUALLY COME ON AFTER AN INCIDENT. *AK.Mileage was 60000 miles. Chevrolet Express 2003 problem was reported in LOCUST VALLEY, NY. Original Owner. Vehicle was purchased on 20030401. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: MEYER CHEVROLET . DEALER'S CITY: MIDDLE VILLAGE . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 11379 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Vehicle Speed Control

CHEVROLET EXPRESS 2003 Safety Review #10134945

CHEVROLET EXPRESS 2003 car safety problem was reported on July 20, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with VEHICLE SPEED CONTROL . DT: CONTACT OWNS 2003 CHEVROLET EXPRESS G3500 PASSENGER VAN. THE VAN WILL ACCELERATE ON ITS OWN SPORADICALLY. THIS STARTED AROUND 7-20-05. IT DOES IT WHILE STOPPING AT STOP LIGHT AND IT WILL ALSO DO IT WHILE DRIVING ON THE HIGHWAY. THE IDLE SPEED CONTROL MOTOR, THROTTLE POSITION SENSOR, COOLING SENSOR, ECM, AND THE PROM HAVE ALL BEEN CHANGED WITHIN 5-6 WEEKS. HE SAYS IT DID IT AT ANY SPEED SPORADICALLY. HE MADE AN APPOINTMENT TO BRING THE CAR IN AGAIN FOR A POSSIBLE REPAIR. THE CHECK ENGINE LIGHT WILL USUALLY COME ON AFTER AN INCIDENT. *AK.Mileage was 60000 miles. Chevrolet Express 2003 problem was reported in LOCUST VALLEY, NY. Original Owner. Vehicle was purchased on 20030401. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: MEYER CHEVROLET . DEALER'S CITY: MIDDLE VILLAGE . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 11379 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System

CHEVROLET EXPRESS 2003 Safety Review #10135447

CHEVROLET EXPRESS 2003 car safety problem was reported on Sept 05, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM . DT: THE CONSUMER STATED THAT WHILE DRIVING AT 50-60 MPH 2003 CHEVROLET EXPRESS STALLED. THE VEHICLE SAT FOR ABOUT A MINUTE, THEN IT RESTARTED. THERE WERE NO LIGHTS THAT CAME ON THE DASHBOARD. THIS HAPPENED WITH NO WARNING. THE DEALERSHIP HAS NOT BEEN CONTACTED AS OF NOW. THE MANUFACTURER HAS NOT BEEN CALLED. THE CONSUMER WAS GOING TO CONTACT THE DEALER SO THEY COULD EXAMINE THE VAN.*AK THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY FOUND NOTHING WRONG WITH THE VEHICLE. *NM.Mileage was 7260 miles. Vehicle Identification Number (VIN):1GBHG31U831. Chevrolet Express 2003 problem was reported in EASTON, PA. Original Owner. Vehicle was purchased on 20030801. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 50 mph. DEALER'S NAME: HAWTHORNE CHEVROLET . DEALER'S TELEPHONE NUMBER: 973-427-1560 . DEALER'S CITY: HAWTHORNE . DEALER'S STATE CODE: NJ. DEALER'S ZIPCODE: 07506 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel System, Gasoline Fuel Injection System

CHEVROLET EXPRESS 2003 Safety Review #10142926

CHEVROLET EXPRESS 2003 car safety problem was reported on Oct 11, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM . DT: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED INTERMITTENTLY. ALSO, IT STALLED WHEN SLOWING DOWN OR WHEN STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THE FUEL INJECTOR PUMP WAS REPLACED. THIS REPAIRED THE VEHICLE.*AK UPDATED 11/7/2005 - *NM.Mileage was 49750 miles. Vehicle Identification Number (VIN):1GBJG31F821. Chevrolet Express 2003 problem was reported in CHULA VISTA, CA. Original Owner. Vehicle was purchased on 20001212. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: DIESEL. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. DEALER'S NAME: A-Z BUS SALES . DEALER'S TELEPHONE NUMBER: 800-622-4442 . DEALER'S CITY: COLTON . DEALER'S STATE CODE: CA. DEALER'S ZIPCODE: 92324 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Visibility Windshield Wiper/washer

CHEVROLET EXPRESS 2003 Safety Review #10143617

CHEVROLET EXPRESS 2003 car safety problem was reported on Oct 23, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with VISIBILITY:WINDSHIELD WIPER/WASHER . I DRIVE A 2003 CHEVROLET EXPRESS VAN. I BELIEVE THERE IS AN ISSUE WITH THE WINDSHIELD WIPERS. MANY TIMES, WHEN TRAVELING AT SPEEDS ABOVE 50 THE WIPERS DO VERY LITTLE TO KEEP THE WINDSHIELD CLEAR. EVEN AFTER INSTALLING NEW BLADES. THIS HAPPENS DURING ALL TYPES OF INCLEMENT WEATHER, BUT IS ESPECIALLY BAD IN THE WINTER. THE WIPER BLADES ALLOW ICE TO COLLECT ON THEM, AND THE DEFROSTER IS NOT ENOUGH TO KEEP THEM CLEAR. I MUST STOP AND MANUALLY CLEAR THE WIPERS IF I MUST USE THE WIPERS, THEY JUST SCRAPE ACROSS THE WINDSHIELD BUT DO VERY LITTLE TO ACTUALLY CLEAR THE WINDSHIELD. IF TRAFFIC PASSING BY, THROWS SLUSH AND SUCH ON THE WINDSHIELD. THE WIPERS CAN NOT CLEAR IT PROPERLY. IN ADDITION TO THIS, THE WINDSHIELD WASHER SPRAY HOSES ARE ATTACHED TO THE WIPER ARMS AND TEND TO PLUG OR FREEZE AND COMPOUNDS THE PROBLEM. I HAVE DRIVEN THIS VEHICLE FOR 3 YEARS AND ITS THE SAME THING EVERY YEAR. IT PRESENTS QUITE A PROBLEM SINCE MANY TIMES, I AM OPERATING THE VEHICLE AT HIGHWAY SPEEDS, WITH LIMITED VISION. UNTIL I STOP AND CLEAR IT OFF. I DON'T KNOW IF ITS BECAUSE THE WIPERS LIFT OFF THE WINDSHIELD AT HIGH SPEEDS OR IF THE JUST SHRINK DUE TO THE COLD. I DO KNOW THAT IT HAS BECOME A SAFETY ISSUE. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 5000 miles. Vehicle Identification Number (VIN):1GCHG35U931. Chevrolet Express 2003 problem was reported in OTSEGO, MI. Original Owner. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 50 mph. DEALER'S NAME: DENOOYER . DEALER'S CITY: KALAMAZOO . DEALER'S STATE CODE: MI.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Seat Belts Front Buckle Assembly

CHEVROLET EXPRESS 2003 Safety Review #10144891

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 08, 2005.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SEAT BELTS:FRONT:BUCKLE ASSEMBLY . DRIVER SIDE SEAT BELT RECEIVER MALFUNCTION - WHILE INSERTING BELT LOCKING TAB, RED RELEASE BUTTON POPPED OUT - TRIED TO REINSERT BUTTON, MECHANISM JAMMED TRAPPING ME IN SEAT; UNTIL I COULD THREAD MYSELF OUT OF BELTS. PART ORDERED. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 22366 miles. Vehicle Identification Number (VIN):1GCHG39U131. Chevrolet Express 2003 problem was reported in REDDING, CA. Original Owner. Vehicle was purchased on 20030125. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: LITHIA CHEVROLET . DEALER'S CITY: REDDING . DEALER'S STATE CODE: CA.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Wheels Center Section

CHEVROLET EXPRESS 2003 Safety Review #10150331

CHEVROLET EXPRESS 2003 car safety problem was reported on Feb 11, 2006.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with WHEELS:CENTER SECTION . I HAVE A 2003 CHEVROLET 2500 EXPRESS VAN (PURCHASED NEW AND WELL MAINTAINED) THAT I USE FOR FIRE INVESTIGATIONS. ON THE DATE OF THE INCIDENT, THE ODOMETER READING WAS 50628 MILES. ON MY RETURN TRAVEL, I WAS ON I-75 NORTH BOUND THROUGH DAYTON, OHIO (SPEEDS EST @ 65-70 MPH) WHEN THE VIBRATION THROUGH THE STEERING WHEEL INCREASED. APPROXIMATELY SEVEN MILES SOUTH OF PIQUA, OHIO, I EXPERIENCED A CATASTROPHIC FAILURE OF THE LEFT FRONT WHEEL (DIDN'T KNOW WHAT TYPE OF FAILURE AT THIS TIME) WHICH CAUSED THE VEHICLE TO SUDDENLY "JERK" TO THE LEFT. TRAVELING IN THE CENTER NORTH BOUND LANE OF I-75 AND IN HEAVY TRAFFIC, I USED BOTH HANDS TO STEERING MY VAN TO THE RIGHT HAND LANE NARROWING MISSING A SEMI TRACTOR-TRAILER. I CONTINUED ONTO THE BERM WITH THE END OF THE VAN SLIDING SIDEWAYS TO THE RIGHT. AS THE VAN SLOWED AND NOW ALMOST PERPENDICULAR TO TRAFFIC, THE LEFT SIDE OF THE VAN BEGAN TO LIFT WITH BOTH LEFT SIDE WHEELS OFF THE GROUND. LUCKILY, THE VAN CAME TO A STOP AND THE LEFT SIDE DROPPED TO THE GROUND. TRAFFIC ON I-75 WAS IN CHAOS TRYING TO AVOID MY VAN DURING THE WHOLE EPISODE. I BELIEVE THE LONG WHEEL BASE OF THE VAN CONTRIBUTE TO PREVENTING THE VAN FROM ROLLING. AAA TOWED THE MY VAN TOWED TO DEFIANCE (OHIO) CHEVROLET DEALER IN PREPARATION FOR REPAIRS BECKMAN CHEVROLET DEALER SERVICE DEPARTMENT INSPECTED THE VAN ON THE NEXT DAY AN FOUND COMPLETE FAILURE OF THE LEFT FRONT WHEEL BEARING WITH ONLY THE FRONT BRAKE SYSTEM KEEPING THE WHEEL ON THE SPINDLE. THE VEHICLE WAS REPAIRED WITH THE INSTALLATION OF A NEW WHEEL AND BEARING ASSEMBLY(SOLD AS ONE UNIT). I HAD TO PAY $300 AS A "WARRANTY DEDUCTIBLE" WITH THE DEFECTIVE PARTS RETURNED TO THE MANUFACTURER GM . IN MY OPINION THIS WHEEL AND BEARING ASSEMBLY SHOULD NOT HAVE FAILED WITH ONLY 50,000 MILES AND IT APPEARS THERE WAS A MATERIAL OR INSTALLATION FAILURE IN SOME MANNER. AAA IS OUT ABOUT $300 FOR THE TOW BILL. I REMAIN, BOB MARIHUGH, DEFIANCE, OHIO. *JB.0 person(s) were injured. 0 person(s) died.Mileage was 50625 miles. Vehicle Identification Number (VIN):1GCGG25V431. Chevrolet Express 2003 problem was reported in DEFIANCE, OH. Original Owner. Vehicle was purchased on 20030618. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 68 mph. DEALER'S NAME: DON SCOTT CHEVOLET . DEALER'S TELEPHONE NUMBER: 800-767-2688 . DEALER'S CITY: WHITEHOUSE . DEALER'S STATE CODE: OH. DEALER'S ZIPCODE: 43571 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Engine And Engine Cooling Cooling System Hose

CHEVROLET EXPRESS 2003 Safety Review #10151660

CHEVROLET EXPRESS 2003 car safety problem was reported on Apr 18, 2004.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE . MY HOSE THAT CONNECTS TO THE ENGINE TO THE RADIATOR HAS CRACKED AT LEAST THREE TIMES IN THE PAST TWO AND HALF YEARS, I HAVE ASK CHEVY ON EACH OCCASION THAT I HAD TO PURCHASE IT FROM THE DEALERSHIP, IF THERE IS A PROBLEM WITH HOW THE HOSE IS POSITION SO CLOSE TO THE EXHAUST PIPE WITH NO SUPPORT TO KEEP THE HOSE AWAY FROM THIS PIPE THAT GIVES OFF SO MUCH HEAT, I TRULY BELIEVE THIS IS CREATING THE PROBLEM AND I'M TIRED OF REPLACING IT AND WOULD LIKE TO GET TO THE BOTTOM OF THIS. *JB .Mileage was 15000 miles. Vehicle Identification Number (VIN):1GCFG15XX31. Chevrolet Express 2003 problem was reported in BALTIMORE, MD. Original Owner. Vehicle was purchased on 20030910. Vehicle was using ANTI-LOCK BRAKES.Vehicle was not using Cruise Control. Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: JERRY'S CHEVROLET . DEALER'S TELEPHONE NUMBER: 410-661-9100 . DEALER'S CITY: PARKVILLE . DEALER'S STATE CODE: MD. DEALER'S ZIPCODE: 21234 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Exterior Lighting Turn Signal

CHEVROLET EXPRESS 2003 Safety Review #10152905

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 25, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with EXTERIOR LIGHTING:TURN SIGNAL . TAIL LIGHTS LIGHT BULBS HAVE TO BE CHANGE EVRY WEEK OR EVERY OTHER WEEK. *NM.Mileage was 10000 miles. Vehicle Identification Number (VIN):1GCFG29XX31. Chevrolet Express 2003 problem was reported in CHICAGO, IL. Vehicle was purchased on 20030619. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 6 CYLINDERS. Chevrolet Express 2003 drive type:FWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: BIFUEL. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Steering Rack And Pinion

CHEVROLET EXPRESS 2003 Safety Review #10153267

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 06, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with STEERING:RACK AND PINION . THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM .Mileage was 0 miles. Vehicle Identification Number (VIN):1GNFH15TX31. Chevrolet Express 2003 problem was reported in NORTH SALEM, NY. Original Owner. Vehicle was purchased on 20030301. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ARROWAY CHEVROLET . DEALER'S TELEPHONE NUMBER: 9142323860 . DEALER'S CITY: KATONAH . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 10536 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Vehicle Speed Control Accelerator Pedal

CHEVROLET EXPRESS 2003 Safety Review #10153267

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 06, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with VEHICLE SPEED CONTROL:ACCELERATOR PEDAL . THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM .Mileage was 0 miles. Vehicle Identification Number (VIN):1GNFH15TX31. Chevrolet Express 2003 problem was reported in NORTH SALEM, NY. Original Owner. Vehicle was purchased on 20030301. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ARROWAY CHEVROLET . DEALER'S TELEPHONE NUMBER: 9142323860 . DEALER'S CITY: KATONAH . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 10536 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Steering

CHEVROLET EXPRESS 2003 Safety Review #10153267

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 06, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with STEERING . THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM .Mileage was 0 miles. Vehicle Identification Number (VIN):1GNFH15TX31. Chevrolet Express 2003 problem was reported in NORTH SALEM, NY. Original Owner. Vehicle was purchased on 20030301. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ARROWAY CHEVROLET . DEALER'S TELEPHONE NUMBER: 9142323860 . DEALER'S CITY: KATONAH . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 10536 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Power Train Automatic Transmission

CHEVROLET EXPRESS 2003 Safety Review #10153267

CHEVROLET EXPRESS 2003 car safety problem was reported on Mar 06, 2003.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with POWER TRAIN:AUTOMATIC TRANSMISSION . THE RACK AND PINION UNIT HAS LOTS OF PLAY IN THE CENTER. (APPROX 50K) THE TRANSMISSION SLIPS IN REVERSE FROM DAY ONE. THE GAS PEDAL SHIFT FROM LEFT TO RIGHT ABOUT 3 INCHES. (APPROX 40K) THIS VAN HAS ABOUT 50 REPAIRS UNDER WARRANTY. THIS VAN IS USED BY MY WIFE AND 4 KIDS. *NM .Mileage was 0 miles. Vehicle Identification Number (VIN):1GNFH15TX31. Chevrolet Express 2003 problem was reported in NORTH SALEM, NY. Original Owner. Vehicle was purchased on 20030301. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: ARROWAY CHEVROLET . DEALER'S TELEPHONE NUMBER: 9142323860 . DEALER'S CITY: KATONAH . DEALER'S STATE CODE: NY. DEALER'S ZIPCODE: 10536 .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Seat Belts

CHEVROLET EXPRESS 2003 Safety Review #10159521

CHEVROLET EXPRESS 2003 car safety problem was reported on June 10, 2006.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SEAT BELTS . THIS IS REGARDING RECALL NUMBER 05113 (SAFETY BELTS) FOR WHICH WE RECEIVED A RECALL NOTICE FOR OUR CHEVY EXPRESS VAN WHICH IS THE FOUNDATION OF OUR FOREST RIVER 22' MOTORHOME. I ASSUME THIS AFFECTS THE SEAT BELTS IN THE CAB ONLY. OUR PROBLEM IS THAT WE HAVE BEEN UNABLE TO FIND A DEALER WHO WILL REPAIR THIS MANUFACTURER DEFECT EVEN THOUGH THE LETTER WE RECEIVED STATES WE CAN TAKE IT TO ANY GM DEALER. WE ARE TWO WEEKS AWAY FROM LEAVING ON AN EXTENSIVE ROAD TRIP WITH THIS VEHICLE AND WOULD LIKE TO KNOW THAT IT IS SAFE AND WE BELIEVE IT IS UP TO THE MANUFACTURER TO CORRECT THEIR SAFETY DEFECT ASAP. *NM.Mileage was 5800 miles. Vehicle Identification Number (VIN):1GBJG31U731. Chevrolet Express 2003 problem was reported in ELKHORN, WI. Vehicle was purchased on 20050415. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Electrical System Wiring Interior/under Dash

CHEVROLET EXPRESS 2003 Safety Review #10187752

CHEVROLET EXPRESS 2003 car safety problem was reported on Apr 01, 2007.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH . TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 2500 VAN. WHILE THE VEHICLE WAS PARKED IT CAUGHT ON FIRE AND BOTH AIR BAGS DEPLOYED. THE CONTACT STATED THAT THE CAUSE OF FIRE WAS THE SAME AS MENTIONED IN RECALL # 05V104000 ELECTRICAL SYSTEM: WIRING:INTERIOR/UNDER THE DASH BOARD). THE FIRE DEPARTMENT EXTINGUISHED THE FIRE, AND THE VEHICLE WAS TOWED TO THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 74,000.*AK.Vehicle was on fire. 0 person(s) were injured. 0 person(s) died.Mileage was 74000 miles. Vehicle Identification Number (VIN):1GCGG25U231. Chevrolet Express 2003 problem was reported in COLUMBIAVILLE, MI. Original Owner. Vehicle was purchased on 20041011. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:RWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 0 mph. DEALER'S NAME: AL SERRA CHEVROLET .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic Antilock

CHEVROLET EXPRESS 2003 Safety Review #10198731

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 04, 2007.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with SERVICE BRAKES, HYDRAULIC:ANTILOCK . TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. WHILE PREPARING TO STOP FROM 20 MPH, THE VEHICLE FEELS AS IF IT IS GOING TO STOP, BUT SUDDENLY LUNGES FORWARD. AFTERWARDS, THE VEHICLE WILL STOP. THE DEALER STATED THAT HIS VEHICLE IS NOT INCLUDED IN THE RECALL FOR THIS FAILURE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 42,000..0 person(s) were injured. 0 person(s) died.Mileage was 42000 miles. Vehicle Identification Number (VIN):1GCFH25T831. Chevrolet Express 2003 problem was reported in CLINTON, PA. Original Owner. Vehicle was purchased on 20030904. Vehicle was using ANTI-LOCK BRAKES.Vehicle was using Cruise Control.Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. Chevrolet Express 2003 TRANSMISSION TYPE: AUTO. VEHICLE SPEED: 20 mph. DEALER'S NAME: OLVERIO CHEVROLET .
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel System, Gasoline

CHEVROLET EXPRESS 2003 Safety Review #10259377

CHEVROLET EXPRESS 2003 car safety problem was reported on Oct 24, 2008.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS LLC had a problem with FUEL SYSTEM, GASOLINE . SINCE OCTOBER OF 08, I ORDERED A FILLER TUBE WHICH ALLOWS THE GAS TO TRAVEL FROM THE GAS CAP TO THE GAS STORAGE TANK. EVERYTIME I FILL UP, GAS STATIONS WILL SHUT THE PUMP OFF DUE TO SEVERE LEAKING FROM THIS FILLER TUBE. THE LEAK IS SO SEVERE THAT THE FEAR IS SOMEBODY DROPPING A CIGARETTE AT THE TIME OF FILLUP. APPROX 1 GAL OF GAS LEAKS/ FILLUP. I ORDERED THE NEW PART IN LATE OCTOBER FROM THE DEALERSHIP I PURCHASED MY 2003 CHEVY PASSENGER EXPRESS VAN. I HAVE SPOKEN TO THE CHEVY REGIONAL OFFICE AND BEEN TOLD THAT THE PART IS ONLY AVAILABLE AT 5 DEALERSHIPS IN THE COUNTRY BUT THEY HAVE BEEN RESERVED FOR CUSTOMERS AND I WOULD HAVE TO WAIT UNTIL THE PART GETS MANUFACTURED ONCE AGAIN. WHEN? THEY DON'T KNOW. I REQUESTED A SIMILAR VEHICLE BE LOANED TO ME UNTIL THE NEW PART BECOMES AVAILABLE. THEY SAID "NO, IF YOU FEEL UNSAFE THEN I SHOULDN'T DRIVE IT. I TOLD THEM THIS IS AN ACCIDENT WAITING TO HAPPEN AND IT WILL NOT ONLY COST MY LIFE BUT ANYONE IN PROXIMITY TO THE GAS STATION. ONE PARTICULAR DEALERSHIP SHARED WITH ME THAT IF GM DOESN'T PAY A BILL FOR WHATEVER REASON, THE PART MANUFACTURER HALTS PRODUCTION AND THIS IS WHAT HAPPENS. WILL YOU PLEASE HELP ME? *TR.0 person(s) were injured. 0 person(s) died.Mileage was 62000 miles. Vehicle Identification Number (VIN):1GNFG15T131. Chevrolet Express 2003 problem was reported in BEACHWOOD, OH. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Latches/locks/linkages

CHEVROLET EXPRESS 2003 Safety Review #10296179

CHEVROLET EXPRESS 2003 car safety problem was reported on June 01, 2008.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with LATCHES/LOCKS/LINKAGES . I OWN A 2003 CHEVROLET EXPRESS VAN. I AM UNABLE TO OPEN THE REAR DOORS ON THE DRIVER AND PASSENGER SIDES. I HAVE BEEN TOLD BY A LOCAL BODY SHOP THAT THE PROBLEM IS THE PINS THAT WERE USED IN THE HINGES. THEY ARE RUSTING FROM THE INSIDE CAUSING THE DOORS NOT TO OPEN. THIS BODY SHOP SAID THEY HAVE BEEN GIVEN INFORMATION ON HOW TO FIX THE PROBLEM AT A COST OF $1500.00 PER SIDE. BUT I CANNOT FIND ANY INFORMATION ABOUT A RECALL FROM GENERAL MOTORS. I DO NOT HAVE AN EXTENDED WARRANTY ON THIS VEHICLE BUT I DON'T THINK THESE REPAIRS SHOULD BE MADE AT MY EXPENSE. THIS VEHICLE IS USED MOSTLY WHEN I GO CAMPING. I HAVE TWO YOUNG CHILDREN WHO RIDE IN THIS VEHICLE. I TRIED TRADING THIS VEHICLE IN NUMEROUS TIMES BEFORE THE REAR DOORS BECAME TOTALLY INOPERABLE. BUT EVERY DEALERSHIP I GO TO GOES FOR THE REAR DOORS AND TRIES TO OPEN THEM. WHICH LEADS ME TO BELIEVE THAT THEY KNOW THAT A PROBLEM EXISTS. *TR.Vehicle Identification Number (VIN):1GBFG15T231. Chevrolet Express 2003 problem was reported in WATSEKA, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Structure Body Door

CHEVROLET EXPRESS 2003 Safety Review #10296179

CHEVROLET EXPRESS 2003 car safety problem was reported on June 01, 2008.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with STRUCTURE:BODY:DOOR . I OWN A 2003 CHEVROLET EXPRESS VAN. I AM UNABLE TO OPEN THE REAR DOORS ON THE DRIVER AND PASSENGER SIDES. I HAVE BEEN TOLD BY A LOCAL BODY SHOP THAT THE PROBLEM IS THE PINS THAT WERE USED IN THE HINGES. THEY ARE RUSTING FROM THE INSIDE CAUSING THE DOORS NOT TO OPEN. THIS BODY SHOP SAID THEY HAVE BEEN GIVEN INFORMATION ON HOW TO FIX THE PROBLEM AT A COST OF $1500.00 PER SIDE. BUT I CANNOT FIND ANY INFORMATION ABOUT A RECALL FROM GENERAL MOTORS. I DO NOT HAVE AN EXTENDED WARRANTY ON THIS VEHICLE BUT I DON'T THINK THESE REPAIRS SHOULD BE MADE AT MY EXPENSE. THIS VEHICLE IS USED MOSTLY WHEN I GO CAMPING. I HAVE TWO YOUNG CHILDREN WHO RIDE IN THIS VEHICLE. I TRIED TRADING THIS VEHICLE IN NUMEROUS TIMES BEFORE THE REAR DOORS BECAME TOTALLY INOPERABLE. BUT EVERY DEALERSHIP I GO TO GOES FOR THE REAR DOORS AND TRIES TO OPEN THEM. WHICH LEADS ME TO BELIEVE THAT THEY KNOW THAT A PROBLEM EXISTS. *TR.Vehicle Identification Number (VIN):1GBFG15T231. Chevrolet Express 2003 problem was reported in WATSEKA, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Tires

CHEVROLET EXPRESS 2003 Safety Review #10340091

CHEVROLET EXPRESS 2003 car safety problem was reported on May 11, 2010.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with TIRES . 2003 CHEVROLET EXPRESS LOST CONTROL OF VEHICLE STRIKING THE MEDIAN BARRIER. *BF ACCORDING TO THE POLICE REPORT, THE REAR TIRES HAD VERY LITTLE TREAD. ON THE INSIDE OF THE TIRES, THERE WAS NO TREAD. (OHIO TRAFFIC CRASH REPORT # 10-0234-91)*JB UPDATED 07/22/10 *BF.Vehicle was involved in a crash. Chevrolet Express 2003 problem was reported in MIDDLEBURG HEIGHTS, OH. Accident was reported to Police. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. FUEL SYSTEM:Fuel injection. FUEL TYPE: GAS. VEHICLE SPEED: 55 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Air Bags Frontal

CHEVROLET EXPRESS 2003 Safety Review #10340154

CHEVROLET EXPRESS 2003 car safety problem was reported on June 23, 2010.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS CORP. had a problem with AIR BAGS:FRONTAL . VEHICLE WAS PARKED IN OUR COMPANY PARKING LOT, VEHICLE WAS NOT RUNNING AND THE KEY WAS NOT IN THE IGNITION. EMPLOYEE WAS LOADING TOOLS AND EQUIPMENT INTO REAR OF VEHICLE AFTER COMPLETING A JOB. SIDE SLIDING DOOR WAS OPEN. PASSENGER AIR BAG ONLY DEPLOYED. VEHICLE HAD NOT BEEN A WRECK. *TR.Mileage was 181632 miles. Vehicle Identification Number (VIN):1GCFG25T131. Chevrolet Express 2003 problem was reported in NEOSHO, MO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes, Hydraulic

CHEVROLET EXPRESS 2003 Safety Review #10399510

CHEVROLET EXPRESS 2003 car safety problem was reported on Nov 15, 2010.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS LLC had a problem with SERVICE BRAKES, HYDRAULIC . TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. WHILE DRIVING APPROXIMATELY 30 MPH THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL BUT THE VEHICLE HESITATED TO STOP. THE CONTACT APPLIED EXCESSIVE PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTO SHOP WHERE THE VEHICLE WAS INSPECTED. THE TECHNICIANS WERE ABLE TO DUPLICATE THE FAILURE. THE TECHNICIAN STATED THE BRAKE PADS AND ROTORS WERE IN GOOD CONDITION BUT INFORMED THE CONTACT OF A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V045000 (SERVICE BRAKES, HYDRAULIC). THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. .Mileage was 80000 miles. Vehicle Identification Number (VIN):1GCFG15X431. Chevrolet Express 2003 problem was reported in NEW CANAAN, CT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Visibility

CHEVROLET EXPRESS 2003 Safety Review #10399953

CHEVROLET EXPRESS 2003 car safety problem was reported on May 09, 2011.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS LLC had a problem with VISIBILITY . WHEN DRIVING IN A HORRIBLE RAINSTORM, THE DRIVER'S SIDE WINDSHIELD WIPER STOPPED MOVING AND THEN ON THE NEXT ROTATION, SWUNG ITSELF AROUND AND GOT LODGED BY THE SIDE VIEW MIRROR. AN ACCIDENT WAS AVOIDED, BUT IT OCCURRED 3 MORE TIMES RANDOMLY THAT SAME DAY, AND THEN TODAY. IT WAS A MIRACLE THROUGH THE HEAVY RAIN THAT WE DIDN'T WRECK. LUCKILY THE PASSENGER SIDE WIPER KEPT WORKING AND WITH SOME LUCK, WE EXITED TO SAFETY. *TR.Mileage was 43899 miles. Chevrolet Express 2003 problem was reported in BOUNTIFUL, UT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 75 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel System, Gasoline Storage Tank Assembly Filler Pipe And Cap

CHEVROLET EXPRESS 2003 Safety Review #10441615

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 26, 2011.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS LLC had a problem with FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP . 2003 CHEVROLET EXPRESS FUEL FILLER PIPE LEAK: GAS FILLER TUBE RUSTED THROUGH AND GASOLINE LEAKED EVERY TIME I REFUELED. CORROSION HOLES CAUSED FUEL TO LEAK AND CREATING A FIRE HAZARD. THIS VAN HAS A LEFT SIDE REAR CARGO DOOR. THIS IS A SIMILAR COMPLAINT AS: ODI ID NUMBER : 10413214 *KB.Vehicle Identification Number (VIN):1GBFH15T431. Chevrolet Express 2003 problem was reported in SALINE, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL TYPE: GAS.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS 2003 Safety Review #10441615

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 26, 2011.CHEVROLET EXPRESS 2003, manufactured by GENERAL MOTORS LLC had a problem with FUEL SYSTEM, GASOLINE . 2003 CHEVROLET EXPRESS FUEL FILLER PIPE LEAK: GAS FILLER TUBE RUSTED THROUGH AND GASOLINE LEAKED EVERY TIME I REFUELED. CORROSION HOLES CAUSED FUEL TO LEAK AND CREATING A FIRE HAZARD. THIS VAN HAS A LEFT SIDE REAR CARGO DOOR. THIS IS A SIMILAR COMPLAINT AS: ODI ID NUMBER : 10413214 *KB.Vehicle Identification Number (VIN):1GBFH15T431. Chevrolet Express 2003 problem was reported in SALINE, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. Chevrolet Express 2003 drive type:AWD. FUEL TYPE: GAS.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel/propulsion System

CHEVROLET EXPRESS 2003 Safety Review #10470601

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 14, 2012.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with FUEL/PROPULSION SYSTEM . TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS CONVERSION VAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, HE NOTICED A HOLE IN THE FUEL FILLER NECK. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 127,000. .0 person(s) were injured. 0 person(s) died.Mileage was 127000 miles. Vehicle Identification Number (VIN):1GBFH15T431. Chevrolet Express 2003 problem was reported in FREDRICKSBURG, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS 2003 Safety Review #10471856

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 17, 2011.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with FUEL/PROPULSION SYSTEM . TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT A SMALL AMOUNT OF FUEL CONTINUOUSLY LEAKED OUT OF THE FUEL TANK FILLER NECK IMMEDIATELY AFTER REFUELING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL FILLER NECK TUBE EXHIBITED RUST CORROSION. THE PART WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 12V388000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY: FILLER PIPE AND CAP) HOWEVER THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 111,000. .0 person(s) were injured. 0 person(s) died.Mileage was 111000 miles. Vehicle Identification Number (VIN):1GAGG25U231. Chevrolet Express 2003 problem was reported in BURKE, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Seat Belts

CHEVROLET EXPRESS 2003 Safety Review #10472768

CHEVROLET EXPRESS 2003 car safety problem was reported on Dec 14, 2011.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with SEAT BELTS . TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE SEAT BELT BUCKLE ASSEMBLY BROKE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE SEAT BELT WAS WORKING UP TO SPECIFICATIONS. THE DEALER STATED THAT THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 03V050000 COMPONENT: SEAT BELTS:FRONT:BUCKLE ASSEMBLY. BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS NOT AVAILABLE. .0 person(s) were injured. 0 person(s) died.Mileage was 65000 miles. Chevrolet Express 2003 problem was reported in BROOKLYN, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Structure Body

CHEVROLET EXPRESS 2003 Safety Review #10479318

CHEVROLET EXPRESS 2003 car safety problem was reported on Aug 10, 2007.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with STRUCTURE:BODY . DURING A FAMILY OUTING WE WERE UNABLE TO CLOSE THE RIGHT REAR PASSENGER DOOR. EXPERIENCED DIFFICULTY CLOSING DOOR. AFTER SEVERAL ATTEMPTS, I NOTICED THE DOOR WAS NOT ALIGNED WITH THE BODY OF THE CAR WHICH PROHIBITED THE DOOR LATCH TO CONNECT AND CLOSE. THE DOOR WOULD NOT CLOSE SHUT COMPLETELY AND HAS SINCE KNOCKED WHILE DRIVING AND ALSO CREATES A SAFETY HAZARD FOR CHILDREN & ADULTS BECAUSE IT IS PRIMARY EXIT FOR THE REAR EXIT TO THE SIDEWALK FORCING PASSENGERS TO EXIT FROM THE REAR LEFT DOOR PASSENGER DOOR ONTO THE STREET TO ONCOMING TRAFFIC THAT CAN LEAD TO ACCIDENT, BODILY INJURY OR FATALITY. NO PRIOR MAINTENANCE INSTRUCTIONS OR SUGGESTED UPKEEP WAS DOCUMENTED IN THE BUYERS MANUAL WHICH CAME WITH THE VEHICLE THAT WOULD INDICATE POSSIBLE HINGE CORROSION OR RUSTING. POSSIBLE PIN DEFECT DETECTED BY CERTIFIED DEALER ON 10/7/2012, WHEN TAKEN IN FOR SAFETY RECALL ON FUEL FILLER PIPE RECALL 12166 CAMPAIGN ID#12V388. MULTIPLE COMPLAINT FOR HINGE/PINS HAVE BEEN DOCUMENTED IN COMPLAINTS ON SAFERCAR.ORG WEBSITE FOR 2003 CHEVY EXPRESS VAN. I BELIEVE THIS ISSUE SHOULD BE INVESTIGATED TO AVOID ACCIDENTAL DEATHS DUE TO INOPERABLE ACCESS TO SIDEWALK FROM THE LEFT REAR PASSENGER DOOR. *TR.0 person(s) were injured. 0 person(s) died.Mileage was 69000 miles. Vehicle Identification Number (VIN):1GBFG15T431. Chevrolet Express 2003 problem was reported in DETROIT, MI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. FUEL TYPE: GAS. VEHICLE SPEED: 0 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Fuel/propulsion System

CHEVROLET EXPRESS 2003 Safety Review #10484524

CHEVROLET EXPRESS 2003 car safety problem was reported on Oct 17, 2012.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with FUEL/PROPULSION SYSTEM . TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT SHE NOTICED A LEAK UNDER THE VEHICLE WHEN SHE WOULD PUT REFUEL. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE FUEL FILLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD PAY A PORTION OF THE REPAIR COSTS. THE FAILURE MILEAGE WAS 126,600. .0 person(s) were injured. 0 person(s) died.Mileage was 126600 miles. Vehicle Identification Number (VIN):1GBFG15T831. Chevrolet Express 2003 problem was reported in ASHBURN, VA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Engine

CHEVROLET EXPRESS 2003 Safety Review #10523793

CHEVROLET EXPRESS 2003 car safety problem was reported on July 02, 2013.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with ENGINE . MY 2003 CHEVY EXPRESS 2500 CARGO VAN WAS IN EVENING RUSH HOUR STOP AND GO TRAFFIC. AFTER REDUCING MY SPEED TO 10 MPH THEN ATTEMPTING TO ACCELERATE. THE VEHICLE STALLED AND BEGAN TO IDLE ROUGH AND SHUT-OFF. I HAD TO PUT THE VEHICLE IN NEUTRAL AND RESTART IN THE MIDDLE OF THE INTERSTATE. I HAD TO CONTINUE TO SHIFT INTO NEUTRAL AND PRESS THE GAS TO PREVENT THE VEHICLE FROM SHUTTING OFF IN THE MIDDLE OF TRAFFIC. I HAD THE PLUGS AND WIRES CHANGE THE VERY NEXT DAY AND THE PROBLEM CONTINUED. THIS COULD HAVE TURNED INTO A MAJOR ACCIDENT WITH THE VEHICLE SHUTTING OFF IN THE MIDDLE OF TRAFFIC. THIS ISSUE SHOULD BE ADDRESSED AND AN IMMEDIATE RECALL NOTICE SHOULD BE PUT INTO EFFECT TO PREVENT A MAJOR ACCIDENT WHICH COULD LEAD TO A POSSIBLE FATALITY. THIS IS DANGEROUS! I'VE RESEARCHED THIS ISSUE AND HAVE FOUND MULTIPLE CHEVY EXPRESS OWNER'S WITH THE SAME CONCERN. GM SHOULD DO THE RIGHT THING FOR THE CUSTOMERS WHO SUPPORT THEIR BRAND AND PRODUCT. *TR.0 person(s) were injured. 0 person(s) died.Mileage was 206300 miles. Chevrolet Express 2003 problem was reported in SNELLVILLE, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 10 mph.
     Report Your Car Problem      Go Top

CHEVROLET EXPRESS Service Brakes

CHEVROLET EXPRESS 2003 Safety Review #10556819

CHEVROLET EXPRESS 2003 car safety problem was reported on July 23, 2012.CHEVROLET EXPRESS 2003, manufactured by General Motors LLC had a problem with SERVICE BRAKES . DRIVER A NOTICED LACK OF PRESSURE IN BRAKE PEDAL. THE BRAKE PEDAL WENT FULLY TO THE FLOOR AND RESULTED IN LESS BRAKING THAN EXPECTED. DRIVER REDUCED SPEED BY DOWNSHIFTING TO LOWER GEARS (AUTOMATIC TRANSMISSION) AND PULLED INTO FIRST AVAILABLE PARKING AREA. BY PUMPING THE BRAKES AND PULLING INTO AN UPHILL PARKING SPOT, DRIVER ACHIEVED ENOUGH BRAKING TO COME TO A FULL STOP WITHOUT USING THE EMERGENCY BRAKE. INSPECTION SHOWED A NEARLY FULL BRAKE RESERVOIR AND NO LEAKAGE FROM WHEEL CYLINDERS. FURTHER INSPECTION SHOWED LEAKING FLUID FROM BRAKE LINE ON LEFT SIDE UNDER THE DRIVERS SEAT AND ABOVE THE VEHICLE FRAME. IT SQUIRTED OUT FROM A CRACK IN A BRAKE LINE WHEN BRAKE PEDAL WAS PUMPED. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS TOWED FOR REPAIR..0 person(s) were injured. 0 person(s) died.Mileage was 29000 miles. Vehicle Identification Number (VIN):1GAGG25U531. Chevrolet Express 2003 problem was reported in HONOLULU, HI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 45 mph.
     Report Your Car Problem      Go Top

Share, Email, Print

No comments have been provided.

CERTAIN VANS HAVE A CONDITION IN WHICH WATER MAY ENTER AND CORRODE THE REAR LICENSE PLATE LAMP SOCKET. IF THE LAMP SOCKET WERE TO CORRODE, THE REAR LICENSE PLATE LAMP MAY OPERATE INTERMITTENTLY OR NO...

CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RES...

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE V...

ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH. ...

ON CERTAIN VANS WITH A GROSS VEHICLE WEIGHT OF LESS THAN 8,500 POUNDS, DURING A VEHICLE CRASH SUFFICIENT ENOUGH TO DEPLOY THE SAFETY BELT PRETENSIONER, THE FRONT SAFETY BELT BUCKLES MAY NOT RELEASE AF...

ON CERTAIN VANS, THE RIGHT-HAND TIE ROD END NUT MAY NOT BE TIGHTENED ADEQUATELY. THE NUT CAN LOOSEN RESULTING IN SEPARATION OF THE TIE ROD FROM THE STEERING KNUCKLE. ...

ON CERTAIN VANS WITH AN 8,500 LB. OR 8,600 LB. GROSS VEHICLE WEIGHT RATING, THE NUT ATTACHING THE PITMAN ARM TO THE STEERING LINKAGE MAY NOT BE TIGHTENED ADEQUATELY RESULTING IN A POSSIBLE SEPARATION....

CERTAIN VANS WERE BUILT WITHOUT A WHEEL BEARING ASSEMBLY RETAINING NUT, WHICH COULD LEAD TO A POSSIBLE BEARING SEPARATION....

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURE...

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURE...

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DO...

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONF...

General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticu...

CHEVROLET EXPRESS 1500 2003

CHEVROLET EXPRESS 2500 2003

CHEVROLET EXPRESS 3500 2003

CHEVROLET EXPRESS 2003